So my 04 FX4 with only 55000 miles is finally starting to rattle. I change the oil more often than necessary, use Motorcraft 5-20 syn blend and a Motorcraft oil filter. The big question is...
What happens if you let it tick away and don't fix it? Beside the noise, what can happen? Will they actually break? Freeze up in the wrong spot and shove a valve into a piston?
I have a 2.4 Petrol, 16 valve engine in my Santa Fe which produces a rattle on startup when cold. When warm it starts normally. Oil and filter change makes no difference. Timing belt changed 40K ago. No other effects felt with regard to power or noise once initial noise/rattle has stopped after 2 to 4 seconds.
View 4 RepliesI have a rattle in my 2004 Lariat crew cab with sunroof. The sound seemed to come from the rear seat, but I finally tracked it down to to roof of the cab. The back dome light (and interior roof) has sagged some and I guess it's the dome light or wires are rattling when driving.
View 1 Replies04 F150 4.6 ltr Has a tinny rattle during acceleration . Sounds like 2 hammerheads in a washing machine....
View 2 RepliesI have a bit of a question about my 2007 Ford F-150 w/ the 5.4 3V. I don't know how long it's been doing this, I just happened to notice it not long ago. Whenever I rev the truck (doesn't matter if it's in Park or Drive) in between 800-1,000 RPMs it makes a "rattle" type sound - like a "rat-tat-tat-tat" I guess is one way of putting it. It only does it when the engine is hot, it won't do it when it cools down some. The truck has 63,000 miles and I've always ran the recommended 5W-20 weight oil. Engine runs good, no power-loss or anything like that. I have posted a video on YouTube of the sound. If you want to skip my talking in the video to get to the sound, then skip to 1 minute and 40 seconds of the video.
2007 Ford F-150 Lariat 5.4L Triton V8 Rattling/Ticking VCT Phaser Noise?
I get this weird rattle noise comes and goes once in a while notice it on highway mostly? I don't think it's a loose heat shield?
View 14 RepliesMy ashtray has been open for as long as I can remember because when I close it, it rattles. I have a Lariat with the center console. What should be done to fix ashtray rattle, pics would be useful.
View 4 RepliesOk noticed this a few times recently. On the first start up of the day, sometimes it sounds like something "rattles" in the engine before it comes tight? This only happens when I first start the truck from sitting overnight, if I run to the store, or at lunch go out, etc, it starts normally. I did have one of the pulleys replaced this past summer, it was making a whining noise so maybe the new belt they installed is loose? I know it could be any number of things.
04 5.4 with about 87k miles...
I have a 2004 F-150 5.4L V8 3v vin code 5. I'm a heavy equipment mechanic and know my way around engines. The longer I own this truck the worse the problem gets. I believe I've narrowed it down to the oil actuated timing chain tensioners. I get a really bad rattle with a shaking condition only after changing my oil. Other then that it runs perfectly. I'm guessing it's losing its prime and trying to build up oil pressure. Is there any way to hand prime those tensioners? Or should I just go ahead and replace the whole assembly?
View 5 RepliesI have a 08 F-150 4x4 King ranch with 5.4L Duel fuel motor. Last year we were backing a trailer and the whole truck started shaking. Stopped, but it in forward and no problems, tried backing again and same thing. It did back up but shook worse with more gas.
We took it to a mechanic who said without even looking at it "Sounds like a reverse clutch, common problem" So we had them rebuild the trans, a few months later it did it again once but we were 300 miles from home. Since we could still back we did what we needed to do and drove home with no problems. Dropped it back at the mechanic who said he couldn't find anything and eventually had a yelling fight with my wife. We couldn't get it to happen again either until last week it did it again and she grabbed the camera to record it.
Took the truck back with the video, he had a mechanic look at it and said the transfer case mount bolts were loose, tightened them up which did get rid of a knock that we had since the trans rebuild and said that was the problem, it was binding and causing the shaking. This weekend did the same thing again.
Now the truck is back at the shop and only 100 miles or so left on the warranty (12m/12k). So after that long story my question is if the problem really was/is the reverse clutch or if there is something else wrong that he never fixed and was just intermittent enough that we let him get away with it this long?
I have a 2004 F150 with 195,000mi. For the last several moths the truck has had a rattle on startup, some days it is barely noticable and only on cold starts, other days it is loud and occurs on every startup. The truck was most recently serviced at the Ford dealer and is filled with Motorcraft 5w-20 syn blend and Motorcraft filter Every change before was either Motorcraft syn blend or Penzoil Platinum (I have always used Motorcraft filters on it) and the noise continued after oil changes so I don't think the drain back valve is the issue. I replaced the cam phasers, timing chains, chain tensioners, and guides about 15,000 miles (2 years) ago and the vct solenoids shortly after that. Here is an audio clip of the noise (I know the truck also has an exhaust manifold leak, I plan on replacing the manifold while im working on it
Is this noise the lash adjusters or have the cam phasers failed again (they were dorman parts)? If it is the lash adjusters, can they be replaced without removing the cams? will failed adjusters be obviously damaged? Should I also replace the cam followers? do i need to replace all 24 at once or can i safely replace only damaged ones or maybe just 1 bank (noise seems to only be coming from the pass side)?
2004 super crew. It is not the seat belt. Can I unsnap the seat to get back there?
View 4 RepliesMy driver door is just loose enough to rattle on bumps and it's quite annoying. I've loosened the striker and tapped it in as far as it'll go with the hammer and it is still not tight enough. I need about 1/4 inch more and that's about how worn my striker is. Obviously I need to buy new a new striker based on the wear, but am I the only one with strikers wearing too much to be adjusted and causing rattles ?
View 7 Replies06' F150 4x4 XLT SCrew 29K-mi
I have a rattle of some sort I can hear coming from underneath towards the rear while under acceleration. Usually hear mostly at certain RPM and not through entire accel to hwy speed. Do not hear it while in Park and reving engine, but on the road I hear it. Mostly I think after it gets hot or something.
No driveability issue only rattle? While I was reving in Park I could hear a bubbling after I let off the pedal. Is that normal. I don't think it is the same noise/rattle.
I bought a 2004 F150 XLT 4x4 122,000KM. I used to have a 1995 BMW 318TI but I built a cabin and a truck seems to go with it. I have already done some work like new plugs, oil change, tranny flush, fuel filter change and Air Filter. I noticed about 2 weeks ago going up to the cabin a rattle sound when I was going up a hill. It is coming from the right side (FRONT) and it sounds like its from the wheel. I really does it if I give it some gas and then press a bit more on the peddle and then you here like marbles in a tin can if that makes sense. I just got back from my mechanic and we took it out and it is still doing it so we jacked it up and checked everything. Their are no loose clips and back plates making noise. We did notice that a heat shield near the cat was rubbing and we adjusted it, this did not solve out problem. We were both looking at each other after an hour wondering what the hell this could be. I am going back on Wed and he is going to hook it up with some kind of machine with microphones and a headset to pinpoint the problem. It does not affect the performance of the truck but it is very annoying when I need to give it some gas to pass or go up a big hill.
View 4 RepliesMy 2008 F150 rattles (from engine area) when I let off gas while in traffic or in a drive-through. It almost feels as though it's going to stall. Drive thru, parking lot, traffic are all examples. "Stop and go" push the gas to move forward and quickly let off gas. I let off the gas there is a large rattle coming from my engine. Not sure if it's miss-firing or if it's an exhaust leak or a timing chain issue. I'm having trouble trying to figure this out because it does not happen all the time and have been unable to re-create when I go to the mechanic.
View 4 RepliesQuick truck stats: 2005 F150, 5.4L, 85,000 miles
The past few weeks my engine has been hesitating on some cranks before it would start. I figured it was due to the cold weather so didn't pay too much attention to it as it was also not throwing the check engine light.
Yesterday it didn't start at all after the several attempts of just cranking over and over. It still didn't seem to trip the check engine light but I pulled my scanner out anyways and it had the code p1237. I cleared it and the truck started right up. It even had no more issues the three times I started the truck after that.
Today, however, she is not starting again and not throwing any codes. Still cranking so I'm sure it's not the started or the battery. I'm going to have my husband pick up some starter fluid on his way home today to see if I can at least get a temporary start since I think it's the fuel pump, or possibly the fuel filter. It is cold again this morning so I'm wondering if the cold is somehow making this issue worse. Either way I'd like to fix it, since being stranded with a truck that doesn't start is not my idea of a way to pass the time.
What else it might be and how I might be able to diagnose it?
Intermittent starting issue in these things? Seems to be getting more common for me this winter. Turn the key, it turns over, and then I let go of the key and she doesn't light. Then when I try again, it's like the engine is flooded. I have to give it gas to start, which I know is a no-no in fuel injected vehicles. Other than that, it's fine. No sputters, no hiccups, runs strong, good mpg, etc. But I'm getting annoyed....
View 14 RepliesI am trying to find out why my F150 Supercrew with a 5.4 and is 4x4 as I start from a stop and I give it gas it shifts from 1st it shifts fine. but when it goes into 2nd gear it starts laboring really bad as if it has no power. If you give it little gas it seems like it has no power. So I decided to push the overdrive button off and it still does the same thing. I have never pulled a trailer in overdrive and it decides to shift automatically into overdrive when I am driving below 45 mph.
View 1 Replies2007 Extended cab F-150... Passenger doors rattle and don't seem to close tight? I tried to move latches , but didn't seem to work?
View 4 RepliesI have a 2004 FX4 and have a very annoying rattle up in the driver's side dash area near the windshield. This happens every time it gets to be winter. The odd thing is, that it will sometimes go away but when I hit an uneven surface such as a railroad crossing, I hear a loud "pop" near that area. Then it will rattle non stop. I don't know if it is the wiper cowling area or what? IMO Ford's design of that area is crap.
View 11 Replies