Ford F-150 (2004-2008) :: Rust Bubble Popping Up On The Rear Of The Bed
Feb 21, 2011
Issues with rust bubble popping up on the 2004 f150's...
I have some rust bubble's on the rear of the bed right around and under the FX4 sticker...
Feb 21, 2011
Advertisement
Ford F-150 (2004-2008) :: Paint Chirping / Rust Below Gas Cap
I've got an 07 f-150 and the paint is starting to chip below the gas cap, there isn't really any rust yet. Whats the best way to fix this? I was thinking about taping it off and sanding a bit and then spraying on bedliner spray.
View 1 RepliesFord F-150 (2009-2014) :: Bubble On Grille / Noise And Rear Defrost Down
My Platinum has 23000 miles now and is a little over a year old. Lots of small problems so far but Ford too care of everything on warranty.
Now I discovered 2 small bubbles on the grille and so not like that. Also the rear defrost does not turn on. Neither by pushing the button on the console or the touch screen one. It does not activate - no indicator turns on nor does it defrost.
For once a week at least I got a grinding noise/vibration from the front power train. Ford can't find any issues and it never does it when they test drive.
Ford F-150 (2004-2008) :: Shutter In Power Steering - High Pressure Hose Is Leaking From Rust
I have a 2004 with the 4.6l. The high pressure hose is leaking from rust. From other posts I have read, it looks like I should rent a puller and remove the pulley first, and then I'll have access to where the hose connects to the pump.
Question: The leak occurred while driving home from vacation today. Went we stopped for gas, we noticed a shutter in the steering. I added about a 1/2 quart to the reservoir - there was still some fluid but foamy. I made it home, and I when I checked again the reservoir was empty.
Should I go ahead and replace the pump while I am at it? I wondering it if could have gotten damaged from low fluid. The truck has 190k so it's not like the pump owes me anything. Will it make any of the repair easier to toss out the pump too?
Golf/GTI VI :: 2012 - Air Bubble In The Sidewall Of Both Rear Tires
So I just got my 30k oil change done on my 2012 GTI and the dealer found an air bubble in the sidewall of both rear tires (Pirelli P Zero Nero). Luckily I bought a third party wheel and tire protection plan from the dealer where I purchased the car so the tires were covered. Tires were replaced and rotated to the front. Drove home the next day (all interstate travel), and woke up the next morning to find another bubble in the sidewall of the right rear (rotated from the front). 4th tire with a bubble since last August. I know this is an issue with low profile...
View 24 RepliesFord F-150 (2004-2008) :: With New Tip Installed Now Exhaust Popping?
All I did was cut off the straight section of tailpipe and install a 2.5" inlet, 4" outlet exhaust tip. It sounds a bit deeper at idle and a little louder when I rev it, but when I let off the gas it pops pretty loud.
I remember hearing popping on decel on videos of trucks where aftermarket exhaust/mufflers were installed, but not just from a new tip.
Ford F-150 (2004-2008) :: Popping / Clunking Noise When In 4WD
I've read alot of info about the 4WD system on the F150's, and I'm having trouble diagnosing what might be going on with mine.
When I put my truck in 4HI (or 4LO), I get a popping sound that seems to come from the front middle/front drivers side when going at speeds around 20-25 and over. I don't experience any loss in traction (that I can tell) or power, but the popping is very loud and noticeable (passengers can hear it clearly).
My problem is a little different than most, as their issues with popping seem to happen when they are not in 4WD, where mine is only when in 4WD. I replaced the IWE solenoid today (wanted to anyway to get the updated casing/shroud) and the problem stayed. I also disconnected the vacuum lines at the solenoid and drove - no noise. I then kicked in 4WD on the switch, and the noise started, which leads me to think it is not vacuum related.
I am kind of lost as to what may be going on. I would think something where teeth broke, etc. would make noise all the time in 4WD, not intermittently or at certain speeds. The noise sounds almost like popcorn popping. I went up the same hill about a dozen times today, and it happened maybe 5-6 times. I don't hear it often (if at all) with speeds below 20 MPH. I can switch in and out of 2WD, 4HI, and 4LO all day with no issues, as well.
The only modifications to the front end have been a 2.5 inch leveling kit, and the only other issues I notice in the front end is a shaking when on the highway, that seems to go away after a while of driving at the same speed. I recently had a front end alignment, and the only thing the tech mentioned was that I will need ball joints in the next 6-8 months (but he said they weren't bad).
Ford F-150 (2004-2008) :: Wiper Cowl Keeps Popping Up In The Center
2707 150 4x4 supercrew. the damn wiper cowl keeps popping up in the center, then it seems I get ice under the edge and against the window, and she sits and growls at me at hwy speeds. like someone is rolling a golfball around and around and around...etc.
View 14 RepliesFord F-150 (2004-2008) :: Grinding And Popping From Under The Floorboard On Front End
2004 F150 SCREW Lariat 4x4. Experiencing some odd noises. When driving down the road and turning the wheel slightly left will produce some grinding and popping from under the floorboard. I'm suspecting a CV axle as the boot is ripped on that side. Would this have anything to do with the IWE system or solenoid??
View 1 RepliesFord F-150 (2004-2008) :: Popping Noise Coming From Front End
Alright, so about a month ago I was driving when I heard a terrible noise sounded like a pop can stuck between a bike tire coming from the front end. I figured this was the dreaded noise most folks hear when the 4wd system isn't getting enough vacuum.
It did this for about two days, even after replacing the IWE solenoid, then it just stopped and I haven't heard it since. Me being on the cautious side, I'm a bit worried. I haven't jacked the truck up, but I did (brace yourself) lay under it while my buddy drove slowly over, there was no unusual movement.
Question is, if I had to replace anything, what exactly would it be and how much am I looking at? My warranty will be up in about a month or so and Ford has been less than spectacular with repairs thus far so I'd like to go ahead and fix it myself
Ford F-150 (2004-2008) :: Odd Popping Noise When Open Tailgate
So I'm having a tailgate issue. When I open my tailgate, sometimes the internal spring wants to keep it up, rather then letting it open down. It also makes an odd popping noise during operation from time to time......I don't see or feel anything broke in it.
View 7 RepliesGolf VI R :: Hit A Pothole Now Small Sidewall Bubble Developing On Right Rear Tire?
So I hit a pothole driving on the freeway a few weeks back and I have a small sidewall bubble developing on the right rear tire. I am asking around and apparently none of the shops carry tire shavers anymore.
Since our car is AWD my understanding is that depending on how much the difference is, they can either replace 1, or 2 (same axle) or have to replace all 4 tires.
Also is there any chance in hell since these are OEM tires that came with the car that VW would be of any assistance with the replacement of the tire?
Ford F-150 (2004-2008) :: Popping Noise In Front End When Turning Left
Hear a small pop in the cab when I am turning left pulled left wheel everything looks fine. Ball mount maybe, I don't want to tear into it at this point.
View 5 RepliesFord F-150 (2004-2008) :: Popping Noise And Fuel Lid Just Flops Back And Forth
Wife tells me last evening while in gas station fuel lid on side of truck made a popping noise and lid now just flops back and forth and does not stay shut. I haven't looked yet but is this common problem and can i fix or dealer job. 2004 F150 XLT ....
View 1 RepliesFord F-150 (2004-2008) :: 2005 - Popping Noise Coming From The Front End?
I have a 2005 ford f150 supercab 4x4, and around feb I replaced all the ball joints my self, and now recently when back with the wheels turned turned to the left and then put it in drive and turn the wheels all the way right and give it has to take off there is a popping noise that comes from the driver side front wheel and it just does it once I take off and quit . I've looked and everything and cant see anything that would cause this. And know when I put it in park and it rolls forward I can hear a popping noise that sounds likes it coming from the rear end. I had my rear rebuilt, with new pinion bearing and race, a new axle on the pass side with bearing and the shop told me that it the driver side is questionable on the axle but it has new bearing also, they also told me that it needs a carrier case cause it had groves wore in it where the axle bearings wore out so much. at the time I could afford to have them to replace the carrier case. what would cause the popping from the front end and now the popping in the rear end.
View 1 RepliesPrius (2004-09) :: Rear Axle Cracks / Rust At Corner / Bushing Arm - Squeaking Brake Pedal
Just hit 225k with my 2004 Prius about a week ago. I passed inspection without replacing the (slightly) cracked rubber bushings for now, but what worries me is the cracks and a slight hole (it has not rusted completely through). Pictures attached. Should I do anything about this, and if so what?
Also, I've noticed that when I let go of the brake pedal, especially after a medium to the hard stop, I hear a squeaking... what's the cause for that? I know the front rotors have a bit of rust on the edges, but not sure if that's the cause... it seems to come from the back.
Other than that, the only other noise I've noticed is a slight clacking/tapping when the A/C is on, usually in hotter weather. The only thing I needed to pass inspection was to replace the muffler after a year and 1/2 ago, the last non-OEM part they put in at another shop was junk and rusted through pretty badly leaving a hole that was leaking. Ended up getting it replaced at the dealer with the OEM part this time...
Ford F-150 (2004-2008) :: Popping Type Noise When Turning The Steering Wheel To Right
I have an 08 F-150 5.4. When sitting still or moving, and turning the steering wheel to the right and only the right past center, there is a popping type noise somewhat like a screw driver down a washboard (for those who'll know what that is). I replaced the ball joints because I saw a slight amount of play, but the noise is still there.
View 12 RepliesFord F-150 (2004-2008) :: 2005 FX4 Engine Missing Under Acceleration / Popping Sound
I have a 2005 FX4 with a 5.4L. I have noticed in the past 3 months that when I mash the go pedal hard the engine misses and there is a popping sound. My gas mileage has gone down 2-3 MPG.
View 10 RepliesFord F-150 (2004-2008) :: Popping Noise While Driving Or Parked With Engine Shut Off
2008 F150 4.2l Popping noise cannot detect source. When the truck gets warm it makes popping noise while driving or parked with engine shut off. Noise is getting louder. This truck has about 50,000 miles on it."
View 1 RepliesFord F-150 (2004-2008) :: 4wd Doesn't Work - Riding Roughly - Popping Sound Over Bump?
Ok my 2004 F150 has been messing up lately. The 4wd doesn't work. Pretty sure that's the actuators however, now it is riding EXTREMELY rough! Every time I turn the wheel to turn into a parking lot and then proceed to enter the lot something in the front end pops! Loudly! It sounds like popping out a dent like its loud! What it is. I just know 4wd doesn't work, there is a loud popping noise when I hit pot holes or turns. I CANT even go off road now because of the popping noise and also it is extremely extremely rough. Any clues on what's up?
View 3 RepliesGolf IV R32 :: 2004 - Loud Popping From Rear?
I bought a 2004 R32 in July. On mornings after it rains overnight or has been particularly humid I get a horrible popping sound when I drive forward or backwards. It is a reasonably slow sound only loosely tied to vehicle speed in a straight line. When turning it is very rapid which made me originally suspect the differential. Removing the Haldex fuse, turning off traction control, and dragging the brake pedal have no effect. Dragging the e-brake seems to stop it until I release it.
The only thing that fixes it is leaving the car running for a little bit. Sometimes it is 2 minutes, other times it might be 5 minutes. Monday when it did it I pulled over a little way from my house and waited. I heard the pop with the car out of gear and parked on level ground not moving. I started driving immediately and there were no more problems. This is the only time I heard something when it "fixed" itself. The popping sound is somewhat like a bad CV joint when you turn the wheel tightly.
The car will go a couple weeks without this happening if it is dry out. I have had a bunch of quattros, but this is my first Haldex which is why I suspect it. I have pulled codes and get nothing for the Haldex. When it is working it behaves perfectly. What to try? Alsobhow water got in my Haldex in the first place to make the milkshake? I am concerned it will happen again. The previous owner had it changed at the dealer in 2013.