I just brought home an 04 F350. It is a V10, 6 speed, with 30,600 verified miles on it. It runs and drives fantastic, and that V10 is impressive! I am very impressed. I have noticed that the compressor cycles, even with the dial in the off position. Is this normal for the super duty, or is something amiss? If something is wrong, what direction do I look in?
View 13 RepliesTrucks compressor kicks on and off and won't stay on no cold air at all do i have a leak ? The truck came whit a new canister that mounts in front of the air box could it be that?
View 8 Replies2003 F350 6.0L ... 171,000 miles ... 5,100 since oil change 15W-30 at the shop ...
I was driving on the interstate (50 miles of driving) struggling to maintain 70-75 mph at 2,200RPMs. I would accelerate and RPMs would go up to 3,000 but no speed. Before I could pull off speed slowed to 50 before dying. Sat on the side of the road 30 minutes before I could get it started. Had to give it gas. No misfires just quietly started. Couldn't go over 30 mph. Towed it to my destination 135 miles.
Volts on 7Pin FICM read fine.
Checked the fuel fulters. Air Filter. Tank for debris. Nothing.
My coolant reservoir was lose and I noticed a lot of coolant in the driverside front wheel well and down the left side of the undertruck. Reattached after checking FICM. Hope that was all it was cause I couldn't find any leaks.
I had Planned to have the oil changed before the return trip before this all happened. New to Diesel engines but I like a challenge. Where do I go next?
The heater blower in my 1999 F350 continues to run after the switch is turned off. I checked the relay and it is working properly. Looking for a wiring diagram showing the control circuit for the blower?
Do the heater switch controls power to the relay coil or if the switch grounds the coil to pick up the relay?
2002 f-350 diesel 4x4 7.3l. It stalls out a few times lately( and starts right back up) and it runs rough like there is an air bubble then smooths out. Changed 1 fuel filter and the pcv valve. 96,000 miles.
View 6 RepliesSeems like my 2001 f350 7.3 has an ac freon leak on pass side near compressor. AC is blowing coolish air but not cold like is should be. There is green like oil around main line leading out of ac compressor. I have attached several pics to illustrate situation.
View 7 RepliesEvery time I connect the battery I get a clicking under the dash its non stop until I remove the battery cables. just when I remove the left passenger side battery. When I put in the key while its clicking and try to start its almost like I have no power the needle just drops down to nothing. The batteries have a full charge I pulled them off and charged over night also brought them in and had them tested. Seems like a serious short in the electrical but that clicking under the dash coming from fuse box scares me. I did pull all the relays and it still clicks.... doesn't sound good! 1999 F350...
View 5 RepliesEvery time I apply brakes I hear a weird humming noise, as well as no stopping power. Checked fluids and pads and everything is where it should be. I heard abs can cause this but not sure on that. I know my master cylinder has a very small leak but it hasn't lost any fluids of that sort. I'm lost. I don't know where else to look.
View 2 RepliesMy 2011 F350 is shaking like a wet dog, all the time, loaded with a trailer and empty. It's the whole truck, not just the front end or rear end. It'll shake a Dr Pepper flat in 10 mins. No one can figure out why. Maybe y'all can think of something.
Here's what we've done
New tires, balanced
Alignment
Replaced ball joints and sway bar
Replaced carrier bearing
Replaced passenger front hub that got mysteriously locked and henceforth destroyed.
Replaced all 4 shocks
Where to look next?? Guess I should mention is 4x4 dually with 177,803 miles.
I have a 2002 f350 7.3 PS that every time I touch the brake pedal it blows the #6 fuse(trailer tow brake/turn signal). I need to use my trailer.
View 14 RepliesI just installed a set of power folding mirrors on my 2008 F350. I noticed that the driver side mirror has a longer travel time than the passenger side. How to fix, or why this is like that? Is it normal? watch the video to see what I mean.
[URL] ....
2004 F250 V10, runs good until it warms up whether it's hot or cold outside. While on freeway, it really shakes while cruising, but of you get in the gas enough for a kick down, seems to be pretty smooth. I've changed the coils, and 9 plugs (one wouldn't budge, but the others I took out looked fine) to no effect. Where else should I look? Also, no CEL, and no codes, which seems odd as bad as it feels...
View 11 RepliesSo, my truck runs really rough when I am @1500 RPM and lightly feather the gas. I have replaced all coils and plugs. Used dielectric grease. Replaced air filter, replaced ICU, changed transmission fluid. The thing still "shudders" ... 2004 f250 5.4 ....
View 14 RepliesI have a 2004 F350 with the V-10 with a Fleetwood motor home on it. 46000 miles.The fuel pump started acting up and i have low fuel pressure. after a lot of testing i replaced the pump and all the hoses on top of the tank. of course you have to pull the tank to do this.
Nothing was touched to my knowledge that has to do with the ABS system.
After everything was put back together and i started the motor. the ABS light came on as usual during the pre-check then went off, and after a couple of seconds came back on, and stays on. it does this each time its started.
I read the most common problem is the rear speed sensor i tested it and it measured .95 oms so i replace it. the new one measures 1.8 oms.
Light is still on. so today i will be testing the front. to insure they are good. The fuses tested OK. My question is what else should i be checking?
My 2004 F350 6.0L v8 has a weird shake when I get between 45 and 55 mph. Doesn't feel like its the tires, feel like the engine. I think I might have the #5 glo plug out. Is that it or could something else be wrong? If it is this how bad is it to drive on.
View 4 RepliesI have a 2004 F350. I go out to start my vehicle and it may or may not turn over. Other time it starts fine
View 1 RepliesOn dads 04 f350 the 4wd first wasn't shifting to 4lo. Would do 4hi and 2wd fine. Then motor on t-case went bad. Replaced motor 2wd and 4hi still good still no 4lo. Then just 2wd so we unplugged t-case motor and power probed motor got it to do 2wd, 4hi, and 4lo. So we thinking bad dash switch but power probed it and its working fine. So we r thinking VP4C3F-14B128-A/ chassis computer bad just behind/above glovebox. R there any test we can do to confirm its bad? We called local junk yards to see bout getting one, nobody had one. If this is indeed bad where is cheapest get one? What all years use this certain chassis computer??
View 5 RepliesTruck started to feel like it was missing here and there. A couple rough starts in the morning and a very potent exhaust smell at startup. Then finally after a couple days of this, it wouldn't start.
At first it would try to turn over and almost did several times, then it degraded to just churning and churning with no close attempts to turning over. No codes thrown when we hooked up the code reader. I've had the IPR go out on me twice, the churning and churning is how it acted when the IPR(s) had gone out.
Towed it home and pulled the IPR, everything looked in order with it. Changed the upper fuel filter and oil/filter in an attempt to rule out the easy stuff. Tried to start it up last night after doing this and it churned and churned for awhile (about 2 minutes), then it almost turned over several times. By this time the batteries were too low to continue. Hooked up the code reader again and still no codes.
I'm planning on charging the batteries and replacing the lower fuel filter today, but not feeling real optimistic that it will do the trick. Any other issues to check for?
Well long story short, I had the the factory hubs in my 04 f-350 and I was driving down the road and it started making this horrible popping noise. So I pulled over and couldn't find anything and just curiosity locked in the hubs and all was fine. Made me think my hubs were bad, so I went and bought the warren premium hubs, installed them. Went for a drive and still the same noise is there when they are in free spin. But once they are locked in its fine. What this could be? Wheel bearings?
View 4 RepliesMy 04 F350 has a bad shudder when slowing down between 30 and 10 MPH. Not so noticeable at other speeds and almost nothing while speeding up. How to fix?
View 1 RepliesThe transfer case on my 2004 F350 6.0L 4WD DRW, 230K miles, just blew to pieces Sunday night. See images below. What could cause this?
I just had the front drive shaft rebuilt with new universals and ball. It was making a metallic squealing noise after this.
I noticed that the front drive shaft did not spin freely when parked in nuetral and set for 2WD. I thought the front drive shaft would only engage when in 4WD.