Ford F-150 (2004-2008) :: 5.4 4x4 - Replacing Starter On Truck?
Nov 23, 2011
I may have to replace the starter on my truck. Have heard it is difficult especially on the top bolt. Any stickys/bulletins on how to do this.
View 1 Replies
Nov 23, 2011
Advertisement
Ford F-150 (2004-2008) :: Truck Start By Jumping The Wires On Starter
I just got this truck about a month ago now and today it started fine and when I got home from work, I ate dinner and then went out and it started fine and once i got home i let it sit for an hour and then went to do more errand and it wouldn't start. I checked fuses and what not it all looks ok. I got the truck to start by jumping the wires on the starter. What might be causing the truck to do this? as i say today is the first time this has happened?
View 8 RepliesFord F-150 (2004-2008) :: Starter Click But No Crank - Truck Would Not Start
I have an 04 f150 and just changed the alternator yesterday, and 4 hours later it wouldn't start starter clicks but no crank.
View 3 RepliesFord F-150 (2004-2008) :: 2006 - Replacing Motor Mount?
I need to replace the motor mounts on my truck. Is there any special tools or tricks I will need before I get half way into it and find myself in a bind? Oh yeah it's a 5.4L
View 1 RepliesFord F-150 (2004-2008) :: 2006 XLT - Replacing Wheel Hub Assembly?
I've got an 06 XLT 4x4 with the 4.6L. I'm replacing the wheel Hub bearing assembly this evening and got the old one removed. Opened the new on to find no grease! I was shocked considering I just replaced the IWE and they come pre-greased. I plan on adding some grease around the hub gear but wondered if i should some how get grease in on that inner needle bearing? I have to have this put back together in a couple of hours so I can drive to work tomorrow.
View 6 RepliesFord F-150 (2004-2008) :: No Power To The Starter Solenoid
Yesterday after work, i got in my truck and it started right up, no problem. my stereo has been giving me some fits the past few days, looks like everything is on but no sound, and was thinking it might be a fuse so i proceeded to shut off my truck and take a quick look at the fuse box. didn't find anything quickly fuse wise, so i got back in the truck to go home and turned the key and nothing. no whine from the starter, no click click click like a dead battery, but i do here a single click from the relay switch as i left the case off to do a more thorough investigation on the stereo when i got home. anyway.. here is all i have ran through.
1. Made sure the battery is good, even tried jumping it for good measure..took cables off and made sure they had clean connections.
2. Switched out the relay, and fuses related to the starter in fuse box.
3. Put the truck in Neutral, thinking safety switch.. wiggled it around while trying to start it as well
4. Crawled under the truck, took a screw driver and bypassed the switch all together to make sure it wasn't the starter, starter kicked in like it was new, but no truck start. (key was in the on position)
5. Checked the solenoid post with a test light to see if it had power on key turn, nothing.
6. Checked the fuse box and surrounding wires to make sure i didn't bump anything when taking off the cover..
From all of this it sounds like some safety switch that isn't giving power, otherwise i would have thought the truck would have started when i bypassed the switch on the solenoid. Just seems very odd the timing of it and i have not had any previous issues like this.. just out of the blue, literally less than 5 minutes from starting the truck without issue.
Ford F-150 (2004-2008) :: 2007 - Replacing Turn Signal Flasher?
I'd like to put in a louder turn signal flasher on my 2007 F150 - where is it located and where I can get a louder one ?
View 1 RepliesFord F-150 (2004-2008) :: Remote Starter Does Not Turn The Engine Over?
My parents have an 07 f150 with remote start and for some reason it will not work, it locks the doors and turns the key on but it doesnt turn the engine over, we brought it to a local dealership and they just unplugged it and plugged it back in and it started working... but later down the road, like 150 kilometers my mom got out to go shopping and it wouldn't work again, does this mean the whole module has to be replaced or is there a quick fix to this, it looks like the stock ford remote start but it has a separate keychain for the button, if it has to be fixed, any instructions on how to do it?
View 3 RepliesFord F-150 (2004-2008) :: Ignition Sticks And Kills Starter
Looking at buying this used 2004 F150 and the Seller says it has a problem with the ignition switch; that it continues to run the starter even after the engine is running, which burns out the starter. He's an obvious layperson and doesn't know much about mechanical stuff (or he's pretending, IDK).
This sounds very strange to me, because if it's some kind of mechanical defect/factory defect, it's something that Ford should have identified, documented, issued a recall maybe, or something, yet when I research the issue the only thing I find is a problem with ignition switches that cause fires in model years that end in 2003 (not 2004). Other than that I find no documentation.
I wonder how accurate the Seller's description is, or maybe it's defective due to some other reason, like maybe a car thief shoved something into the ignition and damaged it, or possibly corrosion. Or maybe it's simply "sticky" and some spray lubricant would fix it.
Ford F-150 (2004-2008) :: 2007 - Remote Starter Not Working?
2007 Ford F150, Remote starter no longer works. after pressing remote (4) times. 3 with horn blast , it is to start. the lights flash, interior dash lights go on as if trying to start. It does this every 10 seconds or so till I hit brake. If I use the remote with the key inserted it starts right up. I had just replaced the battery previously.
View 3 RepliesFord F-150 (2004-2008) :: F250 V8 - Starter Would Not Engage When Turned The Key
2008 Ford F-250 with a 5.4 Liter V-8 3-valve engine and automatic transmission.
Running down the road at 44-MPH. Pulling 5,000lbs. Engine died just after turning on the air conditioner. (Not sure this is relevant.)
Would not start. Turned the key - the starter would engage, but the engine would only turn maybe a quarter turn. Try it again engine turns. Try it again and now it only clicks. So, I
-Replaced the battery. Same symptom. Will only turn the engine 1/4 turn.
-Replaced the starter. Same symptom.
-Checked oil. Clean. No Water. No gas smell. (200 miles since last oil change)
-Checked coolant. Clean. No Oil.
-Charged the new battery and tried again. Same symptom.
-Checked and cleaned all grounds and battery cables. Same symptom.
-Checked that the transmission is shifting though the gears. Seems fine.
-Removed serpentine belt. Check all pulleys, and accessories that are driven by the belt. Everything spins quietly and freely.
-I put the truck in neutral and tried to spin the crank pulley with a 2 breaker bar. It wouldn't budge.
Am I missing something? I fear the engine is seized or hydro-locked. If hydro-locked, wouldn't I see signs in the fluids? Can the pistons be hydrolocked with fuel? Not sure what to try next.
Ford F-150 (2004-2008) :: Fx4 Won't Turn Over - Starter Relay Only Clicks?
I have a 2004 f150 fx4. Drove it home and parked it. Next morning wouldn't turn over. When trying to start the starter relay clicks but no noise from starter. Battery light and wrench light are on. I thought maybe battery was low but when I hooked up charger gauge showed good battery. What do I do next? Also there is no "theft" light...at all not even when I first turn key on.
View 1 RepliesFord F-150 (2004-2008) :: 2006 - Rough Idle After Replacing Ignition Coil
completely stock 2006 4.6, 230,000 miles, I purchased and can vouch for everything after 106,000.
Two separate issues...have had a slight ticking noise growing for about the last two years. Seems to get slightly worse near an oil change but that could be my imagination. It has finally gotten loud enough that my wife (who drives with the delicacy and observational skills of a Sherman tank driver) actually mentioned it to me the other day. It is directly related to engine speed whether the truck is in gear or not. I kind of think it might be a manifold gasket going out but am not sure. Am not very worried about it but...felt like I needed to mention it because of my bigger problem....
Truck has gotten very "cranky" on startup in the last week. Has a rough time finding an idle speed but typically sorts itself out after about 5-10 seconds. This afternoon it started idling rough at a stoplight. It got steadily worse and noticeable even at speed. Four stoplights and nine miles later it threw a code and coincidentally, I was in front of an Advance Auto. They read it and said the #3 cylinder was not firing. I bought an ignition coil, drove 15 miles home and changed it. From everywhere I looked online, this is the second cylinder from the firewall on the passenger side.
Had a little trouble getting it in and am not entirely sure it is fully seated in the slot, but I can't get it to go any further. Seems as tight as a couple of the others. I disconnected the battery to clear the codes, cranked it up and it seems to run "better", but still has a rough idle. Just test drove it about 12 miles and no check engine light but the idle has not cleared up. I think coil must be working fine because I have no issues at highway speed. Earlier, when I backed off the gas you would feel the miss very badly, but not as much when under a load.
Ford F-150 (2004-2008) :: Engine Turns Over And The Starter Engages But It Won't Fire
My 2008 F150 5.4l SCrew wouldn't start this evening. The engine turns over and the starter engages, but it won't fire. Oddly enough the starter stays engaged after I take my hand off the ignition! I have to physically turn the key off for it to quit (didn't want to burn out the starter). The culprit may be the wet weather....it's been a lot milder today and we've had some freezing rain that turned to drizzle. My truck has only done this once before (last year I think). I eventually got it to start tho.
View 13 RepliesFord F-150 (2004-2008) :: 2006 V6 - Intermittent Starting - When Turn The Key Starter Will Grind Once Or Twice
I have a 2006 F150 STX auto trans with the 4.2L V6 that has been having intermittent starting problems. It has 98,000 miles on it. It will start fine 99% of the time but sometimes when I turn the key the starter will grind once or twice then it can go a few weeks with out doing it at all. Then also sometimes it will crank turning over for several seconds but wont start. Then it starts fine the rest of the time. This has happened several times but only happens once every few weeks or so. Just trying to see if it needs a new starter or if its something else. It has a new battery.
View 3 RepliesFord F-150 (2004-2008) :: Starter Not Engaging / Security Light Flash Slowly Even When Key Is Turned On
I just put a brand new engine in my 2004 f-150 4X4. Truck ran fine for two days. Yesterday I started the truck as usual put it in reverse. As I was backing up it just stopped running no warning nothing just stopped. All electrical still working fine gauges radio etc. When I turn the key I get nothing no starter nothing. The security light continues to flash slowly even when the key is turned on. Basically the best way I can describe it is. The truck is acting like it is in gear when I turn the key. And the odometer reads check gauges.
View 4 RepliesPhaeton :: How To Go About Replacing Starter Battery
I tried to jump my phaeton and it would click but not completely turn over and i absolutely cant get it to start. the radio, lights, windows, and things of that nature are still working. So i need to know how to replace the battery i.e. (disconnecting it and can i replace it with a battery from an auto store?) If not, how much should i expect to spend and what else could it possibly be??
View 6 RepliesVanagon - Volkswagen :: 1991 - Replacing The Starter?
1991 Vanagon GL-Ok, first off my gas gauge was inoperable so we traced it down to the sending unit. Disconnected the battery, drained the tank, dropped the tank and replaced the sending unit and all the fuel lines, seals, etc. In the meantime we also replaced the starter while it was up. Gassed her up, tried to start it. Nothing. Lifted it up again, checked the starter unit to see if it was getting a current, no current. Went to the fuse box, tested the fuses, all is good. Went to the battery and tested it, it was producing a current. Thought we might have moved, hit, loosen something when putting the gas tank back in so we lowered the tank to see if there was anything loose, disconnected, etc. Nothing. Reinstalled the tank. Went to the engine compartment and tested the alternator, no juice. Damn. Traced the wiring from the battery to the engine and test the battery cable, no juice in the harness by the gas tank. Went to the front of the van, took out the drivers headlight and tested the lines there. There is a long green object like a capacitor or something with three wired running to it, tested it no juice flowing through it. Tested a connection before the long green object and there is juice there. Is it the long green thing? Do I need to call in the Witches of Warwick to de-demonize it?
View 6 RepliesCamry :: 2002 Starts Once Then Just Click After Replacing The Starter
I've replaced the started the starter several times now and the car will start once then just click. I found that if I disconnect and reconnect the battery cable it'll start one time and then just click. So something seems to be getting reset when the battery is disconnected.
View 4 RepliesToyota - Camry :: 1993 Won't Start After Replacing Starter
Last week the coil went out. The housing had several cracks, and the heavy oil had filled the distributor cap. So the coil, rotor, and distributor cap were replaced. About 4 days later, all my engine would do was make a grating sound when I turned the key. My boyfriend said that it sounded like my starter had gone. It wouldn't start with hitting it or anything. So, he and I, while trying to save some money because we're both on disability, replaced the starter. Now, when I turn the key, nothing happens! We're pretty sure the battery is dead. We have it on a trickle charge right now. But a funny thing happened, all of a sudden the open door alarm started going off! The door had been open for several minutes when it started. So we think that it may be a short. The starter relay, when you look at it, has a spot of corrosion on the indicator. Tomorrow we're going to try cleaning them.
1993 Toyota Camry DX with 170,000 miles ....
Ford F-150 (2004-2008) :: Truck Won't Go Above 30 MPH?
My truck will not go above 30 mph - rpm's will rev high but, speed will not climb. I was able to put the truck in 2nd gear and drive home at @ 40 mph. Truck has 135K miles on it, I'm the original owner. What this might be?
View 14 Replies