So just about every trip that's over 20 minutes I'll get a smell, seems like it's coming thru the vents and it smells like burning wires or like you turned on your heat in your house for the first time of the year.... Is this normal??
View 10 RepliesWhen starting up my 2011 F-250 Gas, I have a burning smell coming from my vents for about a minute then it goes away. It smells like new electronics. My A/C seems extra cold as well. We just got back from a 3800 mile vacation. Its been going on now for about 3 weeks and never changes...
View 6 RepliesI have a 2002 ford f350 triton 5.4 V8. I just put front brake pads on my truck today. Started driving around and i could smell burning brakes. Stopped and alot of smoke was coming from my brakes on my front passenger side but nothing from the front drivers side. Replaced all the brake pads on the front. What is making them so hot?
View 8 RepliesI have a 2000 F250 SD 4x4. I noticed the other day that after driving the truck for 10 miles or more and then stopping and getting back in it feels like the parking brake is on. I drove the truck home and on my way back I smelled brakes burning but it wasn't pulling while driving or braking. When I got home I put my head in the wheel well to get a look at the brakes on the drivers side it seemed ok, but when I did it on the passenger side it was hot as Hades! It's been my experience that if the caliper is hanging up it will pull either while braking or regular driving. I just want a better idea before I go ahead and buy a new caliper and hose and tear the dang thing apart.
View 8 RepliesI just got this truck and didn't have any strange odors other than brake caliper which got replaced immediately. I got 4 new Mastercraft AXT tires last week and two days before that I got a muffler installed. I put a flowmaster on it (black) Now if I drive it about three four miles, I get a smell coming from somewhere which I can't locate because nothing is hot and it goes away within a few minutes so I cant pin point it. At first i thought it smelled like rubber heating up, but now not sure. I may take it back to tire dealer and have him check all the tires for balance. I had them do an alignment, so I would hope it isn't that. The smell came with the new tires I think....I had the exhaust worked on two days prior to that and didn't notice anything after that. I haven't checked anything else, but there isn't anything hot when I jump out and start sniffing around. Would tires do that if NEW or out of balance?
View 8 RepliesFor the first time while towing a bumper pull trailer, started getting a very strong burning smell, only while going up decent size hills. After the climb, smell goes away. Kind of smells like burning rubber or wiring, but that should be constant and not just while up hill.
Checked tranny fluid and it didn't look burnt or low and never saw visible smoke. Have seen this discussed before but with no definitive conclusions. Truck has 150K on it and has long ago lost most of its towing power and the hills also drop the speed to around 45mph from 70 when I hit the big ones.
2005 F350 Lariat crew cab a few weeks back.
My question.... I noticed a strong ammonia/super glue like smell floating around in the cab about the 3rd time i drove the pickup. Since then, it seems to do it intermittently. My first assumption was it was coming through the vents. I have done a couple experiments, and I don't believe this is the case. My wife and I were driving yesterday and she thought she noticed the smell again. while I was driving she started checking all the vents, and nothing. But when she leaned clear down near the speaker hole in the door, she said she could really smell it.
What could be causing this? I'm assuming if it was the AC it would be coming though the vents. And at this time, I don't think it is.
I have an 04 f250 with a 5.4 I smelled something like burning and the truck shut down. the fuse panel was warm. after a min or so it starts back up never know how far till it stalls again.
View 4 RepliesThe wife and I ventured out last Friday evening to run a few errands. When we returned to the house and pulled into the garage, we both smelled burning brake pad. I felt the rear wheels, the drivers side was too hot to touch.
Dragging brake caliper. I got online and reserved a drivers side caliper and a set of pads at NAPA. Saturday morning I removed the caliper. Much to my surprise, one of the caliper pistons was broken into multiple pieces.
I took the offending caliper to NAPA and picked up the new caliper and a set of pads.
Side note - NAPA seems to think the 2007 trucks have calipers that mount in front of the axle, not behind the axle. They will try to sell you a passenger side caliper and tell you it is a driver side caliper. It will bolt up fine, but the bleeder valve will be at the bottom of the caliper instead of the top. You'll never get the air out of the caliper.
Got back home, bolted up the new caliper and pads, then bled the system. All worked well.
I decided to throw new pads on the passenger side brakes as well, since I had 2 remaining. I took off the passenger side caliper, much to my surprise I found a cracked and broken piston on that side also! Another run to NAPA to pick up another caliper. Installed, bled the system again, all working well.
Now, I have never seen a cracked and broken caliper piston like this, let alone one on each side of the rear axle. What might have caused this? About a year ago I had a shop install new backing plates. The pads and calipers are about 3 years old, same shop installed those.
I know this has been talked about many times and how to solve the issue but thought I would ask some other questions too. Earlier in the summer, I did grease the slider pins as preventative maintenance. I don't drive my truck all that much and when I used it yesterday, (about 30 minute drive) I came home to burning brake smell. I'm wondering if enough heat would cause the caliper to go bad? Should I just grease the pins again or change out some parts?
View 6 RepliesI have had the truck just under a year. It has 104k on it i only drive it on weekends. Last weekend going to Home Depot about 15 miles got out and could smell brakes burning. Felt the wheels and the right rear was very hot. Got back home no smell but still hot not as hot as earlier. Pulled the wheel off it looks as if the pads and calipers are fairly new paint is still on them caliper is a TRW. The pads were stuck in the carrier even the stainless clip ends look rusted.
Cleaned it all up both sides lubed the pad carrier with pin lube. Pushed the calipers back in some both sides went in easy. The right rotor has definitley been hot. Put it all back together and went for a test drive. Came back no problems checked the temperature with a laser type heat thermometer all wheels were around 140 f. Went out yesterday morning stopped and could smell the brakes again. Drove it back home and the right rear was 300 f. others 150 to 160 f.
Jacked it up put it in neutral and the you can spin the wheels by hand. Started the truck had the wife get in put it in drive wheels turning applied the brakes they stopped let go they turn freely again tried the parking brake it works fine also. So do I buy new calipers and brakes or maybe is the wheel bearing going bad causing the brakes to heat up?ied.
I pulled into my driveway after a 30 minute drive and smelled burning brakes. The right front was the culprit so I took a garden hose and cooled it down. The next day I remove the caliper and one of the pistons fell apart. So I need a new caliper and trying to decide if I buy after market or go with Motorcraft? I think the rotor, caliper, and pads are original since I the rotor is stamped Ford and the caliper bracket has TRW and Ford markings.
View 12 RepliesMy a/c vents smells musty/moldy when A/C is turned on, searched the FTE site and everyone says to check the A/C drain tube to make sure it is not clogged, I have searched all over top and bottom with a flashlight for the drain tube and swear there isn't one. I think it should be on the bottom of the condenser box but just do not see it. Where it is located? The vent smell is Awful!
2000 F350 Super Cab 7.3 Diesel
Recently purchased a CPO 2009 F250SD 6.4L. Happy with the truck overall but this AM I noticed a slight burning plastic smell so I opened the hood and looked around closely. Didn't really find the culprit(I don't think) but noticed that the engine compartment heat shield/barrier appears to be falling down above and behind the turbos (pictures linked below). How big a deal is this? Would it be covered under the CPO warranty? It almost seems like a safety issue. I also wonder if the insulation material, now exposed without the metal reflector material, is what is causing the smell....
View 14 RepliesI have a 2005 Ford F-250 Diesel 6.0 my ac works fine but after working a while the air quits coming out of the vents. It happens every time I go on a long trip with the ac or heater. Is like if a duct damper closes because I can hear the motor blower going. The entire ac system is new but it was doing this with the old system....
View 5 RepliesI just picked up a 05' F450 Super-Duty it had the rear seat removed and the rear wall, under the window is bare metal. I have all kinds of road noise and dust coming in through the two vents on the back wall. How to fix this?
View 6 RepliesMy 1999 F 250 5.4 liter. I know I have a vacuum leak because whenever I accelerate the air conditioning coming from the vents switches to the defroster. So my question is how do I go about finding the leak? My hubs in the front are manual so I know I don't have lines going up there. I do have some mechanical capabilities I've changed water pumps alternators brakes etc. But never anything with vacuum lines or a/c.
View 14 RepliesFor the past month or so I've noticed that there are a few strange smells coming from the air vents on my GTI. Firstly, if the car sits for awhile and then is started it smells like that model airplane glue or some kind of strong adhesive inside the cabin. It goes away rather quickly. The second one worries me more. When I run the car hard for a few minutes (higher speeds, highway pull or two, etc.) and then come to a stop at a light, there is a very distinctive "burning" smell. It might sound gross, but the closest thing I can think of that smells like it is the smell in a dentists office when you're getting a cavity drilled out of a tooth.
View 7 RepliesWhen stopped at lights I start to smell burning oil coming from the vents when I have the heat on. It only happens every now and then and only when you are stopped at a light. I tried letting the engine idle after driving once and I can't smell it when i open the hood. I do synthetic oil changes every 5,000 since the car was new. I don't know what it could be? My last oil change was about 2,000 miles ago so I can't see it being burn off from the last change still.
View 4 RepliesSo I bought this truck a year ago and the guy had his fog lights re wired to another switch under the dash and had a brake controller wired in (that's what I think it's called) the fog lights worked for a month then just stopped working there's a rats nest of wires under the hood for the fog lights too. The brake controller never worked.
My main question is what are the wires that are hanging down under my dash that look like someone snipped ....there's a random green wire attached to one and just hanging
So I was sitting in my car, running, parked with the ac on and out of no where I got an electrical/burning smell coming from the vents. My volts were reading 12 with ac on at idle but once my rpms reach about 7-800 it goes back to 14. My question is what was that smell? I've had 2 alternators go on this car (power draining aftermarket accessories 3.3 v6) and have driven the car for about 2 hours collective time since the problem started (usually alternator goes quick) and haven't noticed any lights dimming, ac blows cold, system still plays full tilt. could a bad compressor be causing putting some stress on the car?
View 8 Replies