Ford F-150 - 1997-2003 :: 2001 V6 - Annoying Rattle / Vibration Under Driver Side Dash
Apr 16, 2012
I have a 2001 F-150 Supercab with the V-6. This past weekend it developed some strange noise best described as a rattle or vibration that sounds like it is coming from under the driver's side dash possibly somewhere right behind the instrument cluster. May even sounds a little like a "grinding" noise - like two plastic gears not agreeing with each other, but I don't know of anything under there that could make that noise. I have opened the hood and listened from there with my wife pressing the gas to make the noise start, but can't hear anything from outside the truck.
It is not constant, but starts as soon as I give it a little gas, even before I put it in drive. It's a little worse when it is in drive. I have turned the air on and off, turned the steering wheel, pressed the brake, etc, and it doesn't appear to be related to anything obvious. I have stuck my hand under the dash and can't find anything obviously loose.
View 9 Replies
Advertisement
2001 F150 2WD 4.6 102,000 miles.... All rotors and pads replaced by a shop and the trouble began. The shop swore it was my tires and like a dummie I took it to Sams and had my tires replaced.
What's been done? New BFG Long Trail T/A Touring Tires, rotors and pads were replaced a second time, new Monroe shocks and the shocks were replaced a second time, new U-joints, front wheel bearings repacked, ball joints inspected and have slight wear, new driveshaft at 20,000 miles, two new rims, two new back tires of same type, wheels balanced over and over with road force equipment. All this got rid of a dangerous shake at 67 mph but did not affect the 42 mph bounce.
I now have a pronounced bounce at 42 mph. I have an annoying vibration at 67 mph that is present 97% of the time and an occasional smooth ride for 3-4 miles on the interstate before the vibration resumes. The ride is always rough until the tires warm up. I think the vibration is caused by the road and the truck can't stop it, but I'm not sure. Three shops are scratching their heads.
View 14 Replies
I'm wondering what is going on with my 2001 F-150's 5.4L Triton engine. Recently it's been making this noise that I can best describe as a "rattle" from the passenger side of the engine. It's not a constant rattle, it comes and goes every few seconds.
It sounds like it's either from the valve cover or timing cover, so I was thinking maybe it's the feared Cam Phaser failure, however the noise doesn't seem to match what I've heard from other videos of confirmed Cam Phaser failures.
I've attached a link to a video of the noise that I made. It also has a lifter tap from the opposite side of the engine that may be noticeable in the video. It has been present since I bought the truck two years ago, it hasn't gotten any worse and it isn't what I'm concerned about.
Video link : [URL] ....
View 8 Replies
I bought a 2010 Tiguan in April and have loved it, except for an annoying rattle in the dash. I took it to the dealer a few weeks ago and they couldn't find it. Took it back, they had it for two weeks - still couldn't find it, and ended up calling in Volkswagen engineering. Apparently, I have one of six cars that has this problem, VW is trying to find a fix. I picked up my car on Friday and realized that the bluetooth wasn't working and they'd put scratches on my dash. There were also grease marks on part of the plastic, and my gas light was on. Took it back yesterday, they fixed the bluetooth and put a small hole in my headliner in the process. I don't know what to do, the dealer said they would try to patch it, but it's right up front where I'll have to look at it all the time. I really want them to replace it, but at this point I'm worried what else they'll screw up.
View 9 Replies
I have a 2003 F150 manual 4WD with 4.6L engine and 165000 miles. When i am driving i feel a vibration in the steering wheel and on floor board that intensifies when i press the accelerator. I do hear an irregular humming that sounds like it is coming from the driver side front. I checked the wheel for any play but it was very tight. i check tie rod ends, ball joints no play. i recently changed both u-joints on the rear shaft and the bearing hub on the passenger side front. Also, the steering feels a little 'wobbly' when i make sharp turns. it almost feels like it is giving. What else should i check?
View 1 Replies
I have a 2004 FX4 and have a very annoying rattle up in the driver's side dash area near the windshield. This happens every time it gets to be winter. The odd thing is, that it will sometimes go away but when I hit an uneven surface such as a railroad crossing, I hear a loud "pop" near that area. Then it will rattle non stop. I don't know if it is the wiper cowling area or what? IMO Ford's design of that area is crap.
View 11 Replies
I recently purchased a certified pre owned 11 350 AWD and am noticing a dash rattle on the drivers side. It seems to be on the dash above the tachometer. If I apply pressure(w my hand) it seems to go away.
I know rattles come in all shapes and sizes but where would you start?
Here's a night pic: Only had it a few weeks.
This is what I have done so far.
20/10 Tint
6K Low Beam Headlights
LED Parking Lights
Quick question: By replacing the HID low beam bulb do I lose the headlight turning adjustment feature. It doesn't appear to work now.
Thinking about Plastidipping the AWD GS350 emblem
View 3 Replies
My wife's 2011 Gti (31k miles, dsg) has developed a bad rattle vibration at idle. It goes away when you press on the gas. At first first I thought it was just a bit of plastic rattling in the wheel well or engine bay, but now I'm suspecting the engine. It's coming from the drivers side and it sounds like the 'TSI rattle' turned up to 11. It's intermittent, but worse when it's cold.
Engine mount? Chain guides going going bad? I will try to get a video of the sound today.
View 1 Replies
I finally pulled the trigger on a dark grey Corolla S yesterday, and it turns out that it rattles on the driver side top dash. When I push on it, it stops, but it's pretty annoying and noticeable. I guess I should take it back.
View 14 Replies
So I have finally solved the rattle that has been seemingly coming from my driver side dash speaker. I'm not exactly sure which of the 3 things I did fixed it, but it's fixed.
First, I removed the 2 10mm bolts securing the speaker and removed the wiring harness. I noticed that there are 2 metal clips that those bolts screw into and they are loose, so I took some electrical tape and just taped over them to keep them from rattling.
Next, I found the wire for the speaker has a plastic shroud around it that is very stiff and could make noise, so I wrapped that with electrical tape as well.
Finally, the thing that was most likely the cause of the rattle was a loose wiring harness attached to the firewall. If you reach into the speaker hole you will feel the harness just under the hole. Where the harness is attached to the firewall it was extremely loose. I simply took a paper towel and was able to wedge it behind the harness and the firewall which kept it from moving.
Now the driver side rattle is gone, but I've noticed another rattle somewhere else near the center/passenger side of the dash. Every time I fix one rattle I seem to find another. Maybe I'm being a little OCD about it.
View 6 Replies
So I had a persistent dash rattle that would mysteriously go away when my car was brought in for service. I took it in a 2nd time, again nothing. So I took the service adviser for a drive until it showed up... then it wouldn't stop.
Shop foreman drove it right after we got back and this time he heard it too... took 4 hours to re/re the dash trim and radio but they found some HVAC ducting was loose from the factory ( b4 work??) and rattling around. They put it back together and apparently put tape around the joints (like you would in your home - I guess from the factory the pipes just snap together). Car is much quieter now. Just hoping this issue doesn't come back in 4-5 years when the tape falls off? It also stopped an intermittent rattle coming from the right side of the dash.
There was also a wind buffeting noise around the drivers side doors. There is a TSB to address this now for 4-door cars. A minor adjustment to a seal and I was good to go, again much quieter. I'll have to see how it fairs at 130kph on the highway, but the buffeting I could already hear at 90kph is completely gone.
View 2 Replies
I have a 2013 Hyundai Elantra Limited and have noticed a rattle in the front driver's door area near the Dash. It's hard to pinpoint where exactly it is coming from. The rattle can be heard even on smoothish roads and sounds like a little screw or something else is loose or rubbing against something. I checked that sunglasses holder and made sure nothing was in there but the rattle is still there.
View 55 Replies
Purchased 2000 F150 (224000 miles) about a year go cheap for knock around truck. Only gets driven about twice week (20 miles most). Has been running great until recently. Got in the other day went about a mile and notice really strong vibration in steering wheel and dash. First thought about something to do with alignment etc. After a little experimentation realized it was the motor. When you get to around 40 mph and try to hold the speed constant it starts shaking (I believe the motor is missing). If you mash the gas and accelerate it stops. As soon as you try to hold constant speed again it starts again. I can run it up to say 45 and let off the gas and the shaking stops. Once it was driven like this for about 5 miles or so, when I come to stop sign it idles rough. If it is put in neutral runs smoother. Could the fuel filter be clogging up? I did try some additive to see if it would clean it out, no luck. Now the check engine soon lite came on. Fuel Filter, Plugs?
View 5 Replies
2001 chev s-10 pick up with 3rd door.driver's side door[s] rattle over bumps and whatnot, the doors seem to work perfect and hinges are tight,the door alignment is good, and its not a door panel or loose item...its the door[s].
View 6 Replies
I have a 2002 F150 Lariat Supercrew, and suddenly a bad rattle developed inside the passenger side door. The window still works fine, but I'm afraid it won't much longer. I have taken the panel off, and can reach into one of the supports and mimic the rattle. When you shut the door, it sounds like the glass is going to fall out. I had to replace the motor on the driver's side door a couple of years ago, and I'm hoping to prevent another window sliding down inside the door. How to fix this situation? I haven't been able to feel anything that may have come loose.
View 3 Replies
A little back ground... Drove from NM to MN. Truck ran well averaged 13.5 mpg. hand calc'd (only .1 off of trip computer, I found it was typically a rounding difference). Shimmy and vibration from 70 to 80 mph, I am getting wheels rebalanced today. Rear AC blows very cold, front AC needs attention, coldish air blowing.
I have a squeak behind the bash on the passenger side. After about 300 miles of feeling in, under, over etc we couldn't find the squeak. After a bit we turned off the max AC and the squeak went away. Now it is a squeak with road movement but it only does it when the Max AC fan is running. When we got to Minnesota, we lifted the hood and I can move the whole AC unit and recreate the squeak/rattle. Is this movement usual? Would this be the cause of my front AC not blowing cold?
View 4 Replies
What is it? Can it be shut off?
View 3 Replies
2001 f350 4x4 dually 7.3 powerstroke, I recently replaced the hub assembly, stub shaft and seal, u joint, ball joints on the front drivers side and now periodically the truck makes a grinding growling vibration coming from front drivers side and stops after hitting a bump...
View 3 Replies
Having an issue with my 97 f150 its a 4x4 with 4.6L engine the issue is my driver side window keeps going down by itself. I changed the switch and relay for the power windows and still doing same thing?
View 2 Replies
I have a 97 expedition It started a month ago crossing the border, I stopped at customs booth drivers side window would not go down. During the next couple of days the drivers side window would go down by itself, and I would have to bring the window back up. I have done alot of research on line everyone was telling me it was the GEM Module.
The window switch is good and the window regulator is good. Brought to my neighborhood mechanic, he said he was 90% sure that it was the GEM Module, he even said that he was tapping on the GEM Module and the window would go down on it's own. I decided to order a GEM Module online to fit my vehicle, received it on Saturday, installed it. [found no moisture around module] Same Problem, window would not go down. Now I have the drivers side motor unplugged from the switch.
View 2 Replies
1998 f150 4x4 the drivers window is stuck up. It clicks by the up button but not the down button. The pass window works fine by both buttons, the door locks work fine. Took out the switch it tests with a ohm meter fine. The switch has power to it. I took out the window motor jumpered it to the battery and it works in both directions. Manually ran the window up and down and it moves freely. I swapped the relays under the dash and everything operates the same. I'm not sure where to go next for trouble shooting this problem.
View 6 Replies
