Ford F-150 - 1997-2003 :: Chugging / Low Fuel Light Is Always On / No Start
Aug 29, 2016
I got a call from my inlaws saying their truck wouldn't start. Well apparently it had been chugging the day before keep in mind the low fuel light is always on , and they made it home but it stalled and wouldn't start again ran out of gas i imagine he added gas but still nothing , I know with some of these trucks they have a maxi in the tank but would it clog to the point it wont allow fuel to pass ? how do you bring up dash engine fault codes ...
2003 f150 xlt ....
View 14 Replies
Advertisement
I have a 1997 f150 lariat 4.6, at some point i started losing power, so of course I had my friend come by and check all the mechanics under neath the hood and besides needing caps and rotors all seemed well under there, so twice I've put it on a computer and it needs and o2 sensor, I've already checked my Cadillac coverter , and dropped and replaced my gas tank twice, I ended up having to replace a shock, it does run better when i put heat through it for a short time.
I've been checking my antifreeze and I am not losing none, I also did regular maintenance to it to figuring it was a fowled plug but still no good , so whats next ? coils ? I didn't replace my plug wires but I checked them all and they looked to be in good condition and I have a transmission filter kit to change that out I don't believe its been done ever ..
View 5 Replies
I ran out of CNG - truck won't start on reg fuel. Fuse good, relay clicking and I believe I have voltage going to plug connector going to tank. However, I do not have any wiring diagram to know what I'm looking for. The plug is four wire - yellow- 11 volts, red / black stripe 7 volts, black / red stripe and black wire no volts. What checks can I make before dropping the fuel tank and pulling fuel pump? 2003 F150 7700 Bi-fuel ....
View 6 Replies
How do you test the fuel pump regulator, the truck wont start. I tested the schrader valve and it does have pressure but didn't seem like much. (need a gauge) I replaced fuel pump a few years ago so was wondering about the regulator. Is there a test procedure?
View 7 Replies
I bought the truck now it won't start has to fuel at the fuel rail cranks but won't start when I spray starting fluid it starts but won't stay running....
View 1 Replies
Drove for 25 miles. Park, try to restart to park truck at other place. Truck start but very rough. Did drive for 20 yards and truck stop. Try to restart no way. I think I do not hear fuel pump when I turn key and gas pedal fill completely empty, no any force to move it. Should I assume fuel pump or should check some sensors first? I have P0420 for a few weeks, not source of this problem. Drove truck before with P0420 for years. No other code. Do we have PATS in keys? My truck is f250 99 LD. My pickup have PATS. How to check it?
View 5 Replies
So I pulled into my driveway yesterday about 5 minutes after my low fuel light came on and as I was making the final turn around my house the engine cut off. Luckily I was able to park in it's normal spot before coming to a halt.
Anyway at first I though "out of gas" even though I knew I'd driven further with the light on. After putting in 3 gallons still no luck. I noticed with the key on no noise from the fuel pump so I checked the fuse and relay both were fine. I then checked all the other fuses and noticed the large 30amp PCM fuse under the hood was blown.
When I replaced it, it blew instantly. I was able to hear the fuel pump come on for a brief second before it blew out. Unsure if the two were related I then pulled the Fuel Pump fuse and replaced the PCM fuse one more time and again it blew. The motor cranks over but won't fire (not getting fuel.) Where I can start to correct the issue.
View 8 Replies
My '97 truck has over 315,000 miles on it, original fuel tank, 30.1 gallons, replaced fuel pump maybe a 9 months ago. No gas gauge problems until today. Bought gas this AM and had about 3/4 of a tank. During my drive home (56 miles round trip), noticed the gauge was read about an 1/8. Had monsoon rains today, so I wouldn't have noticed any gas pooling under the truck or a smell if it was suddenly leaking. On the was to fuel up, low fuel light came on. Bought only 5 gals of gas in case tank was leaking and I have to drop the tank. Low fuel light out after restarting the engine but the gauge reads the same, about an eighth? Diagnostic ideas? Won't really be able to examine the tank for leaks until things dry off, probably tomorrow. Diagnostics??
View 4 Replies
So my truck felt gutless somtimes, wouldn't start Every couple days , and Fuel gauge stops at half tank won't show full, so I went n bought a new fuel pump..... Well shoot nothing changed . I guess my next move is pull the dash off n fix gauge? It used to be a reliable truck . Now Im not comfortable to let wife drive it . I also pulled the chip to see if that had to do with not starting, also theft light blinks normal. I'm going to get some connector grease n redo all of my wires to c if there's just connection issues.
View 6 Replies
1999 4.6L won't start after sitting a month. Ran fine before, now won't start. Cranks fine. Cannot hear fuel pump turn on when key is turned. Fuel pump fuse is good.
Fuel pump relay clicks a few times when key is turned. Is this normal? I am hoping it is the relay and not the pump. What should I check next? The wires at the pump? What should they read?
View 2 Replies
The truck is a 4WD with the 4.8L V8, has 134k problem free miles. While pulling a camper trailer the Service Engine Soon light came on and was blinking. After removing the camper the light went away. Now the light has returned and blinks occasionally. The light is not the larger issue tho. When the engine is cold it is difficult to start and I have to hold the accelerator to the floorboard to keep it running or rather chugging but only on days when ambient temps are below 50ish. As the motor warms it chugs less and eventually smooths out. Once the engine has warmed up it runs as if there is no kind of problem. The service engine light stays on but does not blink. This all began suddenly tho there might have been a problem before but we recently moved to the Chicago area from the Phoenix area. A stop at the local auto parts store for a code read said the fuel pressure sensor is bad tho it seems there is something more than that going on. With a Chicago winter coming this needs repaired!
View 3 Replies
2001 F150 5.4 Auto ... Truck was running excellent. Engine light and overdrive light begins to blink and it acts like its running out of fuel or water in gas. Baring made it home. Cleared the code and it comes back. Transmission seems fine.
View 2 Replies
I have a 99 F 250 7.3. It runs fine at idle even for a long time. When I drive around the block a couple of times it will start chugging and lose power and shut off. I have been mixing fryer oil with the diesel. I changed the fuel filter, oil change, crank sensor and fuel pump. I added 15 gallons of diesel and diesel treatment. Pulled fuel filter and bowel is full I'm not sure where to look next.
View 1 Replies
I have a 1998 f 150 v8 4.6 ltr xlt. A mechanic told me that if my tranny gets hot the OVERDRIVE LIGHT will start to blink. It sounds strange to me, should I have a guage installed? I will be towing a trailer this summer.
View 8 Replies
I did the power door fix, wrapping the door actuator motor 'resistor' in foil, and all was good. This morning I started the truck to move it, all fine, then pulled the door panel off to readjust the window guide in the door as windows were binding. After adjustment I went to turn on the ignition to test the window and the Theft light is on, and the truck won't start! It's a1999 F150, 5.4L.
1. The power comes on when I turn the key to ON, then when I turn the key to start the truck I hear nothing, no clicking, and the power goes off.
2. After leaving the key in the On position for 45 seconds, the Theft light blinks rapidly, the odometer is all dashes, the RPM and Speedometer gauges swing to max, then back to 0.
3. When turning the key to start the truck, there's a 1 click sound (solenoid?), then all power goes off on the instrument panel, no cranking.
What might have gone wrong here? Could the wrapping of the 'resistor' in foil in the door actuator have caused an electrical short? [URL] .....
Below happened previously but not any more...
4. When I turn the power back on to ON and push the buttons for the windows, the power seems to cycle On / Off in 2 second intervals, as the window goes down a bit, then stops, then goes down a bit, stops etc. and the lights on the instrument panel dim / go on / dim in the same cycle.
View 14 Replies
i have a 99 f150 with a 4.6 that will not start. it has sat for a while now. when i go to turn the key to turn it on it cranks and cranks and cranks but wont start. the theft light blinks like crazy and the odometer reads dashes. There is also a relay which i do believe is the pcm relay that clicks like crazy. when the relay clicks and the key is first turned to the on position the fuel pump will turn on and off as the relay clicks.
We tried putting a scan tool to it to try to pull a code and the scan tool wont connect. I do believe its the pats system kicking, but i also think its related to this relay clicking like a mother, maybe a bad connection in the junction or something. But I am not really sure how to try to start and find the problem. i have also tried replacing the relay that clicks and the new relay does the same thing.
View 8 Replies
My alarm and lights started going off one night. By the time I got to it, everything stopped. When I tried to start the next morning, I got nothing. After several tries, horn and lights started again. The only way to stop it was to disconnect battery.
One person told me that it was the key or the ignition not recognizing the key. I was then told that my truck, 97 f150, had no chip in the key so the problem was the computer.
I replaced my computer with a refurbished one. Once I hooked up the battery, the horn was still going, lights flashing and theft light still blinking. Also, not sure if its related, but when I try to use the key in the passenger door it turns, but there is very little resistance and the door does not unlock.
1997 F150
4.6L V8
4x4
6" Fabtech Lift
235,000 Miles
View 8 Replies
Have a 97 F150 4.2 that won't start. The lights come on in the interior. Dash lights all come on, turn the key and nothing. Replaced the solenoid on the firewall and no go. Was able to jump it at the solenoid on the firewall and it started. Not sure what's causing this.
View 2 Replies
The brake lights on my '02 F150 have started flashing spontaneously ie - with no one in truck. This lasts for a few minutes, then stops, but can start again a few minutes later. The fear of course is that someday lights could come on and stay on, resulting in dead battery.
I do have a trailer brake controller that has been on truck ten years. Read something on internet that brake pedal switch might be going bad (??). Any one else observed this strange behavior?
View 3 Replies
I have a 2000 f150 with 200k miles. I have no spark and no gas at the fuel rail Schrader valve. I have replaced the shaft pos sensor, no start. I have checked the fuses and the relays. I have crawled under truck and listen for the fuel pump to turn on while someone turned the key to on and heard nothing. I have 2 keys and while turning the key to on and start, the THEFT lite flashes. I have checked the impact sensor on the passing sick panel, it hasn't been tripped.
View 5 Replies
01 F150. Cranks but no start, will fire with starter fluid spray. Theft light fast flash, Check engine light on. Only have one key and don't know what the kid that had owned has done.
View 5 Replies
