Ford F-150 (2004-2008) :: 2005 Cranks But Will Not Start
Feb 2, 2017
My 2005 cranks but will not start. I spray starter fluid in throttle body and it will start but won't stay running. I've replaced the fuel pump and the fuel sender unit which is located under the spare tire. After I replaced the fuel sender unit It started and ran for about 30 seconds. It quit when the fuel line popped off the fuel pump and pushed gas all over the ground. I secured the gas line back on and now it won't start again unless I use starting fluid.
View 3 Replies
Advertisement
Brought a 2006 f350 6.0 from the action and knowing it was damaged from the frame, i went ahead and brought a another f350 6.0 2005 from someone around town, the last owner is calming the truck was stole, and most of the engine was stole, and the windows where damage. ( I just wanted to buy the truck for the body so i can transfer the engine to this one! ) but instead of switching the engine, me and my dad went ahead and only put the missing parts back onto the engine....
I can tell the last owner wasn't telling the truth, and me and my dad where thinking the last owner made up his own story about the truck being stole !! I did a vin check and noting came up about having a bad history!!!!!!!!! I'm thinking something went bad in the truck, and the last owner did his own fault story... Anyways!!!
we finally put everything back in place, and the truck cranks, but does NOT start!! and also has no spark. sometimes it sounds like it does wanna start!! we check the fuel, and wires, oil, fuel filer! everything good, but the truck has no spark, and where not sure if thats the problem. and also switch out the Crank sensor. Still no luck!!
And also there is smoke when we crank. battery are good too, and even left the truck 28 hours on the wire to head up the engine!!
View 3 Replies
Ok so... have an 04 that has more issues than Playboy magazine... any DIY tips or tricks...
I dont have an original key but the key I have has worked before. Motor cranks but wont turn over. Have tried the battery unhook thing, didnt work.
View 4 Replies
Truck has been running perfect and is my daily driver. Went grocery shopping with the wife and made two stops and drove it home. Parked in the driveway. No hint of any issues but when I went out a couple of hours later we went to head out to dinner and it cranks and doesnt start. Nothing out of the ordinary anywhere. No check engines lights, no theft lights flashing, nothing to indicate an issue. Engine sounds perfectly normal cranking, I can hear the fuel pump when I turn the key. I cleaned the battery terminals today because they had some corrosion and I checked all of the fuses that have anything to do with fuel or fire and nothing was blown.
I also went and bought a Fuel Pump Drive Module and installed it and still nothing so I took it back.This is a pretty pampered truck, not a torn up beater. What else I should check? Will probably town it to a shop tomorrow if I dont have anything else to try but I am at a loss at this point. I tried to listen with a stethoscope and I dont hear the injectors firing or the COP's. Oh I also shot it with starting fluid and nothing happened so I dont believe its fuel related. I think something is keeping it from firing the COP's or the injectors arent firing. But what could it be? Nothing happened to the truck last time I drove it. Oh I did check the fuel pump cutoff button as well. Nothing there either.
View 11 Replies
I just went out to move my truck to take out garbage and it cranks but doesn't start. It is 4.6L 4WD. I sprayed ether in intake no change. Checked all fuses all good. It has been raining pretty hard the last 3 days and it has been sitting in rain all 3 days. I checked for codes with a simple code scanner no codes. But the code scanner I used is not able to do KOEO or KOER tests. I know it needs new plugs but it has never sputtered or died on me. Has slight misfire but not engine stopping. I havnt had any check engine lights or problems before.
View 3 Replies
Bought a truck from a guy the other day. Long story, but he was a con artist. Told me the battery was dead from cranking it, he couldn't hear the fuel pump so he thinks it needs a new one. Got it home, checked fpdm, it was unplugged. Plugged it in fp running now. Charged battery. Cranks slowly won't start. Appears the engine has been changed. Have codes P0201-208, all injector codes. Cranking it over reminds me of an older distributor type engine that if off its timing. But also of cranking with a low battery. There's a new starter on it already. I'm going to pull the converter bolts on the weekend to see if they may have bound the torque when they installed the engine. Injector codes?
View 4 Replies
My 04 f150 has been sitting upwards in my drive way for a month now won't start cranks great with full power..
View 1 Replies
My truck's been having an occasional hard start, meaning the engine cranks strong but it fails to catch and then sputters. The 2nd start attempt usually fires up with no issues and then runs perfectly otherwise.
MPG's haven't changed, fuel filter was changed 15K ago. Air filter is clean. Plugs were changed about 10K ago. I always use Shell/Chevron gas. MAF sensor looked clean when I took it out so I didn't do anything to it.
This is starting to happen more frequently, maybe once every few weeks and I get a feeling it's the start of something. I've found myself waiting a few seconds for the fuel pressure gauge to come up before turning the key to start reliably. In the past, I could simply flick the key and it fires up the first time.
I see posts talking about the fuel pump module above the spare tire. What are symptoms of that going bad? Any pending codes that might be stored?
I'm about to get myself a scanner since I need one sooner or later. Which specific PID's to check while debugging this?
View 6 Replies
I have a 2005 F150 XLT 5.4 that doesn't always start. I've been having this problem for over a year now.
Sometimes it will start, but sometimes it won't. Seems about every other, or perhaps every 3 days it just will not start. Then, if I wait a few hours, it'll start.
I've replaced the fuel pump, fuel filter, mass air flow sensor, fuel pump driver module, starter and the battery. None of this has seemed to effect it.
Lately I've found out that if I put the truck in neutral, then while cranking I go to park (going through reverse) it will start. Sometimes not on the first try, but after a few attempts it will start.
It should also be noted that when it does start, often it'll make some loud noise RIGHT before it starts up. Sounds kind of like the starter grinding. If it doesn't make the grind noise, the other thing it may do is all the lights and everything turn off for an instant (half a second) then come back on and start.
I'm really lost as to what to do. I've been thinking that it may be the transmission range sensor, but I really don't know. I don't want to keep spending money replacing random parts, in hopes of fixing it. I'm on the 3rd starter, because of all the cranking I have to do when it doesn't start.
View 9 Replies
My truck just shut down and now will not start//turn the key on it pulsates at the throttle under the hood and red security light pulsates same time.....I saw post a while back a truck had the same problem. I took the postive and neg off waited 2 hour put back on did nothing no codes come up either ......I was just driving along engine just shut down got it towed ....
View 3 Replies
My engine wont start and i have changed the fuel pump, the fuel pump module, and the fuel rail sensor. it has started once for about 30 seconds but dies and wont start again.
View 6 Replies
i have a 2005 F150 5.4L while driving my message board bell indicated low oil pressure i pulled into the station and checked oil. i had to add about 2 qts i filled up with gas and the truck has not started since. I towed it home changed the oil, filter, oil pressure sensor and the fuel filter
when i try to start it the engine turns over normal no noises, knocking or anything out of the ordinary. It sounds like it wants to start but then acts like something is shutting the fuel pump down. I had the local mechanic tell me that the fuel pump was out. I can here the fuel pump kick on for no more than 2 seconds then shuts off. he told me it should pump for about 5 to 10 seconds. i am not convinced it is the fuel pump dont want to spend $300 on something i dont need.
is there a saftey cut off swith to the fuel pump when the low oil pressure indicator comes on? i also check the codes and its not giving any codes but i had removed the battery and replaced it and i am thinking that removed the codes?
View 7 Replies
I drive a 2005 F-150 XLT with a 5.4L engine in it. This problem only happens after I have been running the truck on a small trip (15-20 min), stop to get something, and then 5 min later start the truck up, and this is the feedback I get.
-Sometimes it barely cranks, idles for a second and then cuts back off.
OR
-Takes much longer than usual to crank and get's going fine.
This is the only time it happens, upon restart after driving for a short period.
View 1 Replies
My 05 f-150 Supercrew 5.4l, will start for a second and then die. I can sometimes feather it and rev it up, but it dies as soon as you let off. I changed the fuel filter and while we had the lines off we turned the key on and it pumped fuel but only for a few seconds. Shouldn't the pump run constantly with an open line?
View 1 Replies
I have a 2005 STX with 107,000 miles on it. When it is cold you have to turn the key on for 5 seconds twice then start it. When it is warm it will start like it always did. When the temperature outside is 60 or above you have to do the key thing about 5 times. I think it is my fuel pump...
View 4 Replies
My truck usually starts up great, but every so often it takes 3 to 4 long cranks before it will start. By long cranks I mean more than 4 or 5 seconds of turnover. Seems to be no real rhyme or reason to this. It does it engine cold or hot. I have iPhone engine monitor app and numbers seem fine. BTW it's a 2005.
View 12 Replies
I have a 05 f150, on initial startup ALL of my needles shake for about 5 seconds and then return to normal operation. What is wrong.
View 2 Replies
I put in a cold air intake in my 05 5.4l. Now truck will start up then die, the throttle doesnt seem to open up when i step on the gas. everything was working fine before I started on it.
View 4 Replies
I have a 6 liter 2005 e350 diesel that starts great when cold and runs well all the time but after it warms up it just cranks but won't fire up. But if i shoot ether into the intake it will start. It doesn't show any failure codes.
View 2 Replies
I'm TSing a no-start on my 2005 6.0L F250. Engine cranks fine. I've been working my way thru the TSing guide and using my new ScanGaugeII. No codes found. At glow plug warmup, (dash light goes off), I'm getting 40.5v FMP, 11.0v FLP, 14.8% ICP, and 0psi IPR. After cranking for 10-15 sec, get 35.5v, 10.0v, 84.7%, and 446psi. I've had a trickle charger on all night to keep the batteries charged. Have not seen FMP over 45 or IPR over 470.
View 14 Replies
I have looked through every post and idea possible with no remedy for my no start condition. I have tried everything that I am capable of doing without diagnostic computers and other specialized tools. A little history of what happened. While idling in the parking lot for a few minutes, truck all of the sudden start running rough, and acts like it is going to quit. Hurried out of the parking lot to make sure that I made it home, but the the truck would only get up to about 25 MPH, but I finally made it home(about 3-4 miles).
NOW, the truck won't start at all, but just cranks. Some more detail about how it cranks. It cranks fast, I separated the batteries by disconnecting the grounds on each, and made sure both are charged. Batteries are only 3 months old from Ford Dealership. As the engine cranks, oil pressure registers after a little while, (longer the first time for some reason), and as soon as oil pressure shows up on the dash indicator, black smoke starts coming out of the exhaust. The engine is trying to start a little bit, but it mostly just cranks.
Things that I've done: Changed fuel filters, Motorcraft (new orings). At first the pump was pumping large bubbles through the line up into the upper fuel filter, but after sitting it appears that it is not pumping bubbles anymore, and I cycled the Key more than 10 times. Did the bubble test while upper filter was removed. Unplugged ICP sensor. Pulled EGR, installed new one. Pulled oil filter and made sure that oil is pumping.
Checked FICM voltage, with key on Injectors buzzing, also engine cranking for quite a while. Never dropped below 48.5 V. Pulled FICM just incase and performed repair procedure, still same volts and no start. Coolant level is good. Checked oil level. unplugged EGR. Checked filter Minder. checked for chafing on FICM harness. Unplugged MAF. Checked FICM relay operation, Fuses all around. I need this truck to run.
View 9 Replies
