Ford F-150 - 1997-2003 :: 2002 - When Turn The Ignition On Engine Will Turn Over But Not Start
Nov 9, 2012
My 2002 F150 Screw has been giving me issues when trying to start it for the last month. Sometimes it will start sometimes it won't. When I turn the ignition on the gauges all seem normal, the theft light turns solid then goes out, but engine will turn over but not start. Sometimes it will start if I leave the ignition on for 20 seconds then pull the key and try again. (this doesn't always work). I have disconnected the battery for about 2 minutes this usually works but not always.
Sometimes it will start first time with no issues. Once the the engine fires it runs fine. Another symptom is when I shut the engine off, pull the key and open the door, the chime telling me that the key is still in the ignition sounds. (but the key is in my hand)
I put a new battery in yesterday to rule that out and because the old one seemed to be getting weak. (starting issues didn't go away). I don't want to put 300+ into a fuel pump without being sure that's the problem.
View 1 Replies
Advertisement
When I turn off the ignition and try to rotate the ignition switch/key to the steering column lock position it will not go all the way. It stops just before locking the steering column and I cannot remove the key. This is an automatic with a gearshift on the column. I have to reach up with my left hand to pull the gearshift lever up as if to pass the PARK position. While holding the gearshift like that the ignition switch can be rotated to lock and key removed.
I had the dealership attempt to fix this twice while under warranty with no success. After 10 years I am sick of it and would like to fix it. 2002 Ford F150 4x4 5.4L automatic on column.
View 11 Replies
I have an 02 f150 5.4 4x4, drowned it a while back, thought i had hydro lock, crank can be turned by hand though as far as i can with a wrench, so internals seem to be fine, no bent or broken rods that i could tell, ripped everything apart cleaned it up put it back together, new fuses, new ignition relay, new starter, alternator and battery as well, turned the key to on and got all my electronic stuff back up, turned to start and it all goes dark, which i assume is because at that point its sending power to the starter, but the starter didn't turn or crank the engine...
So question being when i put my new starter on is it possible that i might have crossed a wire or something that would cause it to not crank? and due to the fact that I had water in it, and had hydro locked it, all my plugs are out, now I know that spark is needed for the engine to run, but shouldn't be needed just for the crank to turn right? question being is that once i fix the wires on my starter, I am looking for initial crank before start up, so do i need to put a plug or two back in and hook them up to make it crank? or will it crank without them? and yes I did replace all my fluids as well.
View 8 Replies
I'm having a problem with my ignition switch. It won't turn and I have to turn the steering wheel for it to finally work.
View 4 Replies
I have a 1997 ford f150 V-6 4.2. My son was driving the truck on the expressway and it quit running. The toe truck has delivered the truck back to my house. The engine turns over but will not start. I shot gas into the engine with a spray bottle and the engine still would not start. Was going to check the coil for spark next. What to check first. Was thinking the problem could be the modulator or coil.
View 10 Replies
I have a 2001 F150 step side 4.6L that just stopped turning over to start. The engine rocks slightly when you turn the key, then nothing but a little electrical smell. Was starting fine up to this past week. Battery is strong and good and upper battery connections clean, has original starter solenoid. I am a weekend mechanic, my son's work truck, trying to do this myself.
View 1 Replies
I drive a 1997 well-maintained Toyota. This is the 1st time I've had this problem. It started yesterday. I started my car, as usual to stop somewhere for 5 minutes. When I returned I tried to start the car and got "nothing". No sounds, but the lights/radio/dashlight worked. I tried several times, gave up and called AAA.
I took a walk around the block to see if my mechanic was open on Saturday in case I had to tow my car there. It wasn't. I went back to my car to wait for AAA. However, this time the car started immediately, and I drove home after cancelling AAA. I drove the car the rest of the day/evening on & off with no problems.
Today, I tried to start it in the AM and once again it did not start (like the previous day). My neighbor suggested that the ignition & steering wheel are related and could be something to do with that. Anyway, I tried turning the wheel to the right/left, etc. but could not get it started today as I did the day before,
Tomorrow I plan to have it towed (or maybe it will start again) to my mechanic. What could be wrong? Never had this type of thing happen before. The battery is good.
View 4 Replies
97 F150 4.2 auto with Simple trans pan gasket change because it was leaking and now the ignition fuse blows every time I turn the key to the on position. Ran fine before now what? can't pull code with reader with key on or off.
View 4 Replies
Pulling into work this morning I noticed my check engine light was flashing. The car (1997 Buick LeSabre, aka The Rolling Couch) was still running and everything seemed normal. I turned off the car and then went back out 3 hours later and tried to start it. It would not start, and the symptom is not one I've had any luck Googling. When I turn the key, it makes a sound, but it's not a click. It's the normal sound when ignition starts, but the engine does not crank at all or turn over. It just makes a single ignition sound and then nothing. Could this be a belt? The starter? I have not taken it anywhere or pulled the error code yet.
View 13 Replies
I have an 02 F150 super crew FX4 4.6. Over the last year, about once every 2 months I noticed that the AC wouldn't turn off when I took the key out. I would turn it back on and off and it would stop. A couple weeks ago during a mild hurricane (we get those in NC, just a lot of rain) the truck started trying to start itself in the drive way but wouldn't turn over.
Then it started trying to turn itself over while I was driving. (but only after heavy rain). I thought I identified that it wouldn't happen if I pulled out the key ignition lock cylinder thing. You know, you have to push it in and then turn to start; If I made sure it wasn't pushed it, it seemed not to ghost start. So I figured maybe it was an issue with the key ignition lock.
Then this week it wouldn't start, it would try to turn over but not start. (usually after rain). I replaced the starter solenoid relay and things seemed to be fine for the last 2 days.
Well it rained like hell last night. It wouldn't turn over. After trying to turn it over and removing the key, the accessories stayed on (fan, radio, etc - even with opening door). I pulled the 50a fuze which killed the accessories, and it would turn over without that fuse in, but I had to put the fuse back in to get it out of park.
Another clue, recently, occasionally I hear relay clicking behind my dash after the key is out when it is acting up. So I am lost here. Should I rip out the dash and see if water is leaking in?
View 3 Replies
I put the key in and maybe 1 out of 10 times it wont turn to start the engine. When I pull it out and put it back in 2-3 times it will turn. I tried my spare key and it still happens. I have W2-40'd it with no luck. I am out in the wilderness a lot and don't want to get stranded. is it the switch or has the interlock cable shown this as a problem? What are the steps to replace the switch?
View 1 Replies
We have a 2004 2.4L 4 cyl Santa Fe. Turn ignition key get a click and engine will not turn over. Push key in harder and engine may start fine. If it is the key ignition switch or something else. is there somewhere I can look to see how to remove the ignition switch?
View 4 Replies
I have a 2002 F-150 xlt 4x4 5.4l V8, 96k miles. been sitting about 3 weeks i went to start it and nothing.. thought ok jump. We tried jumping/charging the battery nothing. then we switched batteries from running car same thing when i turn key just hear a click in dash. battery light remained on even when we swapped out. The theft light was off as well.
View 1 Replies
I have a 2005 SE 3.3L engine with 115000Miles,
When you turn the ignition key , you have to wait for it to crank 6-7 times before it starts. whether engine is cold or warm it makes no difference.
I was wondering how your engines ( 3.3Ls) behave, does that start immediately after 1-2 cranks, or it is normal for this type of engines to take 6-7 turns ?
View 4 Replies
Just picked up a 1999 F-150 XL, 4.2L V6, 5-Speed. Spent half the day rewiring the headlights back to factory as a previous owner did a bunch of wiring that made absolutely no sense. (Foglights or KC lights?). Anyway, works great with the exception that the headlights turn on when I turn the selector to just parking lights. I removed all but the factory wires under the hood. I haven't been behind the dash yet to check the headlight switch and I was hoping to avoid doing so. A fuse or relay that may be causing the issue? I don't have a service manual yet so I haven't been able to identify all the fuses under the hood.
View 2 Replies
Started the morning with oil pressure gauge dropping to 0, gave it a few minutes checked oil, it was fine. Restarted truck, pressure went back to normal. Drove about another 30 miles pressure gauge would drop but would rise when hit accelerator. I was driving about 60mph, gauge went back to 0, check engine light came on and within a matter of seconds, a whining noise started, pulled over before i could completely stop, it died, and now won't crank.
View 6 Replies
My 1997 F150 with the 5.4 engine has 167,300 miles. My wife drove it to work the other day and when she went to come home the truck would not turn over. The starter would engage the flywheel but would not turn the engine over. I had it towed home and I pulled the starter. Advance Auto bench checked it for me and said the starter was fine, only drawing 36 amps. I have also verified the cabling from the battery and starter relay is fine.
So here is some history up to this point. Over the past four months the battery light would come on and off. I had the battery (only 8 months old) and the alternator check and both tested fine. At one time the check engine light came on and the code indicated a miss fire on the #3 cylinder. I pulled the plug (new platium plugs at 120k miles) which looked fine and reconnected everything. Since I disconnected the neg. terminal of the battery the engine code cleared. Once in a while the engine would sputter and run rough at 40 - 45 mph, but run fine at slower or higher speeds.
Since I had the starter off I used a pry bar to try to manually turn the flywheel, seems to turn in one direction but not the other. I have also tried to turning the engine over by hand via the belt and putting a socket on crankshaft pully bolt. I can not get the engine to turn over. So in my reading on the internet it seems like I might have a hydrolock. I have not lost any antifreeze that I can detect and I have not seen any white smoke coming from the exhaust. From what I'm reading there are two types of hydrolocks, one caused by antifreeze and the other caused by a open fuel injector.
Does what I am describing sound like a hydrolock and what is the best way to diagnose if it is caused by a leaking gasket or injector? Should I pull a couple of plugs on each side and try to crank the truck?
View 11 Replies
My daughter has a 1997 Taurus SHO and it's been running pretty well until this morning when a turn of the key failed to start the engine. The battery is fully charged but when she turns the key, we get the click from several places under the hood, including the starter relay. I'm pretty sure it's the starter relay, it's inside of the fuse box, is identified as "starter" on the guide printed inside of the cover and is black plastic about 1.5 inches square. The windows, radio, horn and all of the other accessories work, but no reaction to the key.
View 2 Replies
I have a 1998 F150, had this truck for just shy of 200,000 miles, never a major problem and now she's killing me. Turn the key, no crank,no start, the same time this started the radio also quit working. I can start her with a screw driver at the soleniod (new by the way) runs perfect after that. By the way it's a 2 wheel drive with the 4.6 v-8
View 1 Replies
This 97 F150 4.2 is new to me, originally a very base 2wd white fleet vehicle, with 189,000 miles, runs smoothly and quietly, idles well, transmission shifts smoothly. Gets reasonable gas mileage.
Problem statement: the truck has an intermittent starting problem. The failure to start happens about 5-10% of the time. The motor will turn over fine, but but immediately stumbles while trying to start. Turn key off and then re-start attempt will be again followed by a bucking stumble. Some times the motor might try and run for 2-3 seconds bucking and stumbling. It is possible the problem happens more often when the truck is warm and has been shut off for 15 minutes or so. Once the problem happens it is very repeatable. It won't start again unless I wait about 30 minutes to an hour. Once it starts it seems to run very nicely. I have noticed some times when I go to successfully start the truck it might run roughly for the first 3-4 seconds bucking and sputtering a bit and then smooth out and not have an issue until the next re-start attempt.
The truck runs so nicely when it is running I doubt it is an issue with the plugs, air filter general tune up. Could it be an intermittent fuel pump issue? The next time it occurs I will check fuel pressure. Could it be fuel pressure regulator? Also tested by fuel pressure. ECU? The truck runs very nicely most of time that seems like a long shot. Crank sensor? Bad fuel? I did add some dry gas.
View 14 Replies
Drove it last night around 9pm. Parked it and went to drive it again this morning around 7:30. No cold weather here or rain. Here is what I know: When I turn the key I hear a click (not a repeating click) but the engine doesn't turn over. Batteries have 12.5 volts. I put my trickle charger on them and had full charge after about 3 or 4 minutes. When I turn the key the headlights do not go dim. I put a screw driver across the solenoid on the passenger side fender and got a strong arc. When I do that, I can also hear another click that sounds like its coming from the engine. I tapped the starter a few times with a hammer, but it still wont turn over. I'm guessing bad starter.
View 14 Replies
