Ford Super Duty (1999-2016) :: 2015 F350 - CEL On - Glow Plug Relay?
Jul 26, 2015
I have a new f350 with 1500 miles and the check engine light came on. Took it to dealer he said it was the DEF heater. He replaced that part and then it came back on and now its the GLOW PLUG RELAY MODULE. Now for the good part. Ford told dealer that I could drive the truck with the CEL on. Ford stated that they were remanufacturing the glow plug relay and that is was not available at this time and not sure when it will be ready. I filed a complaint with ford, but with little success. Not sure what else to do about this issue.
View 2 Replies
Advertisement
I have an 04 F350 with Glow Plug errors on cylinder 2, 4 and 8. I have already replaced the harness on that side because the old one was gunked up pretty bad. Still have the same issue. Does this sound like a GPCM issue to ya'll?
AE pulled the following codes:
P0672 Cylinder 2 Glow Plug Circuit
P0674 Cylinder 4 Glow Plug Circuit
P0678 Cylinder 8 Glow Plug Circuit
Not having issues starting but it rarely gets into the 30's here in FL.
View 2 Replies
I have a 2003, f-350, 6.0L with a K&N Filter. While driving the glow plug light comes on and the power is shut down. After a few seconds the power comes back and it won't do it for a while. No codes. I replaced all of the glow plugs and wires. What's causing this?
View 3 Replies
Okay, I just bought the truck (all stock except for straight pipe and cai). Nothing bullet proofed yet. It has 125,xxx miles on it and for the 4 months I had it I had no issue. Well now while idling or driving the glow plug light will flash on then off and stay off. I'll have no power and after a few minute it'll die on me. But start right back up. Is this a harness issue? 2006 6.0.....
View 2 Replies
i was replacing my glow plug relay and my ratchet hit one of the small wires and sparked. i went in the truck and I heard a really fast clicking noise at the fuse box. I opened it up a very top small relay was the one clicking. i replaced it and it still clicks. the truck is TOTALLY DEAD no power to anything. I checked ALL the fuses under dash and under the hood, they are all good. both batts are at 12. 9 volts. what would kill the whole truck like this. is there a main fuse somewhere? I really need to get this going tonight. it's gonna rain all day tomorrow and this is my only Tow Truck for my business.
View 14 Replies
2005 F250 6.0L ... My truck is running really rough when the engine isn't all the way quite warmed up. once the truck is fully warmed up to normal running temp it runs good. I am getting four engine codes. P0672, P0673, P0674, P0676 These codes say 2,3,4, and 6 glow plugs have a open circuit. Can this be the cause of my problem?
View 7 Replies
My 2004 F350 would not start yesterday, for the second time. I had just been driving it 30 minutes before, but when I tried to start it nothing happened. The dash light came on but nothing else, not even a click. Had to leave it overnight, and this morning it started completely normally. what this might be? It seems kind of like a relay or reset that was cut off and took time to reset itself. The first time it happened, it started up after 20 minutes, but yesterday it still wouldn't after an hour at which point I had to go to work so I don't know what the interval would have been if I could have stuck around and continued trying it.
View 6 Replies
2003 f350 5.4... Is the fuel pump relay behind the radio? Under hood? Or built in the fuse panel and unserviceable?
View 14 Replies
2015 F350 6.2, 4 door 8' bed FX4...... 17,200 miles.
This morning when outside to start it (nice sunny morning) and turned the key and all the dash lights went on and also went crazy. Said it had all kind of problems on the dash, Trac system, Over heating and so on. The starter did not crank over at all. Tried this about 8 times in 45 minutes, no worky. Call Ford, they towed it to the dealer. I last drove it 2 days ago. All stock, no programmer.
View 12 Replies
Just got a new 15' 350 XL and going thru the 'setup' button on steering wheel, there is a toggle option for power windows. got out the old owners manual and heres what it does. when toggled to 'on position' and you unlock doors with the ignition key, you can immediately press and hold the unlock button again and both front windows go down automatically. this of course is for models equipped with power windows and door locks. dont know why we need this option but it'll roll your windows down for you from afar.
View 14 Replies
How many Volts available at plug for charging FW batteries, and what can be don to trick alternator in to keep charging when truck batteries full, install larger wires? From alternator or truck battery, if yes which battery. 2015 F350 Lariat 200 alternator.
View 14 Replies
2015 F-350 diesel purchased in Sept 2014. When moving slowly such as turning a corner and I have to let up on the accelerator momentarily, when I press down again there is nothing for an unsettling period of time, maybe 2 seconds, as though the engine died, but it didn't and it always comes back. Is there a firmware programming update for this?
View 3 Replies
My 2015 f350 6.2 truck started making this whine noise..... Sounds like a bearing..... Stops at 40 seconds.. [URL] .....
View 14 Replies
I have a new 2015 F350 XLT. For the life of me I cannot open the lid on the center arm rest. I have read the manual, and I can't open the lid. This is my 5th Super Duty with the last being a 2010. So you would think this would be a no brainer. I can pull on the handle and its not opening. Pry the damn thing open? Is there a hidden lock? Hidden treasure?
View 14 Replies
I recently graduated from a 2010 f150 XLT with F250 tow pkg to a 2015 F350 and am not liking the steering. I have owned the F350 for about 2 months and I have about 2500 miles on it. The more I drive it the more I hate the steering. The steering just seems loose and "squirrely" to me. I even took it to the dealership at a 1000 miles saying something is wrong and they said everything checks out. They, of course told me, it's because I'm used to the steering in my F150. I even told them to check the alignment because it didn't seem right.
I don't know if it's in my mind, but I keep feeling/hearing like something is loose on the front end, especially when I brake on road bumps. I thought maybe it was the ABS kicking in, but I don't think that it. I cannot pinpoint the noise and it's hard to replicate it, so it'll be difficult to get that across to the dealer. Any problems with the steering?
View 14 Replies
2015 F-350 diesel purchased Sept 2104. When towing my 16,000 lb 5th wheel the 6 to 5 downshift seems to have gotten much harsher in the last few months. About 10,000 miles on the truck, much of it towing. Is this an indication of a developing problem?
View 1 Replies
Putting in a locking axle to replace there non locking axle? Have a 2015 f350. And found a electric locking for a great price. Can this swap be done?
View 14 Replies
I have a 2015 F350 and with the long dark hours of driving, I want to put some auxillary lights on the front of my truck. I have a ranch style bumper on the front and I am thinking about installing a pair of flush mount LED driving lights. I was wondering, how well they work? I am personally thinking about the rigid flushmount hybrid driving/flood lights with the focused beam.
View 6 Replies
My 2015 F-350 Super Duty has a noticeable vibration between 5 and 15 mph when accelerating with my 5th wheel. The 5th wheel is heavy--around 14000 pounds. The pin weight is heavy--around 3000 pounds. The Owner's Manual says on page 191 "When driving with a trailer or payload, a slight vibration or shudder may be present due to the increased payload weight..." (This was brought to my attention by my dealer.)
Seeing the thousands of F-250 and F-350 Fords pulling 5th wheels out there on the road, I wonder how many have this "slight vibration or shudder" and what they have done about it.
View 11 Replies
The water pump on my 2015 350 (6.2L) failed this morning and the dealer says it needs to be replaced. What might have caused it?
View 6 Replies
Went to change the plugs on an 02 f350, the bolt holding the plug wire boot on doesn't seem to fit any standard size socket. 7 is too big, 6 is too small. 1/4 is too small, 9/32 is too big.
View 14 Replies
