I have an 04 f250 with a 5.4 I smelled something like burning and the truck shut down. the fuse panel was warm. after a min or so it starts back up never know how far till it stalls again.
View 4 RepliesI have a 2000 F250 SD 4x4. I noticed the other day that after driving the truck for 10 miles or more and then stopping and getting back in it feels like the parking brake is on. I drove the truck home and on my way back I smelled brakes burning but it wasn't pulling while driving or braking. When I got home I put my head in the wheel well to get a look at the brakes on the drivers side it seemed ok, but when I did it on the passenger side it was hot as Hades! It's been my experience that if the caliper is hanging up it will pull either while braking or regular driving. I just want a better idea before I go ahead and buy a new caliper and hose and tear the dang thing apart.
View 8 RepliesI just got this truck and didn't have any strange odors other than brake caliper which got replaced immediately. I got 4 new Mastercraft AXT tires last week and two days before that I got a muffler installed. I put a flowmaster on it (black) Now if I drive it about three four miles, I get a smell coming from somewhere which I can't locate because nothing is hot and it goes away within a few minutes so I cant pin point it. At first i thought it smelled like rubber heating up, but now not sure. I may take it back to tire dealer and have him check all the tires for balance. I had them do an alignment, so I would hope it isn't that. The smell came with the new tires I think....I had the exhaust worked on two days prior to that and didn't notice anything after that. I haven't checked anything else, but there isn't anything hot when I jump out and start sniffing around. Would tires do that if NEW or out of balance?
View 8 RepliesFor the first time while towing a bumper pull trailer, started getting a very strong burning smell, only while going up decent size hills. After the climb, smell goes away. Kind of smells like burning rubber or wiring, but that should be constant and not just while up hill.
Checked tranny fluid and it didn't look burnt or low and never saw visible smoke. Have seen this discussed before but with no definitive conclusions. Truck has 150K on it and has long ago lost most of its towing power and the hills also drop the speed to around 45mph from 70 when I hit the big ones.
When starting up my 2011 F-250 Gas, I have a burning smell coming from my vents for about a minute then it goes away. It smells like new electronics. My A/C seems extra cold as well. We just got back from a 3800 mile vacation. Its been going on now for about 3 weeks and never changes...
View 6 RepliesSo just about every trip that's over 20 minutes I'll get a smell, seems like it's coming thru the vents and it smells like burning wires or like you turned on your heat in your house for the first time of the year.... Is this normal??
View 10 RepliesThe wife and I ventured out last Friday evening to run a few errands. When we returned to the house and pulled into the garage, we both smelled burning brake pad. I felt the rear wheels, the drivers side was too hot to touch.
Dragging brake caliper. I got online and reserved a drivers side caliper and a set of pads at NAPA. Saturday morning I removed the caliper. Much to my surprise, one of the caliper pistons was broken into multiple pieces.
I took the offending caliper to NAPA and picked up the new caliper and a set of pads.
Side note - NAPA seems to think the 2007 trucks have calipers that mount in front of the axle, not behind the axle. They will try to sell you a passenger side caliper and tell you it is a driver side caliper. It will bolt up fine, but the bleeder valve will be at the bottom of the caliper instead of the top. You'll never get the air out of the caliper.
Got back home, bolted up the new caliper and pads, then bled the system. All worked well.
I decided to throw new pads on the passenger side brakes as well, since I had 2 remaining. I took off the passenger side caliper, much to my surprise I found a cracked and broken piston on that side also! Another run to NAPA to pick up another caliper. Installed, bled the system again, all working well.
Now, I have never seen a cracked and broken caliper piston like this, let alone one on each side of the rear axle. What might have caused this? About a year ago I had a shop install new backing plates. The pads and calipers are about 3 years old, same shop installed those.
I know this has been talked about many times and how to solve the issue but thought I would ask some other questions too. Earlier in the summer, I did grease the slider pins as preventative maintenance. I don't drive my truck all that much and when I used it yesterday, (about 30 minute drive) I came home to burning brake smell. I'm wondering if enough heat would cause the caliper to go bad? Should I just grease the pins again or change out some parts?
View 6 RepliesI have had the truck just under a year. It has 104k on it i only drive it on weekends. Last weekend going to Home Depot about 15 miles got out and could smell brakes burning. Felt the wheels and the right rear was very hot. Got back home no smell but still hot not as hot as earlier. Pulled the wheel off it looks as if the pads and calipers are fairly new paint is still on them caliper is a TRW. The pads were stuck in the carrier even the stainless clip ends look rusted.
Cleaned it all up both sides lubed the pad carrier with pin lube. Pushed the calipers back in some both sides went in easy. The right rotor has definitley been hot. Put it all back together and went for a test drive. Came back no problems checked the temperature with a laser type heat thermometer all wheels were around 140 f. Went out yesterday morning stopped and could smell the brakes again. Drove it back home and the right rear was 300 f. others 150 to 160 f.
Jacked it up put it in neutral and the you can spin the wheels by hand. Started the truck had the wife get in put it in drive wheels turning applied the brakes they stopped let go they turn freely again tried the parking brake it works fine also. So do I buy new calipers and brakes or maybe is the wheel bearing going bad causing the brakes to heat up?ied.
I have a 2002 ford f350 triton 5.4 V8. I just put front brake pads on my truck today. Started driving around and i could smell burning brakes. Stopped and alot of smoke was coming from my brakes on my front passenger side but nothing from the front drivers side. Replaced all the brake pads on the front. What is making them so hot?
View 8 RepliesI pulled into my driveway after a 30 minute drive and smelled burning brakes. The right front was the culprit so I took a garden hose and cooled it down. The next day I remove the caliper and one of the pistons fell apart. So I need a new caliper and trying to decide if I buy after market or go with Motorcraft? I think the rotor, caliper, and pads are original since I the rotor is stamped Ford and the caliper bracket has TRW and Ford markings.
View 12 RepliesRecently purchased a CPO 2009 F250SD 6.4L. Happy with the truck overall but this AM I noticed a slight burning plastic smell so I opened the hood and looked around closely. Didn't really find the culprit(I don't think) but noticed that the engine compartment heat shield/barrier appears to be falling down above and behind the turbos (pictures linked below). How big a deal is this? Would it be covered under the CPO warranty? It almost seems like a safety issue. I also wonder if the insulation material, now exposed without the metal reflector material, is what is causing the smell....
View 14 RepliesStrange thing happened today while driving down the highway while towing my camper. I was going down the road with the cruise control set at 65 mph and I looked at the dash and I had no tach, speedometer or gauges. The dash was blank. The radio was still playing and I was just coasting to a stop. When I finally pulled to the side of the road, I put the truck in park and turned the key to the off position. Turned the key and it started right up and ran fine for the next 2 hours on my trip. I had been towing for about 3 hours before the truck shut off. Don't want this to happen again as I'm towing back home from FL to CT.
View 14 RepliesI have a 2003, f-350, 6.0L with a K&N Filter. While driving the glow plug light comes on and the power is shut down. After a few seconds the power comes back and it won't do it for a while. No codes. I replaced all of the glow plugs and wires. What's causing this?
View 3 RepliesAbout a week ago I began smelling coolant after driving my 2012 F350 6.7. Yesterday I noticed a small amount of coolant on the ground and decided to take it to the dealer. As soon as I told the Service Manager what was going on he said......"You need to leave it......there is no doubt in my mind it needs a radiator". They pressure tested and and sure enough it does. He said they are replacing about 2-3 a month but there is no recall.
Here is where it gets fun. Apparently radiators fall off at 36,000 miles and are not included in the 100,000 Power Train Warranty. It gets better. The Radiator is on national back order for 5-6 weeks.
While driving up hill at 60mph the truck lost power. Rpm jumped up as to change gears as it hit 55mph. Still losing power until it shut off. I tried to restart and just got a click from the solenoid. No engine codes whatsoever. Battery had 12.1 volts but when turning the key to start in getting 8 volts. Had it towed home. Today I swapped batteries with my other truck and same click noise from solenoid. All lights, radio, ect still work. Where should I start? Alternator, fuses...?? 2008 f250 5.4 ...
View 12 RepliesNoticed a burnt rubber smell while driving today. Stopped at a gas station and before I could get around to the other side of the truck, a guy stopped and told me there was smoke coming from the passenger rear wheel well. The truck seemed to run and drive fine. Didn't seem to be any noticeable drag, but once I got home I felt that wheel and it was a bit warmer than the others.
My parking brake pedal is all the way out and pulling on the release doesn't seem to relieve any pressure or "Pop" like it normally would if releasing the brake. We've got a good downpour of freezing rain right now and I'm not able to start pulling things apart. Anything easy I can try for now? Pretty sure it's seized by the way it's acting but I really don't use the parking brake. Auto trans and I live in a really flat area.
I've got a 2004 f450 6.0 diesel. This thing will start and run great when it's cold. Then when it gets to operating temp, around 190, it will shut down. This is getting worse and worse.
A little history, it was doing this for awhile and a had a few other issues before this. Puking antifreeze, stiction issues, and bad exhaust manifold. Since it wasn't running great I figured why not pull that cab and take care of these issues.
As of last week she got new head gaskets, new exhaust manifold, new injectors, updated standpipes, updated dummy plugs, new o rings on hpop (yellow on the bottom), and a new pipe to the oil pump. I have the old style it's not the stc fitting.
All that work, it still stalls when warm. I monitor with a scan gauge 2. ( Big diesel tech Ron's fan) ...
First thing, give here two second crank start right up, runs better then ever. Gets to operating temp, rev it up, then stalls. Ipc is at 85% ipr gets up to 180 psi.
Unplug ipc, shows 765 psi on the ipr still no start. Put shop air to her and I can't hear any leaks ( probably 15 mins or so).
So I'll be driving down the road and the gauges will randomly start jumping around then the truck will just shut off, this just started a couple days ago, it seems to be gaining in frequency, when i try and restart the engine all my warning lights flash on and nothing happens, try again and it starts back up, now the last time it happened all of the above happened but it was followed by a fast clicking noise from under the steering column, it has to be a electrical issue as i have full tanks and motor is in tip top shape. Also no codes pop up with my code reader.
View 1 RepliesI have a 4 cyl 2000 camry. I notice the smell of burning oil when I shut off the car and while I'm driving. There is no black smoke coming from the tail pipe and it uses minimal oil. I removed the spark plugs and found oil on the threads of spark plug # 2, but not on the electrode. What's up?
View 1 RepliesI have a 2004 F250 with 5.4 Triton engine. It stalls when tapping on Power steering reservoir! This is the oddest thing I've ever seen! I did not get time to look into it today but will sure do so tomorrow.
View 2 Replies