Ford Super Duty (1999-2016) :: Cleaning Exhaust Filter Message Comes Up On Display For About 10 Seconds
Mar 21, 2013
I'm a new Powestroke Diesel owner. I recently (Dec. 2012) picked up a 2008 F-350 Crew Cab, DRW, 4x2 with a 6.4l automatic. Love the truck. Lots of power. Runs great. My question is; while driving, every couple of days the "cleaning exhaust filter" message comes up on the display for about 10 secs. I understand what that message means and what the truck is doing. What I don't understand is, why does the truck seem to run like crap after? It seems to be down a little on power and the idle surges until I shut it off and restart and then everything is fine.
It doesn't matter how long it runs after the DPF cleaning message displays. Also, three times now since I purchased it it has shown a different message, "drive to clean exhaust filter" followed by "cleaning exhaust filter". This message will stay on for many minutes. What is the difference between messages? Is the truck doing anything different? Is it ok to shut the truck off while either of those messages are displayed? The first time it happened I drove around for 15 minutes or so afraid to shut it off! Unfortunately the truck is obviously used and the owners manual was missing.
View 10 Replies
Advertisement
Is this the same thing as the regen? Got it for the first time yesterday at 775 miles. Just curious. On a related note, I've tried to run around town some with 5th and 6th locked out (speeds of around 55-60 on a regular basis, running about 2300-2500 rpms) to try to run this process...am I doing it wrong?
View 10 Replies
I got a 2 second "cleaning exhaust filter message" on my drive home tonight in my new truck with about 500km. I completed my drive and pulled off the highway into my yard. I don't know if it had finished cleaning yet but I unloaded the bed and then got back in the truck and drove another mile or two until the fuel economy was normal normal again.
The reason I did this was the underside of the truck was clicking and pinging as it cooled. You could smell the heat. Is it necessary to drive to complete this cycle? Or could I have just pulled in and shut it off. I'm sure it would finish on the highway in the morning. Other then the fuel economy increasing I couldn't tell anything else was going on.
View 14 Replies
I've been having frequent, low speed, short trips lately and have been seeing the 'Cleaning Exhaust Filter' message pop up. Given that I have only been mere minutes from my destination in each case, I thought 'good luck with that'.
Today I see the 'Drive to Clean' message, followed by the 'Cleaning Exhaust Filter' message which stayed on (I have been used to it appearing for only a second or two.)
It should all be fine tomorrow though as I have a longer trip planned.
View 6 Replies
New to Diesel trucks, have a 2012 F250 with 4000 miles on it. for the first 3000 miles I would see regular messages about "Cleaning Exhaust Filter" about every 100 miles or so, but this last 1000 miles I have not seen any?? I drive about 100 + miles a day, 55 to 65 mph so I'm sure I'm running it long enough.
The other thing I've noticed is that my MPG has gone from 17 down to 14 which is what I would normally see during a cleaning cycle. It almost seems like I'm in a constant state of cleaning as my MPG has taken a dive... Any things I should check?
Side note, I towed a 30ft RV around the 3000 mile mark, since the tow I haven't seen the message.
View 14 Replies
Last week I picked up a 2016 F-350 with the 6.7 diesel. Since then I have put about 4500 miles on it and gone through 2 or 3 regenerations. About half the miles were empty, half were with about 1500lbs of cargo in the bed. Mostly interstate driving at about 70mph.
However, every time the "cleaning exhaust filter" message comes on in the screen it feels like the truck looses all power for a second. The first time I was going up hill with cruise control set at 70 and it felt like stomping the brakes then hitting the gas all within a second maybe.
View 14 Replies
First 11,000 miles on this 2015 F-350 6.7 diesel was a love affair last 2,000 miles I hate the damn thing it has been in the shop three times in the last month. Exhaust filter over loaded drive to clean. Will not clean while towing a load gets to limp mode. What do I do leave trailer on side of road in order to regen and then go back to pick it up?
View 14 Replies
My truck started to display exhaust filter clogged and cleaning exhaust filter multiple times today. The cleaning exhaust message stayed on until I hot OK and then it comes back later. Not sure what this means?
View 14 Replies
Every time I put the truck in reverse, I get a "Check Rear Park Aid" message on my display.
I tried wiping all of the sensors clean, and I checked the electrical connections and all seem to be fine.
View 9 Replies
I have a 2001 f250 5.4 that when you turn the heat on the trucks motor and exhaust bog down for a few seconds then comes right back up...
View 4 Replies
So there I was doing a simple oil change and when I took the filter out I noticed the little spring on top, in the center of the big spring (oil filter adapter) cocked to the side with the little plastic piece broken.
does anybody know if I can replace just the oil filter adapter (spring thingy that goes in the middle of the filter when installed) or do I have to replace the whole filter bowl assembly? And if so where would be a good place to get this part?
View 5 Replies
Changing tranny fluid/filter today, all has been going great until I went to take the filter o-ring out that didn't come with the filter. It will not come out! made a hook tool out of an old tooth brush like someone on here did, o-ring wont budge. Tried a hook pick, it wont dudge (actually bent the tip on the pick and started to tear the o-ring). Everything is ready to go back together and get filled, but this stupid o-ring will not come out!
View 3 Replies
On my previous 1992 F-350, when I serviced the E40D 2WD trans I replaced the filter during a trans service. I read about some filters falling down inside pan causing shifting issues. There is an aftermarket clip sold that holds the filter in the up position and prevents it from falling into pan.
Is the clip also used on the 2WD 4R100? is it the same issue of potentially falling down in pan as was the case with the E40D? Preparing to service my 2003 F-350 2WD 4R100 and install a new filter and want to be sure I have all parts/supplies ready to go.
View 13 Replies
After replacing fuel filter, pump relay, and air filter for good measure my 2002 f250 v10 gas engine still wont start. What to do?
View 13 Replies
I have a 2015 F250 with a 6.2L and want to clean my throttle body. I have done several before on other vehicles but, just figured I would ask before I just jump in there. Cleaning throttle body on their 6.2L?
View 5 Replies
I have an 04 lariat f350 and after cleaning the steering wheel it is a bit sticky.... What the material is?? Or how to resolve the sticky issue??
View 8 Replies
Cleaning the evaporator on a 03 F250? A buddy of mine cleaned his F150 and said it made a noticeable difference. I was thinking of trying it on mine. If you have, whats the easiest access? Any recommended cleaner?
View 2 Replies
I recently bought a certified used 2012 F-350 a couple of weeks ago. I was reading the diesel insert in the owners manual and came across the exaust filter cleaning notification. I have already put almost 3000 miles on the truck and have yet to see the notification. My brother has a 2013 and said that his comes on every week. I don't know what the previous owner did to the truck, if anything. It is very clean and everything else is stock. I am averaging over 19 mpg combines and it runs great. This is my first diesel truck and I am certain that I will never go back to gas.
View 14 Replies
New truck does it's first regen at 100 miles!
I Experienced my first REGEN last night. We were on the highway for about 20 minutes at 55 MPH when the dash lit up "Cleaning Exhaust Filter".. The odometer was at 100 miles and it lasted until 115 miles. The fuel economy dropped from 14.6 to 13.9 pretty fast.
There was no notification when it was done with the Regen other than the instant fuel economy gauge climbing pretty quickly.. So 100 miles on it and it was already sooted up??? Is that uncommon?
View 4 Replies
In the last year I've had a NOX sensor fault (dealer repaired) and a DEF heater fault (I replaced). I'm now getting an EGT sensor fail. Every fault is with the same system.
I'm also realizing that while I'm getting the exhaust system cleaning message, my DEF level is not being depleted.
All the dealership wants to do is change out fault codes but I think the true issue is elsewhere.
2011 F250 SD FX4 6.7L (stock)
View 4 Replies
My 6.0 powerstroke will not start at all. I changed the rail fuel filter and the oil and oil filter. All oem for caps and filters. But the fuel filter in the engine bay is stuck. I didn't change the filter and I don't think I put diesel on the o ring to lube it. Could this be why it's not starting. I tried using starting fluid aswell no good
View 2 Replies
