Ford F-150 (2004-2008) :: Running Very Rough / Shaking At Low RPMs - Truck Died
Jul 29, 2011
On my way into work this morning, my 06 with the 5.4 started running very rough/shaking at low rpms. I could kick it out of overdrive and it would smooth out and seemingly be fine at higher rpms.
This worked out for a couple of miles until the truck just died on me completely. The Edge is showing po351, 352, 353......358 codes. Ignition coil Primary/Secondary circuit fault on every cylinder.
I'm thinking its unlikely that every coil failed simultaneously....computer? When I try to start the truck, it will try to hit on a cylinder or two, but will not run.
View 3 Replies
Advertisement
I have a 2004 SD with 5.4 that is running pretty rough both at idle and driving. Truck shakes a lot at lower rpms. I have a scan tool and had a misfire on cylinder 4 so I replaced the coil and the plug. Also replaced the idle air control valve. Plan on replacing O2 B1 S2. (One of my codes) even after replacing the coil and plug I'm still getting misfire detected from cylinder 4??? Other codes I had were misfire detected on he first 1000 revolutions. That hasn't come back though.
View 2 Replies
First it was the whole spark plug debacle. Now it's the "fuel pump module". Story starts a several months back. On a moist day I was headed out and the truck ran very rough, "clunky", like it wasn't getting gas. After 15 miles and a stop truck ran fine. Didn't think much of it and truck ran fine for month or so. I was then away for a couple days and came home to find my truck wouldn't run (started briefly then died). Local mechanic thought it might be a fuel pump issue but then got truck running thinking it might have been a delayed inertia switch in front panel (I had hit a deer a week or 2 prior). Again, not thinking much of it continued to drive truck with no issues for awhile. Then one rainy morning on my way to work the truck was running very rough and "clunky" again. It died several times and finally for good.
After getting it towed to the mechanics, he figured the fuel pump was finally shot. The end to my long story is it was the fuel pump module (luckily a lot cheaper fix than the fuel pump) - half of the housing was gone (corroded away) adn moisture was shorting the pump electronics. Why, if this module is half encased in plastic do the engineers feel the need to encase the other half in metal (appeared to be cast aluminum)??!!????!! Of course it makes sense to have an electrical unit that is mounted underneath the truck where it can collect all the moisture, snow, salt from the road encased in a corrodable metal housing. No no, don't put it all in plastic, just half of the unit. MAKES PERFECT SENSE!! I thought to be and engineer took some sort of brains and common sense. Must be not at Ford. I can't be the only one with this issue and wondering WHY!!! - it must be widespread??
View 4 Replies
Last friday, my truck died while running. I let it sit for a few hours, went out and it started right up. Went to get pizza for my kids and I got 5 blocks from my house and I barely had any power. Truck died again while getting pizza and had to tow it home. Now it will not start. I have checked fuses, taken apart the fuel pump on the motor and cleaned the water from it, added a fuel treatment and also did an old truckers trick with the fuel (10% gasoline). the truck will crank and make an attempt to fire but it will not start. I have 3 kids and this is my ONLY transportation. I need to get this thing running STAT.
View 1 Replies
My 06 f150 v6 auto died on the way to work last night. It said trans fault on the dash. The trans has been shifting fine no slipping no hard shifts. The trans has 113k I replaced the motor and it has 57k. Both have been working great until last night. I plugged my scanner up it had a bunch of codes so I cleared them and done a koeo test and got 10 codes.
P0141
P0161
P0740
P0743
P0748
P0750
P0753
P0755
P0758
P0962
With the key in the on position the truck was showing 27.3 psi on fuel.
View 8 Replies
I own a 2007 Lariat F150 with the 5.4 4x4. It has 96000 miles.
That being said. The other day I was driving and went through a pretty big mud hole on a county road (couldn't go around it). Following, very shortly, my truck bogged down and died. "Low Oil Pressure" popped up. I let it sit for a minute, and checked underneath to make sure that I hadn't popped a line or ripped something. I hadn't.
I start the truck up again, and started driving no issues, for about 3/4 of a mile, and again it died, and "LOP". So I let it sit for about 15 minutes, thinking about why it would have that pop up. Couldn't figure out anything. Started again. and had a really rough idle in between the 500-1500 RPM range.
I decided to change out the oil when I got home. I put in some 15-40, hoping that would solve the issue.
It hasn't still idles really rough, but won't shut down anymore. I didn't try driving it though because I was afraid it would die again.
I'm not sure if the spark plugs are bad, I don't think they've ever been changed (I know it's bad). I'm pretty sure that it's not a vacuum leak, but not 100%. I need this truck to run.
View 12 Replies
I have a 2007 F-150 5.4L V3 Lariat with 90,000 miles on it. For about 5-6 months now I have noticed a strong sputtering when I am driving at low RPM's around the 44-50 mph range. When I lightly give it gas the sputtering begins and doesn't cease until I accelerate out of the current gear into a higher RPM/speed. This has become more pronounced over the last few weeks so my mechanic replaced the fuel flter and checked to make sure the pump was working as well. We also added some 5w-30 oil to make it full, even though 5-20 is preferred.
Truck ran smooth initially but then it got worse with the sputtering. A couple of days later I filled up my gas tank and as I pulled out of the station my truck shuttered alot and died. the CEL came on, LOP came on, and even the low tire pressure light came on. The truck will not start now, but it cranks smooth and strong until the battery loses power. I had the truck towed and then we reset the gas shut of toggle, sprayed starting fluid in the air intake, and checked all fuses, as well as the fuel pump engagement. Still no ignition. Next we replaced all spark plugs(4.5 hours later). Still no ignition. Only CEL light and low tire pressure light. I bought it used less than 18 months ago?
View 2 Replies
Ok I have a 2004 F150 Fx4 ext. cab. I had the truck for sale and due to something coming up I was unable to sell it. Kinda wish I did now. But anyways the truck was running great up until last week. I was drove it to work which I normally dont do. On my way home the rear end was making a weird noise. Kinda like a brake sticking. I tapped the brakes a few times and it seemed to work. Then a mile down the road it was doing it again without me trying to come to a stop and the back end was shaking. I pulled over and crawled under the truck to see if a u-joint was going bad. Everything seemed good. It never happened again until today.
This morning I hoped in the truck and went to my parents house. Its about a 5 mile drive and truck was acting fine. Came home and it was still fine. A few hours later I figured I would go up to the fire department I am on and find something to do up there. I got in the truck and didnt make it 5 feet from where I was parked and there was this bad noise followed by my whole truck shaking. It felt like the truck was going to fall in pieces in my driveway. I stopped looked around and didn't notice anything wrong. I figured I would just try to drive a little bit further and it was even worse. So I put it in reverse and it was normal. I put it in Drive again and thought my teeth were about to fall out of my mouth.
What could cause this? I know my transmission was leaking some oil from where the gear shifter comes out. I would check the trans fluid and add some if needed. I drove it up to the fire hall Monday night and did notice a slight burning smell but that was the only time I smelled it. Could it be the transmission?
View 6 Replies
I have an 07 f150 v8 5.4 and it idles very rough. When i start it it seems to start really rough and just about everytime im stopped its shaking just enough to annoy me. Do you think its the spark plugs? I took into the dealer about a month ago and they said everything was fine. But its still doing the same thing. Also the A/C tottaly sucks is that they way it is? When I accelerate the cold air gets kinda warm and it doesn't get cold until i get up to speed.
View 14 Replies
I have a 2004 f150 fx4. My truck starts to jerk around 50-55 mph at 1100 rpms and again at 80 mph.
View 3 Replies
I have a 2002 Ford Explorer and besides the seemingly oh-so-common annoying crack in the tail gate, I have another issue I consider to be major. Recently, on a short trip to the store, I hit an incline in the road of a slight degree. At this point I noticed the RPMs going wildly up and down and ultimately the truck died. I tested this out on a few drives and what I've noticed is that if I'm on a flat surface, the truck seems to be okay. OR if I do hit an incline, either lifting of the gas or powering through it seems to work...although neither of which is a long-term solution. I just lost my job a couple weeks ago and the idea of taking it to a mechanic scares me as I'm very limited on savings. I don't really know where to start.
View 6 Replies
i have a 2006 f-150 xlt, i was driving it today and it started making a 5x5 beeping noise shortly after i started it up. I read on a few forums that that beeping is a warning about the passenger airbag sensor or something. anyways it went away and kept driving for 5 minutes or so when suddenly the dash went out and all the gauges dropped but i was still able to drive fine. A minute later the engine just died and i managed to pull over to the side of the road. now nothing works when i turn the key, not even a light, its just a dead weight, the remote locking doesn't even work. the only sign of life is a LED from my phone charger that is plugged into the outlet. the battery is only 2 months old so its not that.
View 2 Replies
I have a 2004 VW Touareg with 116K miles. Yesterday the check engine light came on and she is running very rough at low RPMs. The manual tells me that there is either a problem with the exahust manifold or an O2 sensor is bad. It feels as if she is struggling for air. When you start the vehicle the check engine light flashes then stays on in the cluster. What can I expect when I take it in to the dealership? Is there anything I can check before I take it in?
View 4 Replies
Well I am not sure if i have trans problem or not. If I put the trans in drive and go through the gears when the RPM's get to about 2000 the truck almost stops accelerating, until you give it much more gas, this happens in every gear. but If you push the button to take it out of overdrive and drive like that it doesn't do it.
View 1 Replies
I bought an 04 f150 super crew cab with the 5.4L triton in it 3 years ago with 50k on it from my great uncle who was the original owner. It's had a tick to it since he had it but the dealership told him they couldn't find anything wrong with it and to get use to the noise. It's ran pretty good up until last couple months where it's been running really rough and not doing the best. It's still hasn't been all the time but more intermittent and comes and goes, but when it's running bad the rpm drops down to about 200 and my motor sounds blown.
When that's happening I could put in neutral and rev it up and it would go back to normal for a bit, but now it's all the time and stalls out even at 70 on the hwy. The codes it throws are, p1000- monitor checks not complete-more driving required, p0345- camshaft pos sens circ error(bank 2), p0022- A camshaft pos timing-over retarded bank 2. Things I have tried-changed all 8 plugs, added K&N air intake, replaced both cam sensors, replaced fuel pump driver module (due to corrosion). Tonight I'm going to clean the throttle body, mas air flow sensor, change fuel filter.
View 14 Replies
This morning I drove down to unlock my gate and got out of the truck while it was idling. When I got to the gate the truck just stopped running it did not sputter or anything it was like a light switch and just shut off. I got back in the truck and tried to start it but nothing happened starter did not engage at all or even try to run. I put a new battery in it knowing that is not the problem but it will just not start or even turn over.
View 1 Replies
I have a 2008 Ford Focus - 4 Door Sedan SE 60300 miles.
I've gone to 3 mechanics now and no one can seem to figure out whats wrong with my car. Here's whats happening:
About 1 1/2 years ago I took my car to get an oil change at Jiffy Lube (Yeah never again). When I left, my car was idling funny... Silly me didn't take it right back and have them tell me what was wrong.. so I let it go, well about a month later it started idling even weirder. Basically it feels like my car is shaking when it gets under 1000 RPM and I notice my RPM dial start falling and bouncing back, acting like its going to stall, but never does. I notice a loss of power when this is happening (on speed up and just accelerating in general). All of this is random, I can't seem to put a pattern to it as to when it happens. One day I'll start it up and everything is perfect... Then I'll shut it off and restart it later, and it starts vibrating and puttering again... No signals as to if its hot/cold or wet/dry, no environmental variables seem to cause it to happen anymore than others. And there is no check engine light on, everything "looks" normal.
What I've had done to it so far is:
Air filter changed / reseated
3 oil changes (keep getting told it will work)
Throttle cleaned
Computer reset for idle sensor data rebuilding
Now I'm told that I need new engine mounts, and that could be the reason for the vibration. I'm thinking that the vibration caused the mounts to wear out, more so than the mounts being the cause. Mainly because I don't see how bad mounts could cause loss in power/bad idling.
What could be wrong?!? Really bugging me and don't want to keep throwing money at it for phantom solutions. Seems like mechanics I go to can't figure it out unless there is a check engine light on with some diagnosis code to tell them exactly whats wrong.
View 8 Replies
At 2:30am this morning I looked out my window and saw my brake lights and third brake light come on for about 5 seconds and then go off. This scenario kept repeating itself. I went to drive my truck 2007, and the brake lights remained on even when the lights were turned off when I was driving. I also need to seal the third light. Brake regulator has been replaced.
View 2 Replies
Let me describe this perplexing issue. I have a speratic rough idle problem. When it happens it's almost like the truck wants to stall. Once going the truck is fine. There has never been any acceleration issues, but for a short time the truck would kind of lunge off idle. It hasn't done that for quite some time. I've replaced the fuel filter. There are no vacuum leaks that I know of. I've tried higher octane fuel. I've tried injector cleaner for a month. What should the fuel pressure be and what is the test port located? Is the fuel pump in the tank? If so, whats that big log looking thing behind the gas tank that the fuel lines run to? Also, there are no MIL codes...
View 14 Replies
History: Truck was running okay but acted like a coil was bad when under load. I changed out all the plugs with Motorcraft and put on Summit racing COPs.
After the plug and cop change the truck will run rough after it is warmed up. I changed back to the old COPs and it runs the same.
First I replaced the MAF sensor after finding many posts on here about it. No change.
I read a bunch of posts on oil causing the problem so I used 10-30w and nothing changed.
I searched for a vacuum leak with carb cleaner and couldn't find one. I removed, cleaned and reinstalled the throttle body.
When I did the plug change I disconnected the PCM without disconnecting the battery. Would this cause this type of problem?
I think this is about all the stuff I found to try in the threads that came up through searching.
View 13 Replies
My f-150 has an intermittent rough idle and consistently runs rough when you accelerate quickly. Vehicle is not throwing any codes?
View 3 Replies
