Ford - Focus :: 2004 - Replace A/C Pump?
Jun 28, 2014
So I just took my 2004 Ford Tauraus into the shop. I have about 155,000 miles on it. I was told as part of the repairs that my air conditioner pump was bad, and that I should have it repaired, as it would affect my power steering and battery. The total cost of the repair and the part I was told would be $1100, money that I do not currently have and that I would not like to dip into my 401K for. My question is if this repair is absolutely necessary, and if I don't get it fixed can I still drive the car as long as I don't use the AC.
View 7 Replies
Advertisement
I've replaced the fuel pump, relay, drive module, and the filter. The fuel pump still refuses to switch on when I go to start the vehicle.
View 9 Replies
I have a PZEV (Partial zero emission vehicle) 2006 Focus. Recently, my car threw the check engine light. Looked at the two codes, found out it was for the secondary air system. I pulled the car apart, removed the pump, checked that the pump was indeed receiving 12v (checked with a multimeter) with ignition-on-engine-off. I couldn't feel, or hear, the pump spinning. Figuring it was the source of the problem (as opposed to a clogged hose), I replaced the relay, thinking that perhaps it was on its dying leg. That didn't work. I next replaced the pump, which also didn't work. I can't even hear or feel the new pump running with ignition-on-engine-off.
I "reset" the codes, or so I thought, by disconnecting my battery for quite a few minutes. During the first startup, the check engine light isn't on. Starting up again though later in the day, the light returns. The engine does run a bit rough when cold without the pump malfunctioning for the first few brief moments.
Is the pump supposed to be powered and running for the entire time ignition-on-engine-off (I assume so since it is receiving 12v). How loud should these guys be? I would have thought I would be able to feel the motor spinning or hear something....
View 6 Replies
I have a 2000 Ford Focus SE with DOHC that is losing power and sputtering when it gets hot after driving for 30 min or more. If I shut the car off and right back on going down the highway it will be fine for 5-10 min and then start sputtering again. If the car is not hot this does not happen and I have a new fuel filter and coil pack as those are the two main things that I could think of. I have seen intake valve seat and fuel pump as the two most common fixes with similar circumstances.
View 7 Replies
Almost every time I start my 2001 Ford Focus, it won't start. The starter functions but the engine won't start. I have to pump it, give it gas, and once it starts, it's perfectly fine, no stalling, no problems after that. That is until I turn the engine off. When I go to start it again, say after doing an errand or two, it may or may not happen again throughout the day, the problem only occurring when I attempt to start it.
View 1 Replies
2009 Ford Focus. Six months ago got in car returning from 60 mile trip. Turned ignition key heard fuel pump hum but no juice to ignition. (Not anti-theft lockout--security light behaved normally.) Would not take jump. Ford Roadside assistance tried everything else possible. Nothing. Towed to nearest Ford dealer. On arrival, car started immediately. Took to local Ford dealer who found absolutely no problems but ran TSB 10-21-8 reprogram PCM--test OK. Had no further problems with car until a week-and-a-half ago--same thing happened. Car towed to dealer again. Started immediately at dealer! Picked up from dealer, that night same thing happened. Did not phone roadside assistance--after 45 minutes car inexplicably started. That was a week ago. No problems since then. Feeling a little panicky w/car that may fail at any time--winter coming.
View 5 Replies
Will it be easier for me to drop the tank or to take off the bed of the truck does a 1990 F350 7.5 liter dual tank gas
View 1 Replies
Across Internet is lot of examples of using pump, usually drill pump or vacuum. It seam to me that drill pump would work good for that job. Pump that attach to battery have limited amount of power and vacuum pump is manual. Look like a excellent device for transmission fluid change. Clearly no drain screw at pan. I do not think I'm fan of disconnecting return line and live empty tranny.
For example here : [URL] .....
View 6 Replies
getting weak spray/dribble (yea, it could be a "personal problem " on the drivers side squirter. Left side great. I have replaced both squirters and blew out the line where it T's over to the drivers side.
Still weak.. I'm thinking its most likely low pressure coming off the pump and maybe it's time to replace I haven't crawled under there to inspect placement of pump. Thought while there I would also replace the reservoir.
View 5 Replies
So I tried to replace my thermostat and housing and the housing bolt snapped off. Ok so I tried to extract that bolt off and the extractor bolt snapped off inside. I am guessing it might just be easiest to replace the water pump now? I am pretty much at the end of my mechanical rope which is short anyhow.
View 6 Replies
I just bought 2009 ES350 with 125K on it. Since I bought it from a Lexus dealer, they were able to pull all maintenance records for it. It does not look like that the previous owner has replaced the pump so I am thinking of doing it myself. Other parts that should be replaced while i am in there, so I can order them at once?
View 13 Replies
When the water pump goes bad do you have to remove the engine to replace it?
View 2 Replies
I've lost all power steering about a week ago. I checked all the lines the return is bring fluid up from the pump and the res is flowing into the pump.
A) should I replace pump?
B) look into other things that could be causing the issue?
View 9 Replies
So, I'm replacing the Steering Box today and read an article that said you should replace the pump at the same time. what do you all think?? I have clear access to it now and they are not all that expensive?? Or are the ford one's bullet proof and leave it alone???
I don't have any leaks and it feels ok I guess..just pushing close to 200K on it.
View 13 Replies
I have a 2004 Ford Focus with 120,000 miles on it. In the past 8 months I have had to replace both rear brake lights twice and both of the head lights. I also had my mechanic replace one break light in addition to the ones I did. On one occasion some one told my wife her break light was out at a traffic light. When I got home and checked the light was working. The only other electrical problem I have noticed is that the emergency break light goes on now and then and also the check engine light. If this is a wiring or electrical problem is it something that will be able to be fix or even found? Also is it going to cost more than it is worth for an older car?
View 3 Replies
I recently noticed a humming noise coming from the passenger side on my Mazda Protege 2000 ES . I suspected it was the water pump, so I took the car to my mechanic. He inspected the coolant reservoir and it was empty. He also checked the noise and the area were the pump is, and told me that the water pump had to be replaced.
My dad told me that his 1994 Sentra had the water pump replaced but none of these things had to be done and that it was unnecessary. But then I thought, every car is different.
I was in shock with how much the repair would cost, so he then gave me another quote with just the timing belt and water pump replacement for $503, but this time he said that he will not give me any warranty for the repairs because of the tensioner.
View 19 Replies
Occasionally my 2004 Ford Focus will not start. I put in the keys and turn them. The lights and radio fire up and there is a click, but the engine won't turn over. To resolve this, I remove the key, open the hood, loosen the battery cable on the positive terminal, wiggle the cable around, and then tighten it back down. I then go back in the car and turn the key. The engine starts. Is there a bad connection somewhere? Should I replace the battery cable?
Long version of the problem: I've been having these problems intermittently for almost a year now. After the first or second time I had the car towed to a local shop. They couldn't figure out what the problem was because the car was starting just fine at the shop. The mechanic said that some of the cables might have shifted around in the towing process. So I tossed an adjustable wrench in the glove box in preparation for the next time. The next day, it happened again. Through some quick trial and error, I narrowed down the problem to be the positive battery cable (or something that's connected to it).
View 2 Replies
My 2004 Focus passed its emissions test in Maryland in the late fall last year. Shortly thereafter, the check engine light came on. My mechanic put it on the computer and said it needed a new catalytic converter. It only had 86,000 miles on it. I watched and waited for a few months and had the fuel filter changed during a routine oil change. A couple of days after the fuel filter was replaced the check engine light went off and stayed off for 4 months, but it came back on a couple of days ago. I have been watching the mileage carefully and it has been steady at about 26 MPG for years.
View 5 Replies
I have a 2004 Ford Focus. I had the battery replaced in May. Two months ago, the battery light came on for 10 minutes than went off. A week later the dash lights dimmed and then rebrightened. Talking with people they thought the alternator was the issue. I had it replaced three weeks ago. I got it back from the mechanic and it worked for two days.
On day 3 it would click and the dash lights would flash but it would not crank. Mechanic jumped it and brought it to the shop and found nothing. Two days later the same problem. Took to another mechanic and they found the radio was draining power so they unplugged the fuse. Again, it worked for two days, then the same problem. They have had it for a week and have no clue what is wrong.
View 7 Replies
My 2004 Ford Focus Hatchback has 152,000 miles on it. At the end of last year the engine started dying/stalling as soon as I started it - I would have to keep my foot on the gas to keep the engine going. I took it to the dealer and they put in a WHOLE NEW THROTTLE BODY. They also told me I needed a new battery and updated the car's software. Total $700. About a week to 10 days later, the car started doing the dying out after starting thing again - intermittently - didn't matter if the engine was hot or cold, fuel high or low, weather rainy, cold or clear and warm.
This morning I worked for 20 minutes to keep the engine going, made sure the engine was warm, and it STILL stalled out. I called in for a tow, called the dealer and said I'd be coming in, went back out to the car ... and it started right up without stalling. Drove it to the dealer and they've now told me they can't find anything at all wrong with the car. They are keeping it overnight to see if they can duplicate the stalling tomorrow morning. Any thoughts? The new throttle body cost me about $500 in December. (Don't know if it matters, but the defroster fan was super loud this morning, but once the engine was able to idle, the loudness disappeared ...). It's been a great car, but maybe it's time to start looking.
View 3 Replies
In January, I had the alternator replaced on my 2004 Focus after it died in the middle of the street. It's been fine since then, but yesterday I was driving it and it suddenly seemed to lose power - the dashboard battery light came on, there was the dinging noise that indicates that a seatbelt is unbuckled or the headlights have been left on when you open the door, and the fuel needle dropped to empty (even though the tank was 3/4 full.) Then everything kicked back on. Then it happened again. This cycle repeated three or four times. I parked the car, restarted it, and after that it was okay. BUT - I have two long trips coming up, to remote areas of the Rockies, and I want to make sure it's okay before setting off on these journeys.
It seemed like the alternator was bad, or maybe there was a loose connection, but I took it to the mechanic and he couldn't detect anything wrong. The alternator is under warranty, so he's suggesting that I just replace it, but also wants to run "other tests" to see what's going on.
Of possible relevance: it's been pretty cold out here for the past week (-5 F), I don't drive the car that much, and it was the first time I'd started it in several days. The heat and radio were both on when I started it. I left it running in neutral while I scraped off the windows, which I usually don't do. Generally I scrape off the windows first, then get in, start, and just drive. Sometimes it's sluggish in the cold when I do this, but usually it's fine.
Is it possible that this was just the cold? I'm wary of getting into a situation where the mechanic starts finding a bunch of stuff wrong with it that isn't actually wrong.
View 5 Replies
