Ford F-150 (2009-2014) :: 2010 / 5.4L - Blue Smoke On Cold Start
Dec 5, 2012
Experiencing blue smoke shooting out the tail pipe of your newer F150. Mine has been puffing blue since 12,000kms, still doing it at 55,000kms. Been to 2 Ford dealers (6+X) and they can never seem to repeat it. However it has been getting worse. Shop foreman guessed and said its valve seals.
I took a video, which I will post here, contacted Ford customer relations, and they tell me until it smokes at the dealer they cant go ahead with any repairs.I told Ford my truck will sit on the dealer lot until it smokes again and I am not driving it anymore. Photo is worth a thousand words, video is worth none. This is driving me up the wall!!.
2010 F150 5.4L Engine blue smoke - YouTube
Note the blue puff in the video is my truck, taken last Friday, and this is a small amount. Normally it fills my driveway and garage.
View 6 Replies
Advertisement
Some background, my truck has been sitting in the garage for a good month and I haven't started it. Been putting in 6 days a week for over 2 months at work, 60+ hour weeks. Today, I start the truck, it immediately dies. Successive attempts same result, blue smoke out the exhaust. I kept it running by revving it up but then it dies again. It's the original battery, 5+ years old now. MM shows 12v at rest, drops while cranking. I put the charger on the battery for a bit while I came inside to ask this, it's on trickle 2A and its at a 7 on the dial, and it goes to zero when fully charged.
I've been thinking I'll need to replace the battery before winter, but I'm hoping it's just that since its discharged that's why it won't stay running? Any thoughts? I have had zero issues with this truck but having a company truck over a year now, it sees very limited action. 2010 5.4 with just a tick over 40K, oil is good, air filter is clean and free of obstructions. We do live in the woods and have critters that hang out in the garage, like squirrels and chipmunks but I'm not seeing any evidence of chewed wires that I can see. It's in the garage and using a droplight I don't see anything obvious. Maybe it's as simple as I have to take the work truck and get a new battery I hope...
View 14 Replies
I purchased my 2013 Ford F150 3.5L Ecoboost screw in December 28th 2013. I now have 12,000 miles on my truck. My transmission occasionally clunks in and out of gear. Mostly in stop and go rush hour traffic around 20mph. Dealer applied a PCM/TCM software update in July. Still clunks... possible 'slip bump fix' required?
When I 'punch it', I see what looks like blue smoke blowing out of the tailpipe. Tailpipe has soot buildup. I've also noticed a slight drop in MPG. I have NOT noticed a loss of power. Wondering if my truck needs induction cleaning?
View 12 Replies
How many of you have this issue with your 2010 5.4 puffs a cloud of smoke on start up I have 20,000 klicks on mine after 8 months....
View 7 Replies
I have a 07 6.0 powerstroke, I had 2 bad injectors so I replaced all of them with reman's. I had a problem with them coming loose. the first time this happened it hydrolocked the motor, number 8 cylinder. so I pulled all the injectors and replaced all the seals and washers and torqued them down a little more than spec like 27 lbs. it runs great and starts great even at 25 degrees but I noticed this morning that when starting it up after it sits (cold) it blows blueish smoke until late it warms up and I accelerate. is this normal? should I check fuel filters? oil in fuel?
View 14 Replies
Got a 2002 7.3 F-350 with 300,000 miles and for the last couple of years I've been getting blue smoke on cold morning start ups and its been gradually getting worse, it clears up after about 30 seconds and all is normal,No loss of performance, Oil consumption is minor, however I hate a vehicle that blue smokes, I'm guessing my issue is valve seals are worn, I was wondering if it is possible to replace the seals while the heads are on the engine? and was also wondering how much time it would take to fix? as i would have to have it professionally done. I know its hard to guess a time frame and everyone is different. Sounds like textbook valve seals to me but is there anything else I should check first?
View 14 Replies
I have noticed 3 times so far blue smoke coming out the tailpipe upon start up. I have not been able to reproduce the issue on demand but I have seen it myself 3 times and it concerns me a bit. It's a 2012 with 36k on it. I changed the oil at 1k, 5k, 10k, 20k & 30k. Last oil change was done by the dealer but every oil change was done with Lexus Filter and synthetic oil. I have not noticed a loss of oil by the dipstick either. I noticed the poof of smoke last week when I was outside at the carwash and one of the employees moved it. I also noticed it when I used remote start the other 2 times. It's not enough that I would be able to see it from inside the truck. I also have black carbon / soot build up in the bottom of my tailpipe but I think that's with all vehicles. I know if I bring it to Lexus they will say "Unable to duplicate issue" and send me on my way.
View 12 Replies
My RX350 has less than 18K miles and it has signs of bad valve seals. If I start the vehicle after it sits for a while, a large puff of blue smoke emits from the tail pipe. My 02 Dodge with 188K miles doesn't even do this.
View 2 Replies
05, 170k miles. Studded and egr delete but I don't have paperwork on either. Got a pretty good deal on the truck but I have a few questions..
It runs and starts great, warm and cold, with only a little blue smoke on cold startup. but every now and then when idling (say at a stoplight) the engine gets noticeably rougher, not terrible. No smoke. Goes away after 5-10 seconds.
When I remove the oil cap, there is a "puffing" blow by, not constant, and its not enough to blow the cap off if I set it on backwards. Just puffing.
This may be related, but I pulled the starter wire off the drivers side and touched it to the battery to hear how it cranks, and there is a noticeable blip in the cranking, its not 100% smooth.
Don't think I am losing any coolant. Runs great, getting 15MPG. No CEL. I went and had a relative comp. check done, cylinder 7 is the problem. We both are leaning toward there being a valve problem So I pulled the valve cover, now I have a few questions.
1. When I crank the engine over without starting, I can hear a "pfft....pfft....pfft" chug of air every revolution. I pulled the cover to see if I had a obvious rocker problem, but can't see anything because the oil rail is in the way. I'm guessing this air puff is sign of a valve problem?
2. When the truck is running, there is a small, steady stream of oil running down the rail and dripping onto the valve cover mating surface of the head, I think it was at every injector, definitely 2 of them. Was getting dark, so hard to see. Is this normal, or do I have a leak? Truck has updated dummy plugs.
My next step is probably going to be pull the rail, see if there is a obvious problem, then pull the head. And tips for me? Planning on having the HVAC evacuated then pulling the airbox.
View 9 Replies
Have a 2009 Ford F-150 with 5.4 ... Recently installed a cold air intake and now when I start it burns black smoke for maybe 15-60 seconds.
I have to rev the engine up by pushing on the gas or else it will stall.... after the 15-60 seconds the smoke turns clear and it idles with no problem and sounds normal.
This happens every time I don't use it for over 9 hours or so if I leave it for a couple hours it will start normal and idle normal....
View 3 Replies
Recently since the weather has been cold. between 0-30 degrees or so. My 2002 7.3 with 161k on it is smoking a decent amount i think. far more than i ever remember it smoking thats for sure! anyways its a combination of blue and white smoke and it doesnt last long when the truck starts maybe 1 minute and the smoke stops.
But I also notice when i rev the truck maybe around 1200 rpms the engine shakes very bad. so i was thinking maybe a glow plug went bad making the engine seem like its missing. but even when its warm i rev it up to 1200 and i still feel the engine shake slightly. Maybe im just being picky when its warm? I need to test the glow plugs and go from there but i want opinions about that issue. the truck sits for 4 hour periods and every time i start it i have smoke. I will pay attention tomorrow morning if it smokes after being plugged in all night and post my findings.
My other issue and this typically happens when its below 20. sometimes i will go to accelerate after coming to a complete stop and the truck kinda has a very weak rev to it then just takes off like the tps took a break on me. sometimes i have had it jerk the truck when the throttle catches and other times it creeps at first then takes off like a boost of power.
lastly and this little issue happens most noticeable at 35 mph. i feel a surging im thinking this is related to the tps but i put the truck on cruise control and i still feel the surging. maybe this ties into my second issue? bad TC? ive plugged in my scanner and the only thing jumping out at me is the icp hunts about 100 psi or more at idle. i plan on doing a WOT test on the HPOP, ICP and IPR tomorrow and see if maybe this is just a weak hpop causing my issues.
Repairs i have done:
new 8th injector and all new injector seals about 25k miles ago.
new ipr
new icp
have CCV mod done and 4 inch turbo back exhaust
new map sensor
cleaned out the EBP sensor and tube but that was probably 40 or 50k ago now.
gray cps and i cant remember when i put that on.
gutted the EBPV
bellowed up pipes
no tunes the truck is factory as far as that goes.
View 11 Replies
2004 f350 4x4 sc dually 130K mi. Cranked truck this morning @ 18*F. Truck not plugged in but regular quick smooth startup. Noticed light blue smoke with normal condensation exhaust for about 5 seconds, then normal condensation exhaust for about 30 seconds. Drove truck at normal operating temps with 5* deltas. To my knowledge, truck has original turbo (Garrett), never been removed or cleaned by me. VGT at startup 70-72, running after warmup mid 50's. Is this a symptom of needing to replace turbo seal, and thorough cleaning while off?
View 1 Replies
My truck has been having this issue pretty much since I have had it, but it seems to be getting worse, or so I think.
When the truck is cold, it does not want to move very well. Like it's missing, and it does this until it gets warmer. Also, I have puffs of blue smoke come out the tailpipe when this occurs with it cold.
Injectors? Injector o-rings? Stiction?
FICM volts are good at 46.5v-48v when cranking.
View 6 Replies
I only see it on start up, after it starts I don't see blue smoke or smell it could this be valve guide seals? If so are they hard to change? This truck has 168000 miles on it and has a 4.6 engine.
View 3 Replies
I have a 2010 F150 and now only cold air comes out of the vents. I have not changed the thermostat since the truck is not running hot. I have read that the blend door may be stuck. Where the blend door is on the 2010.
View 1 Replies
I have a 04 f350 with 175k on it. At around 160k it had new head gaskets, 2-reman heads, egr delete, new oil cooler and it is studded and tuned with SCT and custom tunes.
Since after the head gasket change it seemed to have started blowing a little smoke on the cold starts mainly. In cold weather the starts seem to be harder or slower also. Now for the last 6k-8k miles there is a little smoke at a cold start. But if the motor is warm and it sits for a bit maybe 10 min or less it blows a nice puff of blue smoke or burnt oil.
The smell of burnt oil is mainly on hot starts not cold starts. It does not burn oil running. It will dump some black smoke under acceleration or load. Could this be an injector problem? Or something else? Can't figure it out.
View 5 Replies
My 04 6.0h started puffing bluish colored smoke typically only when I was accelerating. After a short amount of time I noticed it was smoking quite a bit when cold and until it had fully warmed up. I took it to the repair shop and they pulled it apart saying the turbo seal had failed and the turbo was full of oil. I purchased a new Garret PowerMax and had it put it in.
I picked up my truck and of course it was still smoking when cold. After it warmed up nothing, just like before. Since I just put a new turbo in I am worried this one will be ruined as well since the same condition exist. My mechanic said I need to run the truck for few days before the oil would get cleared out which had accumulated in the system. Am I mistaken in thinking that if it was residual oil burning that it would be more likely to do smoke when warm as opposed to when cold?
Since the turbo and seal have now been replaced what else should I look for to cure my blue smoke blues?
View 2 Replies
Ok I thought I remembered reading about this in the past. This morning I detailed the V8 T (19K miles) and started it to back it out of the garage. Got a big puff of blue/white smoke out the back. I searched but found nothing. Should I finally run to the nearest BMW dealer for an X5?
View 24 Replies
I have a problem with my Lariat blowing cold air on the driver's side. It happened last weekend when it was snowing hard and drove around town for a couple hours with defrost on. After I got out on the interstate the cold air was blowing in through the vent on the driver's door and down by my feet. It was -4 driving home. I though that some ice may have gotten in and jammed a damper open allowing cold air in. I took the truck in and thawed it out and the same thing happens. Cold air out of drivers side and hot air out of the passengers side. The truck has the dual heat/cool setup and it seems as if the driver's side is stuck on cold but I have it set on just driver. It was only -25 this morning.
View 10 Replies
I have a 2010 lancer evolution, intermittently under light to no acceleration the car emits a large cloud of blue-grey smoke from the exhaust accompanied by noticeable oil consumption. This only happens when in 5th or 6th gear or when it changes from 5th to 6th. It only seems to happen when accelerating onto the highway or when going up an incline in a high gear. It only ever lets out smoke when under 2500rpm, never above 2500 and only for a second or two. if I downshift to 5th while this is happening, it stops. I'm at a loss as to why its burning oil.
View 14 Replies
I have a 2012 F-150 Platinum 6.2L. Every morning after a cold start, I get this humming sound until the engine heats up. It does seem to get a little quieter when I'm moving but not much. This only happens after the first start of the day and has only started doing this since it's been cold (20-30 F).
YouTube ......
View 2 Replies
