Ford Super Duty (1999-2016) :: 2002 F350 - Cylinders 4 And 6 High To Low Side Open
Jul 26, 2013
Alright, so here's what I've got: 2002 Ford F-350 7.3L - Unmodified, Stock, no chip, no tuner, 130K miles, been run with off-road diesel most of its life as a farm truck.
Here's what it's doing: Serious misfire in cylinders 4 and 6. At idle, mild miss. Throttle from 0 to 50 percent, runs well. Throttle from 50 percent to 100 percent, heavy miss, chugging, white smoke out the exhaust.
Here's what we've done so far:
New UVC Harnesses with updated pigtails.
Cleaned Fuel Filter Mixing screens.
Cleaned out fuel tank.
Cleaned bowl.
Changed Fuel Filter.
Changed IDMs
Changed Crank Sensor.
Inspected injectors while running to see if oil is pumping (it is).
No improvement. Where to go from here. Pulled codes, and it says Cylinder #4 and #6 High to Low Side open. We don't know what to do at this point.
View 5 Replies
Advertisement
I have a 2002 F-350, 7.3 that is not charging. It has no power coming in on the big supply lead on the back of the alt. I traced the cable back, and it goes to intake heater solenoid. Cable is good, but intake and glow plug solenoids both have no power coming to them. I am guessing there is an open circuit between solenoids and starter. My question is, does the power come right from the starter, and is there circuit protection in there someplace?
View 2 Replies
I have a 1999 F350 and the passenger side front door suddenly will not open with the inner handle but it will open if I roll down the window and open it from the outside. The inside seems like it is locked but the locks are all working fine and all the other doors are working just fine .....
View 2 Replies
1999 F350 & lately if I don't plug it in even if it's like 40 out for like the first 30 sec sounds like its only running on 4 cylinders than it'll just even out & alls good. thinking glow plugs here. I did replace them last fall unfortunately with the cheep ones that I been now reading bad things about.
View 2 Replies
I have a 2002 f250 7.3, an my radio is staying on when I turn the key off and open the drivers door. Windows are also still working. But if I open the passenger door it shuts off. What do I need to fix this I am tired of leaning way over and tryind to open that door every time I turn the truck off. I have been told to spray wd-40 into the door catch are i used a whole can an it still isn't working...
View 2 Replies
I have a new 2015 F350 XLT. For the life of me I cannot open the lid on the center arm rest. I have read the manual, and I can't open the lid. This is my 5th Super Duty with the last being a 2010. So you would think this would be a no brainer. I can pull on the handle and its not opening. Pry the damn thing open? Is there a hidden lock? Hidden treasure?
View 14 Replies
I have a 2006 F-350. I got a code p2623 ipr circuit open. I ordered a new one and currently waiting on it. I pulled the old one and the screen has been replaced already. How often do these valves go bad? Is there anything else I should check?
View 6 Replies
I have a new to me 05 F350 dually with 6.0. When I open the door with the key the alarm goes off and the truck won't start. How do I shut this off so I can get in the truck with the key. I can't just leave the door unlocked all the time. It has the key less entry, but I have not set new numbers yet, and if I give the keys to a valet, I don't want to give them the door code too.
View 14 Replies
I have a 2006 F350 CCLB FX4. Is there a way to allow the running/parking lights to come on when I open the door like my dad's 2012? I don't have any roof/clearance lights yet, I'm a little on the fence about drilling holes in my roof but it seems the truck should have them, especially being an F350.
View 14 Replies
I've got a 2000 F350 crew cab with a camper I bought in Chile and I'm going to be driving it from the tip of south america back to the US. It's a 9 month epic family road trip. It'll involve crossing the Andes several times and going over 15,000 ft. There are roads up to 19,500 ft in various places.
My question is am I going to have problems with the altitude? What can i do about it? I've got another truck which is a unimog, it's slow as hell but has a special kind of booster gas you can inject in to the engine to get it started in very cold weather and at high altitude. I chose the F350 for the truck instead of the unimog because a unimog is slow as hell (think 40mph max speed), but it handles extreme conditions well.
View 10 Replies
1999 F350 Crewcab 4x4 dually V10. Fan switch only works on High. All fuses and relays look Good. Is it a bad speed control switch? What can it be?
View 8 Replies
I have a miss at high rpms.. I pulled this engine, manual trans, and 4x4 axle and put them in my F350 Majestic motorhome. 156,000 miles on the engine. Slightly dusted engine with good compression 375-400 (cranking and corrected for altitude). Has a little bit of a long start.
No smoke on start up unless 10 degrees or colder
No smoke when pulling either.
Glowplugs ...Good
GPR... Good
Checked resistance from IDM to injectors ...Good
History of some ether for starting before I got my hands on it. I have AE with the ford enhancement. But I am new to working on a powerstroke and new to AE.
ICP ...new
CPS...new
Oil ....new
EBP...new
Installed a pressure gauge to the drivers side upper port on my fuel bowl:
60 psi at idle
55 psi at WOT 2500-3000 rpms under a load
HPOP stabilized pressure is 2750 @ 40% duty cycle
Truck still misses (semi-intermittently) at higher rpm with a load.
Rechecked codes KOEO: None present
I visually inspected valve movement while running (idle). Did the buzz test when cold.... All injectors sounded the same when tested individually.
Did a cct when not completely warm:
P0266
p0272
Repeated the test at normal operating temperature:
P0266
Torque values on rocker arms bolts and injector holds are good. Fuel quality isn't an issue since this problem has remained for 5 tanks of fuel. What I should do next?
View 1 Replies
New too my Ford, but anyway it's -10 Celsius. My trucks been idling for a few hours and probably will all day because of my job. Usually idles about 600rpm normally. So today the oil temp was about 80degrees Celsius. Then the truck idled up too about 1000rpm for a while. If I touch the gas it goes back to normal idle speed but then starts idling up again after 30 sec. What temp does the truck want too keep it at?
View 3 Replies
2013 F350 passenger headlight bulb keeps blowing both high and low? Replaced 2 times now?
View 1 Replies
I have a 2005 f350 6.0 has 585000. Installed new hpop and lpop and new ipr .pressured oil system with air don't hear any leaks. After truck done started then put truck together no start same problem as before. No oil pressure on dash. All checks goqd except not enough high pressure.
View 2 Replies
About 6 months ago my 4 wheel drive stoped working and I wasn't worried about it because I never used it. I did mess around with it allitle bit to try and fix it the one time I did need it. Long story short I was involved in the floods near Houston these past few days but my truck was never in more than a a foot of water. I went up the store and grabbed a few drinks and went home. tuesday when I went to get in my truck to head back to college station for school it was stuck in 4x4 low. whick puzzled me because my 4 wheel drive hasn't worked in a good while.
When I turn the key on there is no 4x4 lights that come on momentarily and when I turn the 4x4 switch still no lighst come on. Again its been this way for 6 months. I tested the two relays under the hood and both of them have power. there is no power going to the switch in my dash and no power going to the solenoid on the transfer case. Wich is why I am confused on how it went into 4x4 low. I assuming it is in 4x4 low because of how fast the tranny shifts and I know its locked because I cant turn my front drive shaft while in neutral. The hubs are unlocked. I just printed out a shematic and am gonna try to figure out why my 4x4 isn't working.. to hopefully fix it so I can get my truck out of 4x4.
View 5 Replies
I recently bought a 2002 F350 and so far, the only issue I've had with it is I can't find out why the ABS light is on. I've looked around and found that it's probably caused by the speed sensors. But this is where I run into issues. From what I've seen, a bad sensor will generally give a reading of 0 ohms, but none of mine do. The rear diff sensor gives me ~1800 ohms, which I believe is OK.
The front driver side reads about 700 which is I know is a little lower than it should be, and then my passenger side reads ~42 mega ohms. Both the front sensors kind of threw me off since what I've read says they should all read about 1200-2500 ohms. Any other things I should check or should I just go ahead and replace both front sensors? I've just looked around and have barely been able to find anything about the front sensors.
View 2 Replies
Just completed the rebuild on the front end of my 02 f350 and of course I had to take the abs sensors out, everything is good but now my abs light is on. Is there a method I can use or do i have to hook it up to scanner and erase the code.
View 1 Replies
Very strange things happening with 2009 F350 Gas, first the heater blower only is now working on high, progressively has gotten worse, low settings started not working a while ago, now only high works. Just recently the strangest thing, start the truck OK, turn on radio OK, turn lights on then the radio goes off. Will bring it to dealer in a day or two if I can't figure this one out.
View 3 Replies
2005 F350 Lariat ..... I cant get my AC to work in my truck.
AC will not cycle on, Originally thought the system was low because I jumped the pressure switch and it cycled fine (But did not cool inside the vehicle). Checked the pressure and it was in the 40lb range on the low side. My blower will only blow on high but I assumed it was a defective fan speed control.. Possibly an issue with the climate control?
View 12 Replies
I'm having an issue with my 2001 F350 V10. A seriously annoying high pitched whining noise appeared a while ago, then disappeared, and has now come back.
It happens as soon as I start my truck, whether it's cold or warmed up already. it increases in pitch and loudness as I increase RPM, it also does exactly the same in neutral. As soon as I put it in gear (R, D, 2, 1) it completely disappears and will come back as soon as I shift back to P or N. Strangely, if I drive around town for a few minutes, when I get back home and shift to park the sound doesn't really come back, sometimes it will be faint but usually it's totally gone. But if I shut the truck off and turn it right back on again then it's there again.
It's coming from somewhere in the engine compartment or close but due to the nature of the sound it's very difficult to locate. I got underneath using a screwdriver as a stethoscope and listened to the transmission, transfer case, starter, oil pan and even the gastank and it doesn't sound like it's coming directly from any of them. While underneath I noticed power steering fluid leaking from the pump behind the pulley and dripping off the hose. Somehow though I don't think it's related as the sound disappears in gear and doesn't change at all when turning the wheels. I cleaned the fluid off and drove around a bit and it doesn't seem to be leaking too badly and my reservoir is totally full.
The truck otherwise is driving as good as it always has and whatever this sound is doesn't seem to be having any effect on performance (yet...) ...
View 8 Replies
