Ford F-150 - 1997-2003 :: 2000 - Copper Colored Flakes In Overflow Tank?
Jun 21, 2016
I have a 2000 expy with the 5.4 just turned over 200k. I bought the upper and lower radiator hoses awhile back and finally gotta chance to change them out. I noticed i got the wrong bottom hose so I only swapped out the top hose. I filled it back up with 1.5 gal of distilled water. After I drove it about 60 miles I checked the overflow tank and noticed copper colored flakes in it. Im assuming the previous owner put some stop leak in it but not sure Ive never had any problems as far as overheating or losing coolant. What else could it be? Im going to get the right bottom hose and do a flush. Can I use the bottom hose I have, its got the two extra hoses for the oil cooler? I was just going to connect the two hoses together but not sure if that will cause a problem.
View 1 Replies
Advertisement
1996 F-150 5.0... So I bought this truck a couple months ago for a really good price and its my regular vehicle that I use daily. While driving I switched tanks from the front to rear and when i reached my destination i noticed that fuel spilled from the cap, I opened the cap and fuel overflowed. I've read in forums saying that its the Fuel Pressure Regulator or the Fuel Tank Selector Valve . It still drives and runs fine, but I would like to know which part its specifically causing the problem?
View 1 Replies
I have a 97 F-150 and my Radiator fluid has been leaking very bad but hasn't been taking the fluid from overflow tank. Actually the new fluid that I put in the overflow has now turned a rusty color....
View 3 Replies
Anyway here's the problem. My son has a 2000 Ranger 3.0L V6 he left me when he had to move back up to Las Vegas. I was out checking it out today and pulled the radiator cap, man what a mess. It looks like reddish mud in there and the overflow tank. It's not milky like oil in there it's more like mud. It's caked up on the bottom of the cap and inside the filler neck and the coolant looks the same.
So the questions are, what's the best way to clean it all out and what would cause it?
View 4 Replies
Truck was throwing that collect temp different than oil temp light then started to heat. When I drove temp went down. When I stopped I checked coolant t as low and left orange rust dust around and under overflow I have topped off but can't find a leak. I clean it and it comes back I have a leak somewhere? Head gasket? But oil is fine I drive my truck 200 miles no issues?
View 14 Replies
Recently purchased a 2000 ford f150 4.2l. started hesitating when i would try to accelerated stressed or when a.c on. if i drive it like a grandpa wont do it. filled up the gas tank and it completely went away. the second it went down to the 3/4 line, started hesitating again. mind you when it was full even with the a.c on and going 80mph on expressway it would not hesitate.
View 2 Replies
So I have a 98 f150 with the 4.6L V8. Been having some issues with it, first off it gets the standard film on the windows associated with a bad heater core, it doesn't leak fluid into the truck tho. But it does have an issue with heat. Also while driving the coolant system develops an air bubble and pushes fluid out the over flow. Also it periodically registers that it's over heating and goes into limp mode. if you press in the clutch and turn the truck off it resets and acts as if nothing ever happened.
View 2 Replies
My overflow tank seems to be going empty slowly. The last time I filled it was in March and I filled it to the Full line. Now, the overflow is almost empty. I did 425 KM last night almost non-stop and the level stayed the same since that night and today. So, I am not burning any thru the gaskets. Exhaust is not white neither.
I did see one suspect thought. I have this really small rad at the bottom of the bumper and it seems a little wet around the tubes that enter it. Could it be that? I have no spots on the driveway or road when I park. Specs of my truck:
190 000 KM.
Oil changed on Saturday.
Runs well, no loss of power.
Temps are good.
View 3 Replies
I got a 64 F100 with a 292 that I am thinking of installing a coolant overflow tank on to aliviate having to fill the radiator frequently.
The question being............Is it a sealed system or do I need to provide an air bleed to adjust for the presure change within the cylinder I intend to use?
I realise that thermal syphoning will return the coolant to the radiator but am unsure as to weather or not I need to allow the airspace to remain at atmospheric pressure.
View 5 Replies
I have owned my 2005 v10 ex since 60000 miles. Have had many dependable family road trips and love my truck.
Recently it has started puking coolant and the overflow tank smells like exhaust. The oil cap has some coolant sludge on it. But there is no coolant mixed with the oil. Or oil in the coolant.
I am pretty certain these are the signs of failing head gaskets. The truck has 193000 miles on it now.
Want to keep it on course. But keep it reliable. So do I buy new engine or do I just replace head gaskets?
View 14 Replies
I have a 2002 Ford Explorer and I am still trying to figure out why the coolant will overflow in the radiator reserve tank. I put in a new thermostat and a new cap to the overflow tank. When the tank is cold, sat over night, I put in new anti-freeze to the cold coolant line. Then I start up the explorer and let it run for a while. The temp gauge goes up, then drops a tad and cold air comes out of the vents.
After I rev up the engine, I see the coolant level starts to rise in the overflow tank, then it goes to the top and starts to leak out. This takes a while being the thermostat has not kicked in to suck the fluid in. Before this happens, the heater core lines are luke warm. After the tank overflows, the remaining gets sucked into the engine and I get nice warm heat. What causes this. I had the test done to see if the head gasket is bad. The test was negative.
View 9 Replies
I have a '88 F250 with a couple of dual tank issues, first of all if I'm running on the rear tank the fuel returns in the front tank.... not an isssue if trhe front tank is empty, but if both tanks are full the front tank will overflow. If the front tank is empty I run on the back tank until I'm out of gas and switch to the front and I"ll have about a half a tank in the front tank.
Second issue, running the front tank the fuel gauge stays on full until I have about half a tank, then it works OK. If I'm running the back tank it stays on full, even after the tank runs out of gas??
View 14 Replies
I am scheduled to leave on a trip in the morning. I have installed an 85 gallon in bed auxillary fuel tank. I plumbed it in as per the instructions and the same as the last two I had in other trucks. After install I pumped 25 gallons in the aux to see how it worked. Every thing worked right. So yesterday I filled both tanks to the top and left the shutoff between them open.
This morning I noticed a puddle of diesel on the shop floor. Wiped it up and left for the golf course. Got home and found another puddle. I have closed the shut-off valve but it still seems to be leaking. It is not the plumbing I installed. It's hard to tell because I have a protector around the tank but it seems the leak is coming from the top. I just took a short run down the highway and reparked it. I have a can't miss appointment so when I get back I'll see how much has leaked.
Is there some kind of overflow on top the tank? Everything is dry where the aux tank is plumbed in and the air pipe seems to be fine. If the leak stops with the shutoff closed then I'm just gonna head out but if not then I'm gonna take down the shield and see what I can find, but I'd sure rather not.
View 14 Replies
So I have been troubleshooting a few cooling issues and I am currently at a loss of WTF is going on with this thing. The truck is a 99 5.4L SD and has no heat and was burping a little coolant.
The truck was originally burping coolant out of the overflow tank. After verifying that it was not a head gasket by all means except the exhaust gas test. I replaced the overflow tank and cap.
Now the truck is holding pressure fine but I do not have heat. Here is what I have done:
I replaced the blend door actuator--no heat
I went to flush the heater core and since the quick disconnects were such a bitch to get off I decided ti replace it while I was at it. --still no heat,
New thermostat 195 deg --no heat
The radiator is brand new
Supposedly the water pump was replaced by the previous owner I have all the receipts for the truck so I could double check
Truck seems to circulate coolant fine i measured temps at the water outlet with an IR thermometer peaking at about 175~10 deg due to accuracy of the thermometer and heat loss due to thermal variations the lower radiator hose and reservoir coolant temps were around 76~10 degrees so the radiator is working as advertised . Truck doesn't overheat, granted after draining and replacing the coolant the temp gauge did climb some while driving until i worked out all the air pockets but still didn't overheat.
View 14 Replies
My 1992 Nissan Primera 2.0 slx is overheating, probably on its last legs. First time this happened the radiator overflow tank seemed low so I topped it up with glycerol and added some leak plugger to the radiator for good measure. The car drove just fine for 20-30km then it happened again. At the same time, and I don't know if this is relevant, the windscreen defroster, which should bleed warm engine air, now only gives cold.
View 3 Replies
Having a problem with the 2008 Sonata GLS. When filling gas tank, pump nozzle clicks off, but gas flow continues, creating a significant spillage.
View 7 Replies
Is it normal for a small amount of antifreeze to leak out of the small hole on top of my Jaz overflow tank? This is on a 73 Chevy small block.
View 4 Replies
I have an 1979 F150, 351 V8, only 104,000 miles. Been driving it sporadically, had it serviced over the years, been driving it until recently. At least three new batteries have drained to dead in short amounts of time. No one seems to be able to pinpoint the trouble. It has two gas tanks--the original tank overflows out the filler cap in hot weather, even when mostly empty. I must find this trouble. Again--it's been seen by several repair shops, but no one has fixed the problem.
View 1 Replies
I was wondering if I can replace my overflow tube for my gas tank without replacing the whole gas tank. I know I will have to drop the tank and get new straps to install it, but would I need a completely new tank or can I buy an overflow tube separately?
View 3 Replies
When filling the gas tank, the pump shuts-off (as it should) unless the tank filled very-very slowly. It has overflowed/spilled before the pump even shut-off in some cases.
CEL is not on. DTC 16826 stored: "EVAP Emission Contrl.Sys (small leak) Leak Detected". I just got a VAG-COM cable but haven't got the software going
yet.
Bentley has some diagrams for the fuel vapor recovery system but that's about it. Seems like there's something with the fuel vapor recovery / venting system going on. How to further diagnose?
'01 Passat 1.8T ....
View 3 Replies
1998 Mitsubishi Eclipse. 2.0L 5-speed. 195,000. When I complete my 33 mile trip home and shut off engine, I can hear air bubbling into the overflow tank from radiator. Temp gauge shows normal. Just had new water pump, thermostat, radiator flush and refill and new 16 lb radiator cap installed. Overflow tank fills up to near top (not running over) and when engine cools, the tank is back down to half way. I've checked water level in radiator when cool and it is full. Question: Is this normal? Don't think I've ever noticed or heard the bubbling sound before. The engine runs great and smoothly.
View 5 Replies
