Ford Super Duty (1999-2016) :: 2002 - Exhaust Have Periodic High Pitch Sound?
Nov 11, 2014
Is it common for the exhaust to have a periodic high pitch tinny sound?
View 4 Replies
Nov 11, 2014
Advertisement
Ford Super Duty (1999-2016) :: 2011 - Whining And High Pitch Squeal Sound?
I have a 2011 F-350 Diesel. It started making a strange whining sound when I start it in the morning. Very random and only does it when it's 0- -4 c. Took it to the dealership and they said its the cooler fan clutch. Got it replaced yesterday, and this morning I started it up and the whining sound was back. It also had a weird vibrating sound. What it could be?
View 10 RepliesFord Super Duty (1999-2016) :: In Cab High Pitch Vibration?
I just put a dual exhaust kit on my truck (cherry bomb extreme, single in dual out), and I've started to notice that around 2100-2200 RPMs, there's a high pitched vibration in what seems like the tight hand corner of my regular cab. It almost sounds like the glass in the window is vibrating, or a loose bolt, or something like that. Very high pitched, very noticeable.
View 2 RepliesFord Super Duty (1999-2016) :: 2002 F350 - Popping Sound Coming From Exhaust And Lose Power
I have a 2002 F350 with the triton 5.4. For the last week it has been running like crap. I just did my plugs about a month ago. I don't know if it's a miss fire or bad fuel or I don't know what it could be. It's a popping sound coming from my exhaust and when it happens I lose power. It happens off and on. One second it will run fine and normal and the next runs bad. What it could be. Today I just changed my fuel filter and added STP octane boost and fuel injector cleaner. Haven't seen a difference yet.
View 4 RepliesFord Super Duty (1999-2016) :: 2002 F250 V10 Exhaust Flutter Sound At Shift Points Around 1800 - 2200 Rpms
Is there truely no cure for exhaust flutter on a 2002 f250 V10, bedsides putting on headers??? I have the the sound at shift points around 1800-2200 rpms. Sounds great before and after these points....
View 14 RepliesFord Super Duty (1999-2016) :: F250 - High Pitch Squeal From Driver Side
So today pulling out of the gas station I turned my steering wheel to the left and I heard a high pitch squeal from the drivers side. It wouldn't do it again unless I was just creeping, nothing going down the road. I did a few searches on here but they all are if the truck is moving say 30 mph or better. I know I need to replace my ball joints. 99 F250, V10, 4X4, extended cab.
View 8 RepliesFord Super Duty (1999-2016) :: Gear Shift Lever Is Loose / Periodic No Start
I think the gear shift lever is loose and so I get a no start every day or two. I remembered seeing somewhere here that there was a way to tighten up the grearshift lever to fix this problem. I did a search to no avail.
View 5 RepliesFord Super Duty (1999-2016) :: Code P2033 - Exhaust Gas Temperature Sensor Circuit High
2011 6.7... My truck is throwing code P2033 Exhaust Gas Temperature Sensor Circuit High Bank 1 Sensor. What is the part number for that sensor?
View 6 RepliesFord Super Duty (1999-2016) :: Check Engine Light On - Exhaust Gas Temperature Sensor Circuit High
I've owned my 2012 F-250, 6.7L for less than a week and it has a check engine light. The local dealer can't see me for a week, and I need to leave town next week.
I went to AutoZone to have the codes checked and this is what they came back with:
P2033
Exhaust Gas Temperature Sensor Circuit High Bank 1 Sensor 2
P2031
Exhaust Gas Temperature Sensor Circuit High Bank 1 Sensor 2
Can I drive on these codes, or should I park the truck until Ford can see me?
Ford Super Duty (1999-2016) :: Misfire On Cylinder 2 / Choppy Sound In The Exhaust
I have a 99 ford super duty with a 5.4 triton that is having a troublesome misfire. When you first fire it up it has a bit of a stutter then runs relatively smooth but the engine does still have a small shake to it and you can hear a bit of a choppy sound in the exhaust. Not completely smooth. When you drive it light footed it seems to run perfectly smooth and nice. But if you go past half throttle (sometimes you can go past that point) it starts to cough and is very slow at picking up.
When you reach between 3,250 and 4,500rpm the coughing stops. But the pick up is a little surgy, not steady. It was doing this for a while before the engine light came on. I got it scanned and it showed a miss fire on cylinder two so I have replaced the spark plug, coil, and injector but still the same issue. I opened up the catalytic converter to see if it was plugged up. Nothing there.
Ford Super Duty (1999-2016) :: 2002 - Exhaust Noise - Leak / Bigger Pipe?
i have a 2002 250 with the 7.3. i put a mbrp aluminized 4in turbo back with a FTE 30in resonator. I'm getting a lot of noise in the cab sounds like its where the turbo goes into the 4in pipe. the muffler guy said its because of the bigger pipe and not a leak. is there anything i can do to get rid of the excess noise.
View 8 RepliesFord Super Duty (1999-2016) :: 2003 - Muffler Delete On Stock Exhaust Sound?
How will a muffler delete on stock exhaust sound? I don't want to remove the cat because I don't want it to be too loud. I want it to sound good but not too much whistle (considering my truck is a 2003 the whistle would be very loud) Should I just to a delete pipe on the stock exhaust, or do a cat-back 4 inch straight pipe? what will sound better? Also doing the cat back exhaust will cost a lot more.. but is it worth it? What I should do.
View 4 RepliesFord Super Duty (1999-2016) :: F250 5.4L - Engine Making Puffing Sound Out Of Exhaust
Here's a link to a video where you can hear what I'm describing. The noise is most noticeable around the start (first 18 seconds) and the end of the video when I'm closest to the exhaust pipe:
YouTube ....
You may need headphones to hear it, but the engine seems to be making a bit of a puffing sound during idle. It happens completely randomly and I'm not quite sure what could be causing it.
Aside from this noise, the engine seems to idle normally, and the check engine light isn't on. I had all of the injectors out a few weeks ago for cleaning. They all appear to be working fine. I also cleaned the throttle body at that same time and ensured there were no obstructions for the air intake and filter.
What might be causing this sound? 1999 Ford F250 Super Duty 5.4L
Ford Super Duty (1999-2016) :: 2002 E350 Start To Flatten Out And Smoke Out Of Exhaust During Acceleration
I had a post a couple of months ago about this E350 van I purchased with the 7.3. It would leave me stranded every few weeks and I replaced the injector oil pressure sensor and the camshaft position sensor. This truck has a intermittent running problem that cannot be pinned down to hot or cold.
It runs and idles well but sometimes during acceleration it will start to flatten out and smoke out the exhaust. Giving more accelerator pedal powers through the flat spot and the truck runs smooth. It does not do it every time. It does it hot or cold, wet or dry, city or highway, If this was a gas engine I would be replacing the fuel pump or checking a fuel starvation issue but the white smoke tells me that it has unburned fuel.
A cylinder contribution test passes fine. I monitored engine data with a Snap On Verus pro and compared oil pressures with another 03 7.3 I have and they are too close to the same. It starts fine, no issues there. It may take off great one time and buck and smoke the next. I swapped out the throttle position sensor with the other 7.3 and no change. I swapped out the injector control module and no change.
I've thought about injector Orings but I would think the problem would be consistent. I've changed engine oil, checked fuel pressure, changed fuel filter, and drained the fuel system to be sure no water is in the separator. This engine was rebuilt about 30k miles ago. If you floor the accelerator in park it will rev up, flatten out, smoke and buck for about 2-3 seconds, and then take off like normal. I pulled a trailer with it a couple of days ago and wasn't impressed at all. I have a 6.5 GM that seems to have more power than this.
I thought maybe a sticking injector and I added a half gallon of two cycle oil to the fuel to see if that might work. It hasn't. It just seems like it is flooding at a certain rpm and clears itself after a couple of seconds. There are no codes being thrown in the pcm. I am at a loss.
Ford Super Duty (1999-2016) :: 2010 Truck Stuck In Regen Cycle - High Idle And Increased Exhaust Smell
[URL] ....
The problem with my truck is not that its regen'ing too often, the problem is that its STUCK in regen cycle. For the past 4-5 days my truck has been going into regen about 1-2 min after i start driving it, every single time i start her up. If i start my truck in the morning and let it warm up for a few min, i come out and my truck is idling higher then normal and has an increased exhaust smell, but when i aply the brake the idle goes back to normal. Then i start driving up the street and BAM "cleaning exhaust filter" message comes up and the and immediately the sound of the exhaust and induction changes and it sounds like sputtering/knocking.
Sometimes the the engine will flutter in decel or shutdown. HORRIBLE gas mileage, Reduced engine response and power, and white smoke is cooler temps. Basically all of the normal signs of a regen cycle, am i wrong? Im pretty sure its either a dpf sensor or possibly something wrong with the DPF? I haven't had one problem with my 2010 besides an egr valve and she has 167k miles and is completely stock and im very happy with my truck! 2010 6.4L
Ford Super Duty (1999-2016) :: 2002 F250 - IAC Changed - Truck Idling Too High
I just changed out my IAC. Truck is still idling too high. When I squeeze the host to the IAC it idles down. When I unplug the IAC the truck immediately dies.
Does the IAC talk to the the Throttle position sensor? Should this be my next part to change?
2002 F250 5.4L ....
Ford Super Duty (1999-2016) :: 2002 F350 - Cylinders 4 And 6 High To Low Side Open
Alright, so here's what I've got: 2002 Ford F-350 7.3L - Unmodified, Stock, no chip, no tuner, 130K miles, been run with off-road diesel most of its life as a farm truck.
Here's what it's doing: Serious misfire in cylinders 4 and 6. At idle, mild miss. Throttle from 0 to 50 percent, runs well. Throttle from 50 percent to 100 percent, heavy miss, chugging, white smoke out the exhaust.
Here's what we've done so far:
New UVC Harnesses with updated pigtails.
Cleaned Fuel Filter Mixing screens.
Cleaned out fuel tank.
Cleaned bowl.
Changed Fuel Filter.
Changed IDMs
Changed Crank Sensor.
Inspected injectors while running to see if oil is pumping (it is).
No improvement. Where to go from here. Pulled codes, and it says Cylinder #4 and #6 High to Low Side open. We don't know what to do at this point.
Ford Super Duty (1999-2016) :: 2002 F250 - Misfiring Under Heavy Load Or High RPMs
So basically I thought it would be a great idea to degrease my motor from the top down.... After washing I start it up and drive down the road to head abunch of misfiring under heavy load or high rpm's.
My problem is that the misfiring won't throw a code. I then proceeded to buy a new ignition coil (thinking this was the problem) but with no code to go off which cylinder was bad I just switched the good ignition coil into each cylinder and starting it.
Up each time. None of them seemed to make it better. Also the injectors all seemed to be good. So what to do ?
2002 Ford F-250 5.4l
Ford Super Duty (1999-2016) :: 2015 F250 - Cold Tranny Noise / High Rev Sound When Accelerate
Just bought my first Ford. Its a 2015 F250 Platinum. Im at 1400 miles and Im becoming concerned because when I start the truck for the first time in the day, no matter how long I let it sit and warm up I am noticing that on the first couple of miles of driving I hear a high revving sound as I accelerate and it seems to quick shift during those first few miles.
As I continue to drive the high rev sound just fades away and all engine sounds and shifting are as normal as can be and will remain that way until the truck has been sitting for an extended period of time and is cold. I thought it had something to do with tranny temp but this morning I let the tranny warm up to about 115 deg in neutral before taking off but still had the high rev for the first few miles. I have never owned a ford nor have I ever owned a heavy duty truck, hoping this is normal.
Ford Super Duty (1999-2016) :: 2002 Excursion - Knocking Sound When Turning
2002 Excursion 4x4 7.3. I've read about this on here before but I've forgotten what the problem is. When the wheels are turned and the vehicle is going forward at some speed, there is a knocking sound, like a ba-doomp ba-doomp ba-doomp. Does it in both directions, sounds like its in the front hub area. I don't have the time to fix it myself, how much should I expect to pay a dealer and/or independent shop to do it?
View 2 RepliesFord Super Duty (1999-2016) :: 2012 - Pitch Sensor Location?
Truck is 2012 F250XL single cab 6.2. Where is the pitch sensor on this truck? There are times the hill start assist will keep the brakes applied on level ground, and occasionally I will crest a hill onto a level stretch and the truck doesn't want to upshift. So I am thinking the pitch (incline) sensor needs recalibrated. Where it is?
View 7 Replies