Ford Super Duty (1999-2016) :: 2002 F250 - Door Ajar Light Stays On / Power Locks On Driver And Passenger Door Not Working
Dec 19, 2013
Vehicle: 2002 f250 xlt 7.3 powerstroke reg. Cab
Issue: door ajar light stays on, power locks on driver and passenger door don't work, radio stays on after truck is off an door is opened.
Events leading up to issue: went to temporarily hook up a wolo dixie horn to see if it worked. Wanted to do it fast so I took + cable, tied one end to the battery terminal and then connected other end to dixie horn relay. I then grounded both negative wires to the truck. One ground on the frame the other I temporarily wrapped around a one of factory ground mounts under the dash. Immediately after doing this the problems stated above started.
How can I fix this. I need to fix this by tomorrow. I have a guy from Craigslist coming to look at the truck. Now the 4x4 issue.
Truck has zf6 manual and the electric 4wd select ****. Just thought I'd list this if it was needed to be known for solutions.
4x4 high light stays on in while 2wd all the time. 4 low will stay on after switching back to 4 high and 2wd but it goes out if I ether stop the truck shut it off then restart it. or back up and slam on the brakes. Also when in 4 high the front driveshaft won't spin. However It will spin when in 4 low.
Another random issue I'd thought I'd just list while I'm writing this.... Cruise control does not work. And when I press the "on" button and the "coast" button at the same time the horn honks.
View 3 Replies
Advertisement
I bought a crew from a dealer, all the dome lights and cargo lights had the bulbs removed, so i put them back in and of coarse they all stayed on after you close the door, plus the door ajar light stays on when you are driving. I do notice the radio shuts off when you open the door after you turn off the ignition. Does that work on the same door switch, eliminating those?
Also are there switches on the rear doors also? Noticed that the radio isn't effected when you open a rear door. I tried to get the dealer to look at it a day after i took it home, a ford dealer at that, and they told me they tried to figure it out , and couldn't before they sold me the truck. Doesn't say much for their service department.
View 13 Replies
I bought a 2002 f250 Crewcab bout 6 months ago. A couple of months back I noticed that after driving it and turning off ignition and opening door my radio would stay on and doors would not respond to key fob or switch on doors. Eventually it would reset and radio would turn off and key fob would work. It also makes the locking sound when press on brake. It doesn't happen all the time though and that's only issue. Truck is in awesome shape only 106,000 on it, belonged to an old man who only used it to tow camper twice a year. I've read a few posts that have similar problems and have heard could be gem or vsm.
View 2 Replies
My door locks stopped working new battery in fob, I can hear them trying to work. 2000 f250 crew cab .....
View 3 Replies
My Dome lights don't work when you open the door. I can manually turn them on though. Also door ajar light is on. Are these issues caused by the door latch switch? Also have no fog lights I replaced the switch and bulbs. I have a 2003 F250.....
View 2 Replies
Troubleshooting a problem with friend's 2000 F250. His power windows aren't working and are causing problems with his door locks and interior lights. When he tries to use his drivers side power window, his power door locks quit working. If he puts the switch to raise, the interior lights flash. From what I've read, it sounds like the GEM to me, we've inspected the wiring and it all looks good. I pulled it out today and it looks good inside, no sign of water leaks on it. If it is the gem, how much do they cost and do they require programming?
View 5 Replies
2003 F250 extended cab .. I've only had the truck a couple of weeks... While I was check out some lighting issues I noticed that the power door locks are operating backwards (unlock is locked and locked is unlocked) is the a simple explanation or has someone wired them reversed???? If you wired the driver's door backward would that effect the passenger door??
View 5 Replies
I have a 2004 F250 Super duty that had a battery die (I left the keys in the ignition switched on overnight) and after jumping the battery off the vehicle started up but now I have no power door lock or window functions. Any reason a dead battery issue might affect the power locks and windows?
View 10 Replies
2008 F-350 Reg reg cab .....
All the sudden got a pass side door ajar warning. I tried doing the WD40 trick but its still there. Do I need to change out the entire latch or do they sell just the door ajar switch ....
View 6 Replies
I have a 2013 F350 CC 6.7L Lariat. The last two days I have been getting the Driver's Door Ajar warning coming on every time I get in the truck. Sometimes it will go off by itself, other times it wont. If I lowly push the door shut, just before the door latches completely closed the light will go off. But as soon as the door closes completely the light comes back on.
I tried squirting WD40 in the lock mechanism as recommended in some older posts for other models. No worky! I searched Fordparts.com, but cannot find a listing for the door ajar switch. Where to find the switch for this warning light?
View 8 Replies
I have a 2002 f250 screw. my door ajar light is lit up on the dash. I have tried the wd40 trick, pulled the sensors and bench tested them. What are the codes the instrument cluster test has for each door?
What I am thinking is, if we get a list posted it would be much easier to diagnose the door sensors for others. there should be a open/closed bit for each door. possibly a code for all doors open too. I am curious if there is a code for bad communication on the VSM.
From what I have read, correctly working the doors should read 00 when they are closed. drivers front open=80, pass front open=40 ... My door code does not change no matter what combination of door open/close I use.
Truck is 2002 f250 crew cab ...
My code is C0 ...
View 6 Replies
I bought a 2002 F350 Dually Diesel 7.3L Lariat Crew Cab. I had the famous faulty VSM issue that plagued many a 2002 model. Got a new security module and everything worked just fine... Except for the doors. The door ajar light constantly stayed on. I do NOT want to pay my local stealership $140 to dig for my VSM and reprogram it since pretty much everything else worked plug and play.
Hoping it was the other infamous stuck door ajar sensor issue, I've been making my door lock hinges drunk on WD40 with no positive results. This saddened me. Today, though, I made a interesting observation.
The door ajar light goes OFF when both front doors are OPEN. Back doors have no effect one way or the other. I was thinking if I switch the polarity of the door ajar buttons by just crossing the wires associated, that should fix my problem.
View 2 Replies
It's been happening the last week or so, on and off. I'll open the door and close it and the cab light won't go off and the red DOOR AJAR light on the dash won't go off. The last two times it went off after about a minute. Now I don't care about it in the daytime, but at night it's a real pain. How do these sensors work? I see the little plastic lever on the rear door (ext. cab), but it can happen when I open just one of the doors. Is there a centralized receiver for both the door sensors?
View 3 Replies
I have a 2002 f250 7.3, an my radio is staying on when I turn the key off and open the drivers door. Windows are also still working. But if I open the passenger door it shuts off. What do I need to fix this I am tired of leaning way over and tryind to open that door every time I turn the truck off. I have been told to spray wd-40 into the door catch are i used a whole can an it still isn't working...
View 2 Replies
2004, cc/lb 6.0 ... I get in the truck and the dome lights come on, key the ignition and they stay on though they should go off, start truck and they still stay on until I reach 5 mph. Door ajar light is illuminated on the dash. If the truck is off and I open the drivers door, the domes will come on, they will not come on if I open the other three doors. I just replaced the switch on the drivers door and no change.
I held the trip button and started the engine. I kept tapping the button until "door 40" came up. When I opened the drivers door it would change from 40 to CO. When I opened the other doors, it would stay at 40.
I did notice that once I had the drivers door open and completely off the latch and my hands off the door handle, I would move the door and it would then change from 40 to CO. At this point the latch switch is out of the picture. So if i move the door slightly open/close it would switch from 40 to CO when the door is nearly closed. Is there another switch or sensor somewhere near the hinges?
View 1 Replies
All 4 crew cab door locks are not working...I see and hear them moving a little but not enough to get the job done.....Ive read a good fix on this forum but have a few questions...... 1. Could the problem be in the switch or wires ... 2. If I try to fix---do I need to fix all doors or is one door somehow messing the other up.
View 6 Replies
1999 F250 - When I open passenger door , dome light and door ajar is not working but in driver's side everything is working. I have read several issues with this but everything seems to be opposite way lights and ajar are always on
Earlier I change passenger side power mirror and same time i release door jamb electric switch to check it but still no light when connector was released...
View 4 Replies
My power door locks just started acting up. The driver's side switch will not do anything. The passenger's side switch will lock both doors, but it will not unlock them. Is this a switch issue or the actuator? I am assuming the issue is on the drivers side only and am leaning towards the drivers side switch. With that said, I read about a lot of issues with actuators on these truck which makes me think it may be the actuator? Would the doors still lock if the actuator was toast? If it would, why doesn't the driver's side switch work? I tried replacing the driver's side actuator but it made no difference. I also swapped the driver's and passenger's switches and it does the same thing. The passenger locks only and the driver does nothing.
View 10 Replies
Today I purchased a 2002 f250 GAS super duty 5.4. The first thing I've noticed wrong is: The driver door doesn't lock with the remote control but the passenger door does. I also noticed: when I shut the driver door, the dome light comes on and stays on but when i open the driver door, it shuts off (as if something's reversed). Do you think these two situations are related, and how can I fix it?
View 9 Replies
Truck '02 F250 SuperCab - I was having an issue with the door ajar light staying on and the radio not shutting off upon exiting the truck. After having no luck with the WD-40 fix, I replaced the door switch sensor on the driver's side door and disconnected the negative battery cable for a few minutes (maybe 5-10).
Problem solved or so I thought...a few days later (approximately 5) the door ajar light came back on and the radio did not shut off. I disconnected the negative cable and sure enough that fixed it...again The problem is that every few days I have to go thru this. I'm not sure if it's related or not, but the CD player has started giving me "error reading disc" on even brand new CD's.
View 2 Replies
i've got a 2002 explorer xlt and the door ajar light stays on. all the doors properly close. What would cause this ?
View 3 Replies
