I had a new Fuel Pump put in the cheaper plastic one into my 2001 F250 5.4 with a 112,000 miles.
Problem I am having since getting it back is when filling the gas tank up it will shut the pump off at 3/4 tank. I then have to sit there playing the squeezing game to get more gas in. The vent line looks fine no kinks in it and the tank looks level so what could be the issue causing me this headache?
Just got back from a 2500 mile trip and the 800 mile DEF warning came on. Went to a DEF pump but it just filled the neck. Went to another DEF pump, same . Went home and used a Ford DEF jug with the Ford spout. It still will not go in. If I squeeze the jug, I can hear a little bit dropping into the tank.
The vent and fill pipes are not kinked. The vent hole in the fill tube looks clear. I washed off the top of the tank since there is a vent there.
Still no fill. I do not have a bore scope to look in the fill tube. I ran a 1/2 inch flexible hose down the fill tube until it stopped. Still no fill.
so long story short a few weeks ago my truck would start clicking the pump. Every 3 seconds it will click and stop. Tried different pumps, upside down, nothing works. Now it won't even go in like something is stuck in the fuel neck and its spitting gas back out. I stuck a wire and it went down pretty far. I see people saying the evap lines but I have no clue where they are.
View 9 RepliesIs there an easier way to fill the rear end on my '01 f250? I have a gadget with a valve on it with a length of tubing that you put on the bottle, but you still have to snake the bottle up through the chassis.
View 14 RepliesHow hard is it to drop a gas tank from 2001 F250 short bed? It is a gasoline, not a diesel truck. I need to remove the filler neck to modify it and I cannot disconnect the hose from the neck filler to the tank while the tank is in the installed position. So, I want to drop it so I can have more leverage to pull it off or cut it off and put new one on.
View 7 RepliesI have stripped my HPOP fill plug. Any experience on getting one out? And a part # for a new one?
View 10 RepliesI notice the gas nozzle clicks off all the time when I am filling my truck. Normally I just hold the nozzle up more and it seems to work.
F250. Slow fuel fill or fill nozzle keeps shutting off....
[URL] .....
Yesterday went to fill up ($4.05 a gallon geezz!) and noticed that after getting back into the cab, the fuel gauge still showed almost empty. So after yelling a few expletives, I looked again and noticed the gauge starting to make it's way up the dial. It took almost 30 min. before it showed almost full. I'm not sure what the problem is, as the gauge seems to still function. I don't drive the truck much as I use it as a tow vehicle. However, I do try and take it for a spin about 3-4 times a month just to exercise it. I was wondering if the fuel has started to gel and that is the reason for the slow fuel gauge response. Should I add a fuel conditioner/cleaner now that I have a full tank?
View 9 RepliesMy 2000 F-350 during fill-ups will spill out about a quart or more of gas from under the truck somewhere right when the filler clicks off. Also can smell fuel sometimes when between half and full tank. 2000 f350 SWR crew-cab 4x4, 5.4 gas.
View 3 RepliesMy 06 f250 with the 5.4 has a hard time being filled at the pump. So I followed the tsb and replaced the carbon canister, filter box and solenoid with the kit from my local ford dealer. Before it was impossible to get fuel in. Now it is way better but I have to fill it up with the gas nozzle upside down in order to fill at full speed. I have blown out the vent with compressed air.
View 6 RepliesWas thinking it was around 38 gallons but I'm thinking it's less than that. I have a 1999 Super Duty V10 with the long bed.
View 14 RepliesMy truck started running poorly with an intermittent miss about 6000 miles ago. The miss gets more consistent when the tank is below 1/2. Fill it up and the miss goes away. No codes, shop that does a lot of V10 camper work could not figure it out.
My guess is that the fuel pump is going out and it overheats when the tank is low. The problem is getting progressively worse. Now it misses slightly with 3/4 tank and even a full tank sometimes.
Plugs have been changed, fuel filter has been changed, and the shop found 3 COPs that were bad before all this new intermittent miss started. The truck runs ok at wide open throttle.
Am I just nursing a bad fuel pump that will leave me standed soon? Truck has 170,000 mile with original fuel pump.
It doesn't say on the window and in the owners manual I should have a 23 or a 35. The most I've put in my truck is 29.somthing and I had 3 miles till empty and the needle was in the red. I'm thinking I have a 30 gallon tank but how can I find out for sure.
I have a 2015 F250 6.2L CC SB FX4
So my brother swears by sea Foam and has been telling me to run some of it through my truck. Question is,i just put new spark plugs in less then 5,000 miles ago. Will i have to change them if i run sea foam through the booster line and gas tank??
View 8 RepliesI'm close to pulling the trigger on a Crew cab F-250 Powerstroke, 156" wheelbase. Need to know about fuel tank capacity? Ford's website and manual are somewhat cryptic. I believe it's 26 gallons.
View 3 RepliesI have a 99 F350 with a 29 gallon tank. I filled it up yesterday and the total gallons was a little over 24. The low fuel light was on and the gauge only goes up to almost 3/4. I recently bought this truck. I've searched for a thread on here possibly addressing this but have been unable to find one. I've been going through possible issues in my head.... What the problem is?
View 14 RepliesI have a 2012 f250 6.2L gas that the check engine light, low fuel light and the fuel gauge says it's empty. The truck has a full tank of gas. I am in camp for another 2 weeks and my girlfriend is driving the truck. I am thinking a blown fuse or disconnect the battery to reset the computer could solve it. Hoping it's something I can instruct her to do on her own over the phone.
View 13 RepliesI've been looking at adding an additional diesel tank to my F-250, since the stock tank only holds some 38 gallons. However, I do not want to lose the space on the bed and have been looking at tanks that are mounted under the bed.
Most tanks I see are welded steel, completely overkill and accordingly priced. I'm wondering if a second stock tank pulled from a junkyard might fit in well, but haven't lowered mine yet to check the complete dimensions.
I have a 2014 350 crew diesel short box. I am told, I have a 28 gallon tank but can't get over 22 gallons in it even though my gauge show e and my read out says I have 10 miles left until empty? Dealer says the left over 6 gallons is a reserve...
View 14 RepliesAs I was driving to work yesterday I noticed my fuel gauge going from half tank all the way to full going down the highway. I started looking at the rest and they seem to be in there normal spots. I looked up and watched the outside temp go from 40 degrees to 5. This morning the fuel gauge goes straight to full and the outside temp bounces between 2 degrees and 10. What may be going on to cause this?
The truck is a 2000 F350 crew cab with a 7.3 Power Stroke
Have a Howling coming from my single gas tank, truck was sputtering now and then. Yesterday it died and would not start. Towed it home and then it started. Think its the fuel pump, Is it tough to change.... 2005 F250 Super Duty109K Miles...
View 14 Replies