Been searching but can't find a clue. I replaced my steering gear box. Went fine, but after starting back up. My alarm goes off, my cruise or horn doesn't work and my air bag is giving a code 32.
Is there a ground wire or something I could of missed when installing the gear box?
I have a 2001 F-250 SD XLT with the ABS light on, cruise control doesnt work and the horn only works with the key out. The codes for the ABS is no signal input from the left and right front wheel sensors. No problem there. Also my speedo stops or jumps when I press the horn button while driving down the road. When I quit pressing the horn button the speedo works fine. So after looking over the posts on cruise control, etc. Does the rear speed sensor have anything to do with the cruise, horn not working? All fuses are good so I am thinking the cruise control switch on the master cylinder or a short in the steering wheel column or my ignition switch. What do you all think?
View 7 RepliesSo i was replacing my power steering box after the shaft broke on it and apparently i didn't have my steering wheel back to exact center. after putting everything back together and started to drive down the road a very thin flat wiring harness broke and got tangled around my steering column under the plastics of the column. I then lost my horn and my cruise control and i believe my airbag. I pulled the wiring harness out and it was very long with two white plugs on either end. I'm not sure what this part is called or where i would be able to buy another one. And if there's some kind of instructions on how or where this harness plugs into sense it was ripped out.
2000 ford f-350 lariat 7.3l diesel....
I have a 2002 f350 my horn went off in the middle of the night got up and unplugged the horn what is my problem. also, the cruise control won't work when it all happened
View 3 RepliesI'm having trouble with my '99 F-350 7.3L 4X4. One day, my power windows, cruise, dome light, horn, wipers, and 4 wheel drive stopped working. After checking all of the fuses, I have found no bad ones.
View 3 RepliesHorn isn't working found fuse blown. Replaced fuse and horn stays on. Swapped relays still stays on. With fuse out pressing left side of horn cover on steering wheel I can feel/hear relay click. Pressing right side not so much. What and where to check? Is there a way to disconnect the horn buttons on the steering wheel?
View 1 RepliesOur cruise isn't working, I've read through the posts here and tried a few things
2000 F-250 V-10
-First symptom was the cruise light would light with the ON button and go off with the OFF button but I could not set the speed with the SET button. Now the cruise light hardly comes on at all any more.
- I've run the cruise self-test diagnostics and all the switch presses passed with no additional light blinks. After the static test the speed control servo makes a sound but does not move the throttle at all.
-The horn works
-Fuses are good
-Truck was taken to the dealer several years back for the cruise update. The pigtail with the green label is installed at the master cylinder. I've disconnected both connections and sprayed with contact cleaner.
That's about it. What it could be or what to test next?
Was hoping to get confirmation on a fix I intend to repair.
2000 F350 SuperDuty 7.3l Diesel 4x4
Cruise isn't working...... lights won't even come on and nothing happens at the switches.
This morning I put in a new airbag clockspring ...... just requires patience but not too hard to do.
That didn't resolve. Was going to put in new cruise switch at the brake master cylinder.
My question is would that part prevent the cruise control from even turning on at the steering wheel controls? I don't get any light or anything when I hit "on".
I checked literally every fuse in the under dash and under hood boxes. All are good. Is it likely it's the cruise switch?
2000 F250 Super Duty cruise control not working. I looked through a lot of threads on this subject and cannot pin point my problem. Cruise control was working, had to slow down wile approaching a town, back on the highway and now it won't turn on.
Looked at the brake pressure switch, it was till good but was the old type but had the recall harness on it. Bought a new one and replaced it anyways. Still nothing. All my brake lights work, I also did the Cruise control diagnostic and it passes everything. No lights on my dash are on, speedometer works, horn works.
The only thing I did not check is the Vehicle speed sensor. Even though my speedometer works and my ABS light is not on, can this still be the problem? If so how do you test it? Do I just remove it and test continuity?
I just picked up a 2000 F350 V10 from a buddy of mine. While driving, I will turn my cruise control on but no light comes on. But it does come on when I hit the set/accel or coast button. But the cruise doesn't activate. I tried the self test and the Cruise light lights up after I hit all 4 buttons.
View 2 RepliesMy 2000 F-350 SD 4X4 V-10 has no cruise control, and the A/C controls are not powered. Is it possible that both these power option circuits are run through a fuse link, and better yet, through the same fuse link? A/C has been troublesome in the past, but the cruise quit one day without warning. All fuses are good. Tried jumping the A/C pressure switch to recharge it, but no power is present.
View 4 RepliesI have a 2000 f250, 5.4l triton v8 that cranks like crazy, but won't start. When I spray a little starter fluid in it it will run until the spray wears off. Brand new battery and full gas tank. it does have check engine light on dash, probably from the o2 sensor as the exhaust has almost completely rusted out. Also on a side note the cruise control will not engage.
View 6 RepliesI have 2002 F250SD, The horn just starts blowing by itself. Bump the horn switch and it stops for a couple of weeks. I've looked at the wires to the fuse box and no wires shorting out the horn wire. I read some very old posts but nothing conclusive was ever decided on, just a lot of guessing. The horn switch has always been sensitive.
Somebody said the air bag is warming up in the sun and expanding causing the horn to blow. Somebody said the horn relay, but in 55 years of working on trucks, I have never had a horn relay act like that. I'm told the horn relay is built in the back of the fuse box and it all has to be replaced. Some say the clock switch. I don't know what that is or where it is. I guess inside the steering wheel. Is it hard to replace?
Where do I go from here....
In my new to me 99 F250 SD ,Started today off with switch sticking in drivers door causing dome light to be on when doors closed... oiled the crap out of the door mechanism and it started working. Later in the night I look out side notice the radio lights on with no key. Can't figure it out so pulled the face off and figure I'll look at it tomorrow and go to bed.
1:30 am the horns blaring! I open drivers door and horn stops, close it and it goes off I ended up pulling the batt cable so I could go back in the house. I did search for info with no sure real causes. Seems like it has happened to others as well.. BTW it did start raining before the radio stayed on. Thinking water in the dash or fuse panel. But it doesn't explain door switch problems I had earlier. Maybe 2 separate problems. This will be fun! Not!
Okay so I have an e99 f250 7.3 the problem all started went I hit a puddle the other day. My horn started going crazy and wouldn't shut off so I had to pull the fuse and relay. After that I found another problem, all my dash lights,headlights and running lights will not turn off unless I pull the battery terminals, it does not matter which way the headlight switch is it can be on or off and they stay on. I did find it though if I pull the negative terminals and put them back on the lights stay off if I turn the switch on and try to turn the lights back off with the switch they stay stuck on again untill I pull the terminals what could be the problem I've looked at every fuse and can't find the probelm.
View 8 RepliesSitting in the house, heard a horn blowing and ran outside to find my F350's horn was blowing. When I pushed on the horn button on the steering wheel it quit. Couple of hours later, it started blowing again. Pushed the horn button to make it stop and removed the fuse so it would not start blowing again. Did a forum search, but didn't have any luck. Short in steering wheel?
View 14 RepliesMy brothers truck has unusual problem of when parked the horn randomly comes on and stays on? Why?
View 4 RepliesI have a 2001 F250 V10, 150,000 miles, gas, very basic truck (no power windows, no cruise, no security system, no power locks, etc). In it's previous life, it was an IDOT highway truck I purchased at auction in 2005. Used primarily to pull horse trailer, less than 2000 miles per year. Stored under cover when not in use. Windshield leaks very little, but generally not used when raining.
Last week, 9pm, horn starts blaring solid tone. I go out and unlock door, open door, it stops. I start truck, still fine, turn truck off. Lock door, close door, starts blaring again. I reopen door, leave unlocked, close door, then get intermittent beeps. I reopen door, disconnect battery because it's late, I was going out of town, and felt bad for my neighbors. Just got back in town, too afraid to reconnect battery and not be home in case it starts going off again. I had last used the truck about 36 hours before the horn started going off, weather about 70 degrees overnight.
I've read other threads, but can't find one that fits (I have no cruise, kept out of rain, not freezing cold, not diesel).
F250 today at 61300 miles going down the interstate today my vehicle made a strange new noise that sounds like an old timey car horn. The sound started at about 75mph and comes and goes depending on what appears to be air turbulance and other vehicles nearby or goes away as the speed comes back down to lower numbers. Also when the sound is present you can "feel" it in the side handle on the A post. Really weird. Doors were closed all around.
View 7 RepliesI am trying to figure out where the relay would be when i look online for the map of the relay box under the hood it says nothing of a horn relay. I don't have a key fob for the doors to unlock so I wouldn't think its tied to the computer. Should mention nothing happens when you hit the horn also fuse is fine. No power at the actual horn when i hit the steering wheel(horn)....
View 8 RepliesMy custom air horn setup. I have a schematic here and and need info whether my drawing is right or not. I also need some help on what gauge wiring, what amp fuse and what relays.
View 2 Replies