Got F-150 4.6 cooling system leak on the heater line (farthest back line) coming out of the block. Fitting looks to be steel. How does it attach/ do I need to remove the Intake to replace?
View 5 RepliesThis problem is from last winter. 95 Jeep Cherokee. After about -10 it just doesn't produce much heat. Heater fan works fine. Jeep runs plenty warm..but what i neglected to mention and or forgot to consider is... I have a tiny leak in the cooling system somewhere. I added just a small amount of coolant a couple of times over the summer and have witnessed a small amount of steam (not lately for whatever reason) coming from the front of engine compartment. I can't find the leak. My question is :Could this cause enough loss of pressure to affect the cabin heating system.....
View 19 RepliesI have a 2003 Ex with the 7.3. There is a leak in the rear coolant line just in front of the rear right tire. Is there any way to bypass the rear heater under the hood?
View 1 RepliesIs it possible to use so much coolant system stop leak that you could clog the transmission cooling system?The fluid is burned and seems like I am having problems with gear shifting and power from the transmission. 2003 Olds Silhouette...
View 1 RepliesI have a '03 f 150 screw 4x4 with 5.4. I had to replace the heater core in the truck and I could hear air going through before the replacement. Now I can still hear it, have tried to burp the system a few times, even jacked up drivers side front on an incline to get reservoir higher. Ended up replacing the hose with the flow restrictor and that worked or so it seemed. The noise is back and I am lost on what to do next. I tested the head gasket and that came back negative also. What to do next or possibly what the issue is?
View 13 Replies02 F150, 5.4 gas motor, about 338k miles. Bought this truck well used so I would have a truck when I needed one. Someone has removed the heater control valve. I've got a new one, but there is a port on the top for a vacuum line, but where this line plugs into.
View 1 RepliesHad a little fender bender. Right after that i noticed the battery red light was on. When I got it home I took the solenoid off the firewall (all the battery wires meet here). When you put 12 volts to the small terminal, the solenoid pulls in and the two big terminals are connected together. That works. When installed on the truck and startup, I have no 12v voltage at the small terminal. Don't have a diagram, but service manual says something about fuse #14 under the dash feeding the "battery cutout".. Checked that fuse and its o.k. .... where does the 12 v signal to the solenoid come from ? I assume somehow it triggers after the alternator starts charging ?
View 12 Replies2003 F-150 Supercrew w/4.6 V-8, 2-wheel drive, 219,000 miles and very well maintained. I'm getting an intermittent overheat condition that I can't figure out. Coolant level is good and I just replaced the thermostat. My OBDII app showed it running at a constant 207 degrees (195 thermostat) after the thermostat. Appears to have good pressure at the cap. It ran great for 30 minutes at idle and then did fine for a five mile test drive.
The next day in the morning it overheated within 3 miles of the house (heat was on) and you could smell it. Pulled over and let it sit for 20 minutes and started back up and it stayed constant at 207 all the way to work (11 miles). It sat at work for about 7 hours and ran great all the way home (without heat, with heat, with air cond). Then this morning it did it again, overheating about 3 miles from home. This time I pulled over and shut it off for about three minutes. Turned the key on without starting and the temp was already dropping again. So I started it up and it continued to drop down so I drove to work with no more issues. This afternoon again went home and it never overheated.
I'm expecting it to overheat again in the morning. I'm gonna go live on the OBDII for temps during the drive tomorrow.
The transmission line running under the radiator has started to leak. I took a piece of rubber trans. hose and buy passed the cooler. How much does the cooler support the trans. temperature. I don't tow with the truck. And for the most part drive it around 14 to 20 miles one way to work. Is this something I need to replace now or after the temperature hits the 80s.
View 5 RepliesRecently I have been having a strong gas smell coming from my 1997 F150 Supercab 4.6L 2wd. It is not happening all of the time. I have also been hearing what sounds like a vacuum line leak. A loud shrill which varies with the engine rpm. This also does not happen all of the time.
View 1 RepliesMy heater core has a leak in it, but I can not get it replaced so I want to bypass it. How do I do that? Is there a video somewhere? Or tutorial with pictures? F-150 1998 ....
View 8 RepliesI have a 2003 Dodge Neon and recently had transmission work done on the car. When I got the car back the radiator cap was left loose, I didn't know this until I took the car for a drive and it overheated. I let the car cool down, replaced the coolant, and made sure the cap was sealed down. The car now has a slow coolant leak, when I turn the car off I can see it drip underneath for about 2 minutes and then it stops. Also, after the car heats up to running temperature I get a burning rubber smell coming through the vents. What could this be? The car only has 70,000 miles on it and I would like to keep it going if I can.
View 6 RepliesI have a 2002 F150 which has a small leak somewhere in the radiator system. I am looking to see if recommended using one of the Bar Leaks products for fixing cooling system leaks. I guess it is an aluminum based product the adheres to the inner services of the cooling system and can stop leaks.
View 6 RepliesI just purchased an 97 E350 (15 Passenger) and I notice that the two rear heater lines (along the driver side) are rotted and is showing sign of minor leakage. Can I simply replace them with rubber heater hoses or do I need to get the factory heater lines?
View 6 RepliesI borrowed a friends 2000 Excursion with the Triton V10, along with his 3300lb, 28' trailer to tow a car from Ashland, OR to Reno, NV to begin a restoration project. His Excursion has 175,000 miles on it and made the trip down flawlessly, but as they say, "No good deed goes unpunished." When attempting to return last Sunday, had to turn around due to overheating problems. Analysis at a local automotive shop concluded a bad radiator cap. Attempted the return trip Tuesday and the same thing happened (only got farther due to the new cap and ability to hold pressure longer).
Finally got into a Ford dealer and have been informed that the truck has a bad head gasket causing pressure to leak into the cooling system. They suggest replacement of with a remanufactureded engine as opposed to replacing head gaskets, due to the time on the entire engine (who knows what else might be bad?). The vehicle can be driven around town for miles with no problems. But put that heavy load on it and grades and it spews out nearly "all" of the coolant.
I have a leak in my inter-cooler system. I have replaced all the hoses. Is there a reason I should not pressure test the system with 20psi? 2001 F350 7.3 turbo....
View 1 RepliesTurns out I've lost nearly all of the coolant from my secondary cooling system and am trying to diagnose the problem.
Things I noticed:
-All of the hoses appear to be in good condition.
-Coolant is dripping from the center of the engine bay.
-After inspecting the turbo area, it appears the valley below the turbo is wet.
The intake manifold is still on the truck, so I haven't been able to get a better look. Is there anything else near the area I am describing that has coolant? My guess is the turbo water inlet?
Perhaps this : Coolant leak on the 6.7 Powerstroke diesel - YouTube...
I have a 2001 530i BMW experiencing an overheating problem. I replaced hoses, radiator, thermostat, water pump, alternator, both belts all of which went fine. However still loosing anti-freeze, it seems to be coming from under the intake manifold. Looking for step by step instructions on removing it to get to the problem?
View 5 RepliesI own a 98 f-150 5.4 with 70,000 miles. I get a check engine light (code p0455-large leak detected in evaporative emission control system).
Replaced the gas cap with an after market 'stant' ( I believe was the manufacturer) brand. The check engine light went away for 4 days then came on again.
No obvious vacuum line leaks.... Puzzled.
I have a '98 Volvo V70 that has a slow leak in the cooling system. I have brought it to my indie Volvo mechanic several times and they keep trying new things - they've replaced the thermostat, all the hoses, overflow tank, and this last time used Stop Leak in case I have a bad head gasket. I'm 4 visits and $1600 into this repair, and it's still leaking. Now they're saying it must be the head gasket and it will be $3000 to fix. What do I do???? How do I know it will fix the car and when do I ask for my money back? When do guarantees come into play? Is the car worth it? It's worth nothing with a leak, so I'm stuck in this corner.
View 7 RepliesI have a 1997 no turbo Passat 2.0 6 cyl.Over the weekend one of the plastic pipes for the coolant system cracked and after the replacement I end up with the panel telling me that there is no coolant on the reservoir. How to bleed the air out of the system or if there is any bleeding valve for this purpose? And where is located?
View 1 Replies