Ford F-150 (2009-2014) :: Front End Single Clunk / Pop During Turning
May 18, 2013
When making turns and occasionally during slowing and accelerating, a klunk or pop sound comes from the front of the vehicle. It is a F-150 STX 2011 2WD shortbed with 16,000 miles. Engine is 5.0 with 6 speed auto. Previos owner had (before returning to stock) put a lowering kit in, headers back exhaust, intake, tuner, etc. Truck is butchered a bit from pos previous owner. Front end components have all been checked, bolts torqued. Even the cab mounts have been checked. The only thing that can be seen that might contribute is the cat crossover supports have been hacked off.
View 1 Replies
Advertisement
2005 GTI 1.8T 5spd 97k
Pretty much every time I back up and turn, I hear one loud, single pop from the front end. Occasionally, it will happen when I start forward from a stop (if turning) but that's it. It never happens at any other time. I can't decide if it's suspension or steering related. Where could this be coming from?
I have gone through the front end thoroughly and the only issue I find is my passenger inner CV boot has begun to crack and has lost some grease. I would expect a CV failure to click anytime I'm moving and turning. Again, I never hear this noise under any other circumstances.
View 19 Replies
When backing out of same parking spot, I always hear a clunk, clunk, clunk, noise in the front while turning the steering while back in the fixed position. I have heard this noise in the past but did not think any thing of it.
It's hard reproduce this noise, it seems to only be happening when backing out and turning the steering wheel. Car only has a little over one thousand miles.
View 2 Replies
2012 3.5 EcoBoost is a twin turbo or single?
View 2 Replies
Last year I had a bad accident and my front passenger side tire completely ripped off. State Farm fixed it and all was fine. But About 2 months ago I've been hearing this single click on the right front when I was turning right and on the left front when I was turning left. Took the car to different dealerships, one barely looked at it and tried to charge me $300 for jacking up the car and tightening 10 bolts, the other said that my axle is cracked and leaking and recommended replacing my strut mount and sway bar links. So after those were done I drove it home and on the way back I heard the same noise but somewhere underneath my seat a couple of times when I accelerate and decelerate. The dealer took my car away for a week and a half to figure this whole thing out with state farm and forced me to pay for part of the rental car.
View 5 Replies
My click sound is inconsistent, but typically, it's when I make a hard right or left turn. This being said, there are times I've was making a slow turn and my car still made the click noise. The turn can be a small one while in the lane for the off ramp of the freeway or a sharper turn around the corner. My impression is that when there is more force towards one side of the car, my steering wheel shaft is clicking. I also notice there's a click sound when I turn into a dip like when I drive out of a driveway onto a street that's lower than the driveway. The sound is also typically paired with moderate braking and turning. Someone who was in the car and heard the click and mentioned that it might happen when I make a sudden turn.
The single click is coming from the exterior of my car (I can hear it clearly when my windows are down) and around the engine area. I don't physically feel anything when I hear the click but I'm afraid that something may become an issue in the future. The click is also slowly driving me insane!!!
I've already gone back to my dealership and I bought this car brand new. It started happening almost immediately after I bought the car. When I took it in, they said they tightened a bolt (didn't specify which).
I've asked so many individuals and they can't think of anything. It's definitely not a CV issue because the car is brand new and the sound is a single click rather than a continuous knocking.
View 4 Replies
2010 F-150 King Ranch. Randomly when turning left, it feels like the left front brake is engaging and it sounds like your anti-lock brakes when you come to a stop on slush or snow. The truck slows with your foot still on the gas, Saturday it came to a complete stop before it released.
I have had it to 2 Ford dealerships, the first could not get the symptom to occur on a test drive and told me there was nothing they could do because they did not now what to look at.
The dealer I bought it from got it to act up, replaced the IWE 2 weeks ago and 3 days later was still doing same thing. My wife dropped the truck at the dealer again Weds.morning, she told them it did it on the way there. I called at 4:30 to check and they said they drove it 2 times and it did not act up.
View 2 Replies
We just bought a 2010 F150 SCrew XLT 5.4L 4x4 92k miles on Thursday. I noticed Friday night when stopping at the bottom of a small hill there was a clunk as it down shifted into 1st right as I stopped. This is just down the road from our house. Saturday night same deal except when I went to accelerate the Tranny seemed to be slipping, engine reved up but no go. Let off pedal and reapplied foot to pedal, truck drove no problem.
View 6 Replies
I have a 2009 f 150 two wheel drive and after reading and doing a little research I found my problem. Slip yoke same as alot of guys here,come to a stop clunk,take off clunk. My question is my warranty ran out,I had a 30,000 or three year and now I have 31,000 plus it's like the truck new when the warranty ran out. There is a TSB on it,10-22-6 NOV 10 Drivetrain - Driveshaft Slip/Bump On Accel. Or Braking... Will they do any thing for me,and how much would it cost me to have the work done at a shop.
View 11 Replies
I have a 2009 f 150 two wheel drive and after reading and doing a little research I found my problem. Slip yoke same as a lot of guys here, come to a stop clunk, take off clunk. There is a TSB on it 10-22-6 NOV 10 Drivetrain - Driveshaft Slip/Bump On Accel. I am going to pull the rear driveshaft and put in new grease MERCURY MARINE GREASE with TEFLON (2-4-c ) part nbr 92-802863A . How much do I need, will 8 ounces be enough.
View 3 Replies
I am looking at a 2010 f150 4x4 lariat that shifts and drives great a thru all gears and down the highway. The truck makes a clunk whenever you start to move from a dead stop ? go about 5 feet and it runs great? my 07 fx4 has 247,000 miles and still doesn't make any noises, the 10 has 75,000 miles on it ford maintenance oil changes and trans flush, am going to have mech look at it, anyone think of possible items to zero in on? it has the 6 1/2 ft bed with 2 pc driveshaft ...
View 7 Replies
Having intermittent clunk felt in the steering wheel? It happens at random and not necessarily over bumps. You don't hear it as much as feel it in the wheel.
View 3 Replies
2005 2.3Liter 4wd Mariner, 225k miles
I have been experiencing clunk noise on the front end when braking or accelerating and turning wheels.
I have replaced: front control arms, ball joints, tie rod ends, sway bar bushings and stabilizer links and 2 days ago I replaced strut mounts and bearings.
The steering is smooth after the strut mounts replaced but I can still hear cluck noise mostly on left now when going over bumps, braking and accelerating.
Car also has new engine/trans mounts.
I am so lost right now because I cannot figure out what is it. The only thing I didn't replace are the struts but the I test them and they seem to function fine.
View 5 Replies
2010 F150 XLT FX4 5.4L Crew Cab Medium box, nice blue truck, lacking on chrome though.
My friend has a clunk/lag on take off from a dead stop only. Drives fine down the road, but when taking off from a complete stop, you step on the gas, and nothing happens for a second, feels like it lags, then clunks, gives a jerk, and takes off.
From talking to other newer Ford owners, seems like a common problem.
View 9 Replies
I have a 2014 FX4 Ecoboost with 2K miles. While driving in a straight line on smooth roadway I feel a slight 'clunk' in the steering wheel. Feels a bit like slack or something. It only happens when the steering wheel is in perfectly neutral position ( straight up) with no turn to either side. Oddly I feel it more when I hold the steering wheel in the lower half as opposed to the upper side. Could it be 4X4 play or splines or loose something in chassis?
View 14 Replies
I've had my truck start making a nice CLUNK from the vicinity of the rear axle when starting moving from a standstill. (and it's a pretty decent thunk sometimes, you hear it AND feel it). I called and made an appt to bring it in and have it checked out (also having the first oil change done and gonna see if they can figure out why the automatic headlights are almost always on even on a bright sunny day) ...
View 14 Replies
Well it's been 300 miles since Ford applied their "special grease" and put on clamps to eliminate the clunk when slowing and the slipping feeling at take off. Now the clunk is back. Every time at 25 it downshifts and clunks, then once again at 10. Drives me nuts. My service advisor wants me to "log" these visits so we can be more aggressive with Ford to get this resolved. I love the truck, but this is annoying driveline slop. Almost like the splines weren't cut right and Ford is using heavy grease to fill the gaps......developing...
View 3 Replies
I have a 2000 Excursion lifted 6 inches with 35" tires on 20" Fuel wheels and i notice when I make a left or right hand turn between 10-20 mph i get a single pop or clunk from the front end.
Also one more really annoying thing while i am turning there is creaking, sounds like body flex? maybe body mounts? Any issues with ball joints?
View 14 Replies
I've noticed an intermittent clunk which occurs when engaging the hydraulics brakes during reverse maneuvers. It happens with anything from very light to very heavy brake force and typically will happen before driving very far (backing out of driveway, out of parking spot, etc) but does not happen after driving (backing INTO driveway or parking spot). This has been occurring for a while now with no other symptoms (other than some shudder during take off which I attribute to a sloppy transmission bushing).
Front brakes were in great shape when I r&r them a while back to turn the rotors, didn't pull the rears apart but they look good, and I don't have any brake vibrations or issues when moving forward. I can't rule out a driveline clunk or suspension clunk either but the u-joints don't have any slop in them and no squirrely handling issues either.
View 5 Replies
2014. Noticed the feel and sometimes clunk when shifting to 4 high? My house sits up a hill and this time of year, routinely have to use 4X4 to get up. There is a little more noise and vibration than im use to. Usually shift coming down a semi flat dirt/ice road at low speeds, typically about 10mph. Going in for first oil change soon and was gonna ask them to check it out for peace of mind.
View 6 Replies
I am experiencing a loud clunk sound at the end of the extension cycle. This is on the driver side and it appears to be associated with the back hinge assembly. Is there an adjustment for the length of travel? There appears to be a slight amount of play if I pull up on the aft end of the board. There is zero play in the front hinge on the driver side or in both front and back on hinges on the passenger side.
View 3 Replies
