My 1999 5.4l runs great then after driving about 20 minutes, surges & stalls if you try to accelerate. Then the idle surges from 600 to 1500 (back and forth). Connected a fuel pressure gauge, and it shows 30 then drops to near 0 then bounces back to 30 then near 0, then back to 30 etc. No codes are reporting. What to check? Let it cool down, process repeats. Has new fuel pump & filter.
View 4 RepliesI am new to FTE and have a question about my 99 4.2l. After it warms up, i can shut it off and about 30 mins later try to start it again and it will idle very rough and sometimes stall. I also noticed that it surges sometimes with just off idle throttle when its cold. I am not getting any codes thrown, here's what I've done so far: cleaned the maf and throttle body, and it didnt work at all. I did convert my cht over to ect by using the plugged coolant outlet on the lower right side of the intake manifold and extending the connector wires which actually solved the problem a little bit but it still does it from time to time.
More info about the cht to ect conversion, but after reading that ford did away with them in later models i wanted to do the same while at the same time making it so much easier to swap it out if ever needed. No more getting under the truck. And where im at cht's are kind of hard to come by without having to order them Anyway, it worked flawlessly! I only had to extend the wires by about 8", wrapped them and ran it along side the injectors for a clean factory look. Ill try to post pics soon...
03 supercrew 5.4. I've been having problems climbing hills. I'm on a trip and the truck surged fron do then to drive and stopped. Let it sit for 30 mins or so and it was good. Drove another 500 miles ans started again going up some hills. The first time it was 110 out and the 2nd it was 90. I'm pretty sure it's a cop but of course no cel. It does not seem to of over heated either. Can the cops overheat? Do you recommend a diagnostic, will this show up if no cel has show?
View 5 RepliesFor example. If you are going 30 mph the engine surges. It surges when the throttle is in the same tps location.
View 1 Replies2001 F150! It does this weird little surge, burping and farting away...but only in ambient heat. The engine never gets hot, it never over heats. What have we done? A full tuneup with new plugs and boots, oil change, new air filter, gas filter. It did it again...took it back in and had the fuel pressure checked, fuel injectors are fine...it can't be the fuel pump, it runs great unless it is hot weather. It has twice blown the P0171 system lean bank 1 code and has gone away after the tuneup and again after the new o2 sensor. It runs great, except in hot weather, starts surging and losing power...
View 9 RepliesSo I know there has been lots of posts on surging issues and how to troubleshoot. My truck is a 97 f150 4x4 xlt 4.6l v8. I have noticing surging and dropping in my RPMs lately. No CEL. I have kept a journal when I notice when it happens. I only have issues when I am driving around 40-50 mph and if I go over bumps/pot holes/rough spots in roads or when I'm braking over bumps/pot holes/rough spots, my truck surges/RPMs drop CEL flashes on and off only during these instances. Makes me think something could be loose or something causing this. It has stalled at times when having to brake fast (yellow light, etc.). Where to look first? 1997 F150 4x4 4.6 V8...
View 1 Replies'1999 F150, 5.4L, 85K miles ....
Fuel pump failed last year, had it replaced. Ran fine for a week or 2, then one day went into limp-home mode. Mech replace fuel pump relay, again ran fine for a month or so. Now when the ambient temp gets above 80F or so (yeah, it has already this year - I'm in Central TX), engine at full op temp, I'm experiencing some sort of heat-soak issue. Engine runs fine when cold, and at normal op temps on the road, but if it is parked for 15 - 20 minutes then restarted, the idle goes all funky - nearly dies, surges, etc. for a minute or 2, and then it seems ok.
I would go back to the same mech, but he had to close his shop due to health issues, so I'd like to see if I can resolve this. So, it is definitely heat-triggered, and "seems" like a fuel issue, but of course it could be some electrical contact having difficulty above a certain temp.
I have a 99 7.3 with 40,000 on a rebuild,injectors I don't know they do pass a buzz test. What happens is when driving say at 30 mph and I am not needing to give it throttle but i don't back all the way off the peddle sort of at a neutral point my engine will sound rough and seems like its not hitting on all cylinders.it runs great when i give it fuel and idles fine its just the point in between it runs erratic.last year when chasing a no power problem. I did rebuild the ipr, new fuel filter, icp and harness,cps and what fixed it was new fuel pressure regulator (brass was gaulded and causing fuel pressure to crash). No mods other than a bullydog tuner that never goes past #2 setting. I do have a auto ingenuity scanner, what to look for or already know what my issue is.
View 14 RepliesI have a 2003 Ford Focus ZTS with a ZTec 4-cylinder motor, 5-speed manual transmission, @145K miles (one owner). I had the fuel pump replaced in October 2012. For the past couple of months I have had intermittent engine surges when the car is under load, and it is most prevalent when undergoing heavy acceleration or when going uphill. The engine idles smoothly at about 800-1000 rpm. The problem seems most prevalent when I have more than 1/2 tank of fuel in the vehicle.
I have noticed that when the car is in cruise control mode and surges occur the accelerator pedal depresses as if the engine is trying to get more fuel. Spark plugs, Timing belt, tensioner, and water pump were changed approximately 30K miles ago. Alternator replaced @10K miles ago. No visible leaks around the head or valve covers. Vehicle is driven mostly highway miles in low dust environments. Engine light normally doesn't come on, but today the surges were worse than normal and the engine light came on several times over approximately 1 minute interval. Then the surges stopped and the engine light went out and did not come back on.
I own a 2003 Ford F-450 Superduty Chassis w/Utility Body. Owned it for the last 2-1/2 years . So far, the only things needing replacement were an Alternator, FICM, and routine oil and transmission fluid as well as filters.
This past week the truck started lurching while in traffic. I brought it back to the shop and put the scanner on it, and found codes for #1,#3,#5 injectors imbalance and no circuit to the fan motor. Did some research and found low oil and/or dirty oil could affect the injectors, I changed the oil and all filters also removed the EGR and cleaned it too.
I started the truck ran it, stopped, and restarted and let it run for a few. I cleared the codes and did another test. The only code that came up was the Cooling fan P0528 again. I let the truck run. All of a sudden the truck revved up and I could hear the turbo kick in and the engine seemed to take a life of it's own. I did another round with the scanned and found codes for Cruise Control popping up P0565 through p0569 and the p0528 again along with a p1000.
My truck is not equipped with cruise control, but apparently that is what might be making the engine surge. What do I do? What this might be???
1999 F350 7.3 Super Duty surges when going uphill with a load. The only time we drive it is when towing the horse trailer - also has a camper on.
The truck doesn't physically surge, just the RPM gauge goes up and down and along with it a humming noise.
Also, What conditions should I engage the towing button on the end of the gear shift? I've heard several answers. Should it be engaged when towing or off?
I own a 2003 Hummer H2 with a 6.0 liter vortec engine with only 62,000 miles. At 50 to 55 mph 1500 to 2000 rpm the engine surges 300 to 400rpm with foot steady on the throttle. There is no engine light on and I,ve checked for codes with a code reader from the auto parts store. No error codes. I've cleaned the mass flow air sensor and throttle body with no change. My next thought was to replace the throttle actuator control sensor or accelerator pedal position sensor. I do enjoy working on my own vehicles so have been reluctant to take it into the shop.
View 1 RepliesI'm having a strange issue with my 2008 F350 6.4. I have only had this truck for about 2 months now. Every time it gets wet (from rain or a carwash), the 4x4 low light begins flashing, and the truck surges badly at low speeds. When I get above about 25 MPH, the light stops, and the truck runs normally. At the next stoplight, it happens all over again. After a couple days of dry time (?), the truck is back to normal (until it gets wet again). I have found a couple of old threads involving some similar symptoms, but they were never resolved on this forum (that I could find). I believe the transfer case selector motor has been replaced at some point, as it has a Dorman brand sticker on it. I wouldn't think Ford would use Dorman parts as original equipment.
View 4 RepliesWe have a 2003 Passat GLX, 43000 miles, V6, AWD. I've noticed recently that when driving at constant speed the engine will surge about once every second or two. It's very regular, and on a smooth road I can also notice a bump in the drive train, very similar to road bumps.
I've taken it to a dealer, since I believe it is a transmission issue, and therefor covered under warranty. There are no computer codes stored for faults in the transmission, they've said. However, they started by pursuing the fuel injection system (though no code was stored), and then wanted to fix a faulty coolant sensor (since found not to be faulty).
I have a 2003 Jeep Wrangler (4 cylinder) that seems to be having a fuel problem.... about a month ago, it started lurching, having a hard time starting, it would lose power on drives and once or twice it has stalled on me while I'm driving on the freeway. I've had to restart my car going 60 mph... if I feel it lurching or surging, I have been able to keep the car going by shifting into a lower gear or taking my foot off the gas.
I just took it into the dealership and spent 1300 to get it diagnosed and fixed. I got a new timing belt, and a whole bunch of other stuff and on the way out, it stalled at the first stop light. Although it seems to be running better, it obviously didn't fix the issue. I took it right back and now they are going to have me bring it back on Monday to 'try to figure it out’. Where should I tell them to look?
Oh, and - I had to get a short fixed from the ignition key (I was able to pull the key out while the car was running) and they fixed it. But now, I can't get any reception on my radio...
I have a 1999 toyota tacoma 70,000/mi. While idling, at random intervals, truck surges forward. Have to stay on the brake. Cannot drive in winter. Took to Toyota dealer and other mechanics... described problem and that A/C seems to be on all the time. No one has been able to fix. My brother disconnected the A/C and surging has stopped, but I need a better fix that will allow my using AC.
View 4 RepliesSo my 99 F150 never got great MPG, but at least she was between 12 and 14 pretty consistently. However, she's spent a lot of time sitting, and now the MPG is right at 8. 9 or higher would be shocking. Any guess as to why this is? I know that engines need to be run now and again, but I can't beat 20+ MPG in my car and 40+ on my motorcycle, so she sits. I try to take her out once a month for a good drive to get everything heated up and moving and to burn any condensation that got in the oil. She's got fresh oil (not even 500 miles and 6 months), clean air filter, and fresh plugs and wires. I've also treated the gas with Sta-Bil at the proper mixture.
View 1 RepliesWhere is the thermostat located on a 5.4 1999 engine.
View 1 Replies1999 F-150 Sport 4x4
So the deal is I had to use a slim jim to open up my truck door the other day. Door still locks/unlocks fine, only not with the key. Key will still fit & turn the barrel without any prob. just doesn't engage the lock. Took the door panel off and it looks as if the Rod that connects the inside of the key barrel to the lower (part)? not familiar w/name. has come loose.
Looking for a diagram/picture of how it should look to get everything put back together so the key'll work again. Sucks unlocking passenger side and climbing over to open driver door.
1999 f250 ld, 5.4.
Started running rough, checked codes. Initially got po300, po304. Reset, and when I checked again, had po171.
Checked the PCV lines, and found a split right near the throttle body. Of course. broke the plastic tube trying to pull it off. Replaced the short piece of hose with a longer piece to make up for the broken plastic tube.
Now, po171 is gone, but the others remain.
Cylinder # 4 looks impossible to get to. I would like to swap COPs to see if the code moves.
A. does this make sense?
B. how the hell to I get back there?
At a minimum, it looks like I have to disconnect a bunch of hoses, and maybe even remove the fuel rail.
1999 F150. The truck is a 4X4 supercab, with the 4.6 motor, 141,000 mi. During cold weather it runs great, but as soon as the temp gets into the upper 70's or higher I have a recurring problem. The truck starts right up and runs well, but when it is shut off it will not restart until it has sat for over an hour. It has also stalled at speed on the freeway when the outside temp was in the upper 90's to low 100's.
So far it has always restarted after sitting for awhile. I took it to the dealer and they kept it for 3 days, but could not duplicate the problem and found no codes in the computer. I replaced both coils, but it is still not starting after shut down when hot. My next thought is to change the PCM, but that is a big chunk of change to be guessing about.