Ford F-150 (2004-2008) :: Rattle Up In Driver Side Dash Area Near The Windshield
Jan 3, 2011
I have a 2004 FX4 and have a very annoying rattle up in the driver's side dash area near the windshield. This happens every time it gets to be winter. The odd thing is, that it will sometimes go away but when I hit an uneven surface such as a railroad crossing, I hear a loud "pop" near that area. Then it will rattle non stop. I don't know if it is the wiper cowling area or what? IMO Ford's design of that area is crap.
View 11 Replies
Advertisement
I have a 2013 Hyundai Elantra Limited and have noticed a rattle in the front driver's door area near the Dash. It's hard to pinpoint where exactly it is coming from. The rattle can be heard even on smoothish roads and sounds like a little screw or something else is loose or rubbing against something. I checked that sunglasses holder and made sure nothing was in there but the rattle is still there.
View 55 Replies
About 3 months ago I started having a grinding sound from the front driver side hub area. I replaced it and it fixed the problem. I read where you should do both because he other one is soon behind it but I waited. Now I started hearing it from the passenger side too. So I replaced it today and all was good until I tested it from 4 wheel back to 2 wheel. Once I went back to 2 wheel the clicking that sounds like bearings going out to me, was back. What is it?
View 1 Replies
MY '07 SuperCab just started making a strange rhythmic sound as I drive. It is coming from the drivers side front wheel area. It is like a short creaking sound. It stays the same if I am turning the tires. Seems to go away if I put the brakes on hard, but I slow down so much I am not sure. Front CV Joint?
View 1 Replies
I'm starting to be a little annoyed with a rattle in the passenger side dash area. I looked around to check if there was anything obvious, but I couldn't find anything...
I sometimes get that noise while driving over bumps, but oddly, I usually tend to get it when I accelerate and get the engine at a specific RPM (like some sort of resonance frequency issue?!?). What could cause this?
View 10 Replies
Where another 09 owner had what he thought was a cold weather related squeak coming from the passenger side dash / windshield area. Mine does this and it's highly annoying. Here's what I've observed:
- seems to happen in cold temps, though I can't say what "cold" is...<40F perhaps?
- noticeable over bumps or whenever the car frame twists as a result of uneven road surface
- source seems to be the dash / windshield interface on the passenger side
- it's *possible* it may be coming from the top of the windshield as well
- it's very noticeable and highly irritating
Either with an 09 or earlier model? I cut a pool noodle and shoved it down between the glass and dash hoping the pressure would relieve whatever is rubbing. It appeared to work until the temps dropped into the 20s. Then it returned. I have a 2009 GLS, 5MT Sonata.
View 42 Replies
I have a similar door rattle near the door lock area on the driver's side. It sounds like metal touching metal. I took the door panel off and found nothing loose or unusual. The rattle is driving me crazy.
View 4 Replies
I have a rattle coming from the drivers front area. I'm not 100% sure but I think it might go away in warm weather. I had a tech drive along with me once a few weeks ago, but we couldn't hear it that afternoon. Yesterday afternoon it warmed up to around 65ish and I couldn't hear it. I only hear it at slow speeds (5-10mph) and only when rolling over light bumps, anything moderate to heavy and it's not discernible.
This is my first try at recording it and I think it sounds a bit less squeaky more rattley in person. Maybe more like a lost screwdriver in the a body panel or engine bay or something Or a loose strut? Or a loose rotor? (doesn't seem possible) Or the short shifter bouncing? (I have a forge SS, and once I was poking around looking for something loose in the engine bay and I jiggled that and the sound seemed close, but I don't see how that would be it.
Some good examples in the clip are at 15s, 28s, 52s, and 1:02s
[URL] ....
View 20 Replies
I have a 2001 F-150 Supercab with the V-6. This past weekend it developed some strange noise best described as a rattle or vibration that sounds like it is coming from under the driver's side dash possibly somewhere right behind the instrument cluster. May even sounds a little like a "grinding" noise - like two plastic gears not agreeing with each other, but I don't know of anything under there that could make that noise. I have opened the hood and listened from there with my wife pressing the gas to make the noise start, but can't hear anything from outside the truck.
It is not constant, but starts as soon as I give it a little gas, even before I put it in drive. It's a little worse when it is in drive. I have turned the air on and off, turned the steering wheel, pressed the brake, etc, and it doesn't appear to be related to anything obvious. I have stuck my hand under the dash and can't find anything obviously loose.
View 9 Replies
In the last few months my car has been making this crazy medium-weight rattle sometimes, meaning it doesn't sound like something really light doing it and it doesn't sound like something heavy doing it either. Its "history" went like this:
Noticed this sound that really seemed to be coming from the driver-side front, in the wheel well area, checked it out. Nothing obvious. Had the front of the car on ramps a couple of times, poking, prodding, grabbing/shaking things. All is tight. Then had it on stands; same routine, same results. It got a bit worse over time, though it doesn't ALWAYS do it! Sometimes it's quiet forever (on 90-minute drive last week, nothing). This evening, out for 20 minutes, lotsa racket. So it comes and goes. Nothing under the hood seems amiss, either.
At first it seemed to only be present when moving, like something rubbing or dragging on a tire. Nope. Then it seemed to be related to engine speed, like some under-hood component checking out and starting to fuss. That seems not to be the case anymore, either. Now, I've been able to discern that it's something come loose and VIBRATING (I'm pretty sure -- it just sounds like that), but I don't know what yet. I now hear it at idle, sitting at a light (sometimes) and it's definitely worse on rougher pavement than on smoother pavement.
A while back I realized that it must not be coming from outside and under the car after all, because putting the window/s down results in not being able to hear it at all, rather than being able to hear it better. This is true even at 5 mph, rolling along on a quiet street entirely for diagnostic purposes.
Earlier this evening (during the 20-minute out n' about), I note that it's not coming from the driver side anymore; it's more like the whole front of the car. Really seems to be under the dash. When I first figured out that it's NOT outside/underneath, I took off the panel under that side (three Torx screws) and poked around. Didn't find anything obviously loose, etc. I've ruled out the glovebox, its door, and the center console, by holding on to each while rolling. The sound is not quite in the correct spot to be from any of these, either.
View 5 Replies
After driving our 2013 Passat for 215 miles, we noticed that there was a rattling noise coming from the left front wheel area but only at slow speeds (under 10 mph). The noise disappeared at higher speeds. Today, we took the car to the dealership but they could not find anything wrong.
View 4 Replies
My 2008 F150 rattles (from engine area) when I let off gas while in traffic or in a drive-through. It almost feels as though it's going to stall. Drive thru, parking lot, traffic are all examples. "Stop and go" push the gas to move forward and quickly let off gas. I let off the gas there is a large rattle coming from my engine. Not sure if it's miss-firing or if it's an exhaust leak or a timing chain issue. I'm having trouble trying to figure this out because it does not happen all the time and have been unable to re-create when I go to the mechanic.
View 4 Replies
I recently purchased a certified pre owned 11 350 AWD and am noticing a dash rattle on the drivers side. It seems to be on the dash above the tachometer. If I apply pressure(w my hand) it seems to go away.
I know rattles come in all shapes and sizes but where would you start?
Here's a night pic: Only had it a few weeks.
This is what I have done so far.
20/10 Tint
6K Low Beam Headlights
LED Parking Lights
Quick question: By replacing the HID low beam bulb do I lose the headlight turning adjustment feature. It doesn't appear to work now.
Thinking about Plastidipping the AWD GS350 emblem
View 3 Replies
I finally pulled the trigger on a dark grey Corolla S yesterday, and it turns out that it rattles on the driver side top dash. When I push on it, it stops, but it's pretty annoying and noticeable. I guess I should take it back.
View 14 Replies
So I have finally solved the rattle that has been seemingly coming from my driver side dash speaker. I'm not exactly sure which of the 3 things I did fixed it, but it's fixed.
First, I removed the 2 10mm bolts securing the speaker and removed the wiring harness. I noticed that there are 2 metal clips that those bolts screw into and they are loose, so I took some electrical tape and just taped over them to keep them from rattling.
Next, I found the wire for the speaker has a plastic shroud around it that is very stiff and could make noise, so I wrapped that with electrical tape as well.
Finally, the thing that was most likely the cause of the rattle was a loose wiring harness attached to the firewall. If you reach into the speaker hole you will feel the harness just under the hole. Where the harness is attached to the firewall it was extremely loose. I simply took a paper towel and was able to wedge it behind the harness and the firewall which kept it from moving.
Now the driver side rattle is gone, but I've noticed another rattle somewhere else near the center/passenger side of the dash. Every time I fix one rattle I seem to find another. Maybe I'm being a little OCD about it.
View 6 Replies
2010 Matrix XR, car drives great except while driving off of parking lot going slow over bumps I hear a bit of rattling noise coming what seems like the driver side dash area... it almost feels like its coming perhaps from the steering wheel but the steering wheel feels very tight with no play at all.. Other than that it's all good can not hear anything wrong driving on a smooth road or a highway...
View 9 Replies
So I had a persistent dash rattle that would mysteriously go away when my car was brought in for service. I took it in a 2nd time, again nothing. So I took the service adviser for a drive until it showed up... then it wouldn't stop.
Shop foreman drove it right after we got back and this time he heard it too... took 4 hours to re/re the dash trim and radio but they found some HVAC ducting was loose from the factory ( b4 work??) and rattling around. They put it back together and apparently put tape around the joints (like you would in your home - I guess from the factory the pipes just snap together). Car is much quieter now. Just hoping this issue doesn't come back in 4-5 years when the tape falls off? It also stopped an intermittent rattle coming from the right side of the dash.
There was also a wind buffeting noise around the drivers side doors. There is a TSB to address this now for 4-door cars. A minor adjustment to a seal and I was good to go, again much quieter. I'll have to see how it fairs at 130kph on the highway, but the buffeting I could already hear at 90kph is completely gone.
View 2 Replies
2004 F150 FX4, 5.4L, 116k
I have replaced the IWE solenoid ,alternator, spark plugs, air filter, idled pulley and check valve nearest to the IWE solenoid. The sound happens while in neutral and while in Drive at ~2250 RPM and above at an increasingly louder increments. The sound also happens when in neutral rolling down hill when engine speeds are above 2250 RPMs. The sound still happens while in 4x4 and does not stop if 4x4 is engaged while the noise is happening. The noise can be found while revving in park. It seems to be coming from inside the cab almost or center firewall area. However I can't find it with a stethoscope, I would compare it to electrical static.
[URL] .....
View 6 Replies
I have a constant fog on my windshield, A rattle in the steering wheel area and a middle headrest that's too big. What can I do?
View 4 Replies
So the wife's 08 Mountaineer 4.6 likes coolant. None in the crank case. I suspect head gasket, since I can smell it a bit in the exhaust, but I have also noticed steam coming from the drivers side firewall area, but can't see anything. If it is head gaskets, am I pulling the engine? If I have to pull the engine.
View 5 Replies
I have an 08 Sonata GLS and today an annoying rattle was coming from what seems to be deep in the dash on the passenger side. I checked the glove box, closed all the doors tight etc. etc. but it is still there. It seems like a vibration as it is pretty constant but it does change going over bumps etc. Is it a known issue?
View 6 Replies
