Ford F-150 (2004-2008) :: Low Fuel Light Came On While Turning And Fuel Gauge Is Well Below Empty With Half Tank
Sep 4, 2007
I have a 2004 F150 XLT 5.4 L 79,000 miles. Yesterday i was driving home turned a corner and the low fuel light came on and the fuel gauge is well below empty. I had approx 1/2 tank of fuel when it happened. I have since filled tank all the way but the gauge will not move and low fuel light stays on. Everything else is working fine! I have never run the truck low enough on fuel to make the dummy light come on.....
View 5 Replies
Advertisement
My fuel gauge acted pretty weird today. When I left my house today it was just above half a tank. I was sitting in traffic quite a bit and then looked down and it was below the e. I knew it wasn't empty so I kept going. Got to work. Went for lunch and it said full drove about 5 mins to eat and it went down to half a tank. What's going on? I am thinking of the fuel sender or wiring?
View 3 Replies
My 01 sl2 wont start and the gauge says that the car is empty (before this problem, everything was working fine). I know that I have more than a half tank of gas, the car continuously turns over but wont start. I replaced the fuel pump and still it wont start (not to mention that the tank was more than half full at the time). I checked all the fuses and relays and everything seems fine. I am not even getting gas pumped to the filter.
View 9 Replies
So yesterday I was driving home from work.. I know my tank was 3/4 full. All of a sudden, my low fuel light came on and my gas gauge needle went to empty.
The needle sits at E, but it still says about 20 miles till empty on the MFD. When I left the house this morning, it said 5miles till empty.. by the time I got to work, it said 20. Kinda odd..
I will hook up the vagcom when I get home tonight, any area I should scan for? or just a complete scan? There is no CEL error on the dash though. What I could look at to fix this?
View 4 Replies
Ok so the fuel gauge says empty and the low fuel light stays on even though the tank is full. I'm assuming its either the gauges or the sending unit. If it is the sending unit where is it located on this car?
View 4 Replies
I just bought a used 2004 F-350, 4x4, crew cab, short bed, 6.0L diesel. I'm having a WTF moment on fuel. Gage indicates just under 1/4 of a tank of diesel but the on-board computer is flashing like crazy stating 5 miles to empty, what the hell is that all about?
View 1 Replies
fuel gauge does what it wants? It goes down to half way then goes back to full or sometimes even empty. Not a big deal for me because I have gotten used to it. But I would hate to have my wife in here and she thinks it's good and run out.
View 14 Replies
The installation of the new 50 gal. Titan tank went well overall. Start up was smooth with no leaks but the fuel gauge is showing empty with about 45 gallons in the tank.
The sending unit was properly oriented ("clocked") so I'm guessing the electrical connector is not secure at the top of the sending unit. Not sure I can reach the connector without lowering the tank somewhat.
View 6 Replies
I have a 2004 Hyundai accent hatchback with 225000km. The first time I drove it for over an hour, 1 trip no stops, the fuel gauge dropped to empty while there was 3/4 of a tank. The 2nd time I drove over an 1 the fuel gauge dropped again and the gas light came on (again around 3/4 of a tank). My mechanic said until it does it consistently he can't diagnose so I let it go.
More recently, driving it to and from work 5 days, plus some extra city driving, I used 1/4 tank the full week. Today I picked up 4 winter tires and bringing them home (approximately the same distance as my work) I used 1/4 tank right there. I understand it is weighed down, but could it really be that much? What is causing the fuel jumps and gauge jumps? I've already had the float replaced.
View 2 Replies
Full tank and the gauge reads empty. Has happened to me a few times. Occurs after a fillup and disappears after the car is left to sit for a while off. I would hate for this to happen on a long drive. Dealer hasn't been able to duplicate the issue. Am wondering if this might be related to the hiccup in some way. Also, am wondering if this is a fuse issue.
View 8 Replies
So my truck felt gutless somtimes, wouldn't start Every couple days , and Fuel gauge stops at half tank won't show full, so I went n bought a new fuel pump..... Well shoot nothing changed . I guess my next move is pull the dash off n fix gauge? It used to be a reliable truck . Now Im not comfortable to let wife drive it . I also pulled the chip to see if that had to do with not starting, also theft light blinks normal. I'm going to get some connector grease n redo all of my wires to c if there's just connection issues.
View 6 Replies
I'm new to the Gen 1.
All has been well in just over a month of driving the car and about 3300 miles logged. The 12v, Aux battery was dead from the car sitting on the lot for so long (I replaced with a new OEM Toyota 12v battery) After a week of the car experiencing dim headlights, and various other electronics
No codes or CEL though.
Now that the 12v battery has been replaced, the car runs exceptionally well, aside from an intermittent fuel gauge issue where it only reads full bars (completely full) if I let the tank get to empty (Flashing single bar) or close to that. If I fill the tank from s
View 4 Replies
I have a 2009 Sonata SE 3.3 with about 35,000miles. I am the second owner.
I believe that my gas gauge or the sending unit in the tank is bad. The gauge will show empty when the tank has fuel and then it will sometimes read normal.
View 10 Replies
As I was driving to work yesterday I noticed my fuel gauge going from half tank all the way to full going down the highway. I started looking at the rest and they seem to be in there normal spots. I looked up and watched the outside temp go from 40 degrees to 5. This morning the fuel gauge goes straight to full and the outside temp bounces between 2 degrees and 10. What may be going on to cause this?
The truck is a 2000 F350 crew cab with a 7.3 Power Stroke
View 3 Replies
I recently replaced my gas tank in my Sundance, it was getting very rusty around the sending unit area and was starting to leak. Everything is back together and it is running well with no leaks. The new problem that it has, when the car is running, the gas gauge shows less than empty, even though it has a considerable amount of gas in it. When I shut the car off, the gas gauge slowly moves up to where it normally would be when it would be running. Did I somehow mess up the ground or did I cross something? This is my daily beater car and need a working gauge.
View 1 Replies
I bought a 2006 F250 6.0L a couple of months ago, from a dealership. It's been bulletproofed already, has an intake, coolant filter kit. Has 95k (mileage). Today, my fuel gauge dropped to empty from 3/4 of a tank for a couple of miles and set off the CE light. I hooked my scan tool to it, to clear the code (P0460).
After just checking other things out with the scan tool. I cleared it and went on... I had to run to the store, later on... I was pulling out of the neighborhood and the gas pedal was a lot more "touchy" and the truck, responded to it and it launched pretty good and blew a good amount of black smoke.
Do any of you think this has/or had a tuner on it and I may have activated it with my scanner?
View 6 Replies
I just bought my 2012 Elantra Limited from the dealer today . The fuel gauge showed about two bars, a quarter tank I estimated. However when I went to fuel it, the pump clicked off after about 1 gallon, indicating the tank was full.
That was odd so I just figured there was some air in the tank or in the hose, so I tried adding some more fuel. I got about a half gallon more added when it clicked off again. Well, I know you're not supposed to top off the tank so I tried to add more. Got about two gallons added when it clicked off. I stopped fueling at that point for fear of causing damage.
My fuel gauge now shows a little less than half full. How can that be? Is there something I can do to fix this?
View 3 Replies
I just filled up my gas tank and when I turned on my car the gas light turned on and the needle read empty. But before I put gas, the gas light wasn't on yet and. Was at 1/4 of a tank. Maybe I filled it up too much and it'll resolve itself after the gas goes down?
It's a 10.5 if it matters.
View 4 Replies
I've been having a very erratic fuel gauge issue as of about 2 months ago. My fuel level would register full, when in fact I knew it only had 1/2 a tank or so. Then 5 minutes later it would be pegged on full. Under a 1/2 tank the gauge would read any where from 1/2 to empty from 1 minute to the next. So last week I decided to drop my tank and take a look. I was thinking maybe my fuel sender was broken, maybe a loose wire in the tank, or even that my float had dropped off in to the tank.
After dropping the tank, I removed the PK-Up and sending unit and everything was intact. I placed my ohm meter on the sending unit and it checked out fine. So I took the Pk-up and rolled back up underneath the truck and plugged it back in. I had my son turn the key on and off while I moved the float to different levels in order that it would register. It registered empty, 1/4/, 1/2, 3/4 and full just fine as I moved the float to those levels. If you leave the key in the run position and move the float, it won't register or better said, the in cab gauge will not adjust with the movement.
You have to turn the key off move the float and hold it there, then have your assistant turn the key on and the gauge will show the position that you've moved and held it at. I simply removed the plastic cover from the sending unit, and sprayed it down real good with electrical contact cleaner. I didn't scrub the copper contact area at all.
I was concerned that scrubbing might remove more than I wanted to, and really mess things up. I attached an Ohm meter and checked resistance thru out the float travel. All checked out good and I reinstalled it. So now my fuel gauge is working as it should be. I did make a video while I ohmed the Sender Unit thru it's travel, but for some reason it won't load.
[URL] ....
View 5 Replies
I recently bought a 2005 Ford F250 Super Duty, diesel 6.0.
As I was driving to work this morning I noticed that the fuel gauge read almost full when it should have only had a half tank. A little while later I heard a beep and saw that the gauge was now on empty with a "Low Fuel" message displayed. Then I noticed the heater was suddenly blowing cold air.
I've only had the truck for a few weeks, but haven't had any other problems. I did replace the CD receiver and all of the instrument cluster lights a couple weeks ago, but everything seemed to be working fine after.
View 1 Replies
Its been happening often where it shows empty (when i really have half a tank) and my avg mpg resets itself. As I am driving it will go back to normal.
View 11 Replies
