Ford - Explorer :: 2003 - Vibration When Turning?
Feb 1, 2009
What may be wrong with my 03 4wd Explorer. I think I actually might have had two problems, one of which is now fixed.
When I turn in my Explorer from a dead stop, either left or right, there is a vibration that seems like it is in the steering or front wheels. It seemed to get worse over time and I ended up replacing my bearing assemblies which were in fact bad. It may be possible that they went bad because the problem I can't identify messed them up, I don't know.
What I do know is that the longer I drive the car on a trip, the worse the vibration becomes. After 50 miles or so when things are good and heated up, it's really noticeable when you turn at a stop light or in a parking lot or something.
I have new tires, it's in alignment, the tie rod ends and ball joints are tight, and like I said, I've got new bearing assemblies. I looked over everything real good when I had it apart. Power Steering fluid is full too. The transmission fluid has been recently changed, and I did my front and rear diff fluids and transfer case at 100K (I'm at 115K now).
View 7 Replies
Advertisement
I have a 04 explorer limited awd and I get bad vibration when i come to a stop and turning left or right but it don't do it when I stop and drive straight, I feel it in the drive train, what's wrong?
View 1 Replies
I own a 2003 Explorer, 4.0 v6, w/93k. When turning either direction from a stop I get a shudder from the rear end. Ford has issue tsb # 17717 but I cannot fix the fix, only a description of the problem. Where can I find a fix I wondered?
View 2 Replies
81,000 miles on it and starting last week I began to get a vibration at highway speeds. The vibration is both in the seats and the steering wheel, though it feels more so from the front end. HOWEVER, I already have had: both front lower ball joints replaced, the front axle replaced, the tires rotated AND aligned AND balanced, and a missing sway bar link replaced. Why it still vibrates. My mechanics (yes I tries 2 places) can't get it right.
View 4 Replies
I just bought a 2010 Explorer XLT on Saturday with 7,200 miles on it. Everything is great on it, but we noticed a vibration at about 60 -70 mph. Im thinking/hoping tires might need balancing. It does semm to subside a little when slight turn to the left and increase when sight turning to the right (like lane changes). Were/are there problems with the auto 4wd and the sensors? This is still under warrenty until 4/13, but tire balancing is not covered under warrenty. I'm taking it back to the dealer today under the 30 day warrenty that they offer, but they seemed really cool as far as if you just bought it and it vibrates, we will fix it. They say and have so far want us to be totally satisfied. I hate dealing with car dealers worse than going to the dentist, but this was a relatively pleasant experience. Let me know what you all think. I told the wife we were getting a brand new 2010 Explorer and she said that didn't make sense. I said with 7,000 mile on it it was like a brand new car. We need to get rid of the vibration now.
View 6 Replies
I just got a 1995 explorer from my father in law... I have noticed a vibration from 55 to 60 cannot figure it out.. What might be causing it? It is my daily driver to work...
View 1 Replies
I have a 2002 ford explore 4.0 sport 4wd. I have a problem with my car, one day I tried starting the car and it didn't want to start. So i replaced the fuel filter and the car started. then after starting it a few times it didn't want to start anymore, so i took of the fuel tank (thinking bad gas, and there was stuff in the gas) so i take out the old gas out and put new gas, and bought a new fuel pump and filter, and when i put the gas tank back on the car, it still didnt want to start, so i take the fuel pump and find a random battery and connected it to the fuel pump and the pump spins so it works. I connected the pump to the car by itself not it the fuel tank (from underneath the car) and i was under the car to see if the pump turns on and someone tuned the car on, and the pump doesn't turn on (doesn't spin or anything). Long Story short, what i should do? Also I was looking for the fuel pump fuse and couldn't find it (thinking it might be the fuse) what is the fuse number or where its located.. i know where the fuel pump relay is, but just not the fuse. Why the pump wouldn't turned on??? The pic is how my fuse box looks like(there are many different version of the fuse box just wanted to show you how mine looks)...
View 11 Replies
I'm having a problem with my wife's '08 Explorer, 4.6L, 4x4. Recently she started getting a weird vibration while driving. I took it out and noticed the following: The vibration sounds and feels like you are driving over rumble-strips. It doesn't increase or decrease with speed. You can't feel it in the steering or brakes. It goes for 2 seconds, stops , 2 seconds, and stops.
This will happen every 7-10 minutes while driving. It doesn't matter if it's under load, or just coasting. I did notice while it is happening that the tach jumps up about 200 rpm for a second and then back to normal. I've searched and found it could be a possible torque converter issue, or even a bad coil. Where to start looking?
View 7 Replies
I have a 2002 Ford Explorer. For about the last year some of the dash lights have been turning on and off randomly and intermittently. The three lights are the check engine, the airbag and less frequently, the check gauge light. It seems like there's some connection between the lights because often when one comes on so does another and often one will turn off, but immediately another will turn on. My mechanic (not a Ford dealer) tried to fix the check engine light by diagnosing and fixing the indicated codes, but a day later the light came back on. It stayed on for a week, then one morning it stayed off, but the airbag light came on. Is there some electronic (or other) component that links these three lights and could be causing this situation?
View 1 Replies
I have a 2004 Ford Explorer V8 4w drive. I have two problems that I'm trying to figure out, first problem is that my ABS light comes on, mainly when I quickly hit the gas while turning the wheel(such as passing a car). When I turn the truck off and back on, the light goes off, and stays off till the next time I pass a car or what ever.
Second problem is my cruise control, it sometimes works, and sometimes doesn't. I don't know why. One thing that I did notice is that if the cruise isn't working, it'll sometimes start working again after I bring the truck to a full stop.
I get a dtc code C1440 Preasure Transducer Main Primary Signal Faulted.
View 2 Replies
I am getting a vibration when I lift off of the throttle and again when I press the throttle. What causes this. Also what is the normal operation of the 4x4 system is this a true all wheel drive system with a 2 speed t-case or is this the normal old control trac that I had in my 98 4.0.
View 4 Replies
Before I take my dads truck to the mechanic. He noticed a "noise" when running highway speeds, which does not occur often for his truck..a beautiful 2005 Eddie Bauer Explorer with the 5.0 V8. I need this checked as I drag a boat to the Fl Keys from NJ in 3 weeks and the truck needs to be 100%. He just replaced the tires as his mechanic told him it was tire whine, which you hear and dont feel. The wheel bearings have been replaced in the last 2 years and they just did ball joints. I drove it up the highway tonight and felt it right at 62 mph..go faster it got more pronounced and you could feel it in the drivers seat...not vibration on the steering wheel..above 85 and it kind of smoothed out, drop below 62 and it goes away..makes no difference if you are in the gas or not..feels like something spinning out of balance....I ran it for 30 minutes at 75 and then pulled into a Lowes parking lot and drove one set of tires up onto a curb so I could fit under the truck..I started at the back and touched everything in the drivetrain for see if anything was hot..the rear differential was warm, the ujoints were not, the transfer case was warm as was the front differential, but none of the u joints or cv joints were warm... 2005 Explorer 100,000k miles...
View 12 Replies
I recently purchased an 04 Mountaineer with 95k miles on it, there's a slight shudder or vibration when i start out from a stop, turning, reversing all at a slow speed of under 10 mph, there is no other issues after i get up to cruising speed above 10mph.
I had the front and rear differential fluids changed, the transfer case fluid changed, and transmission fluid changed.
View 13 Replies
I have a high speed vibration from 58+ ... 4x4 drivers rear cvjoint bad? The U joints are good, I had the Diff rebuilt due to bad bearing about 1000 miles ago. I guessing its the Cv joint do to grease is all over around the joint. How does one check the cv joint?
View 1 Replies
I've got a 1993 ford aerostar. Today, my steering wheel started shaking/rattling when I turn the steering wheel. Seems to be more obvious when turning right rather than left, and is only obvious at low speeds.
Only thing out of usual was that the front had been on jacks for a few days for an unrelated (starter) repair. What to check or how to isolate? I imagine it has to do with the power steering but not sure what to check.
View 6 Replies
I have a 1997 Ford Explorer. Starting about 4 months ago I have had intermittent problems with it not wanting to start.When you turn the key the radio and dome lights etc. come on but it is dead silence from the motor.First time it happened we ended up replacing the starter solenoid. Next time we discovered that if you "jump" the 2 posts on the solenoid (using well insulated rubber handled pliers) while turning the ignition it will start every time.Took it to a local, reputable mechanic - he is baffled. They looked at every connection and wire they could think of.It is not the battery or solenoid, as best we can tell. It does not do it all the time. It will ocur, then it will start fine for 2 weeks then happen 3 times in a row, then not happenf for say another week or two.
View 7 Replies
Just replaced the tires and wheels on my 2005 EB Explorer. Purchased a set of Better aluminum wheels and tires on Craigslist. Problem is old ones had TPMS and new ones don't. I will put the sensors on the new wheels when the tires wear out, but don't feel like the expense until I need new tires. Is there an easy way to turn the system off so I don't get the message every time I start the vehicle?
View 8 Replies
I have a 2000 Ford Explorer XLT. V6, 4x4
At very low speeds (5-10 mph), attempting to accelerate while turning (like coming out of a parking lot OR out of a curve) the transmission fails to engage. I hit the gas, the RPMs go up, but it doesn't get into gear. I will let off the gas, give it a couple seconds, hit the gas again and usually it engages. Sometimes I will have to repeat this step a second time. This problem started very slowly and has gradually gotten worse. It happens about once a day.
Concerned, I took it to the local Ford dealership and they have thus far changed/flushed the transmission fluid and replaced the filter. The mechanic said he found no metal shavings in the fluid, which might indicate grinding gears. They also said there were no codes coming up pointing to a transmission problem. It is still having the same exact issue however. The trouble now is they cannot "verify" the problem. The mechanics have put 40+ miles on it in similar driving scenarios and it will not act up for them.
After a couple weeks of back-and-forth, I'm really frustrated. My understanding is that they're "not sure" it is a transmission problem. They don't really want to open up the transmission case until they have a place to start. It should either be something mechanical with the transmission or a problem with the computer that controls the transmission, right? After getting off the phone with the mechanic today he said it might be a sticky throttle body?
View 14 Replies
Happened two times already if i press gas when turning 90 degrees. My engine stops and i have to start car again, why could this be happening?
I got misfire cylinder 4 and 6 perhaps its related however i am trying to understand dynamics of things why engine only stops under this conditions?
View 1 Replies
I have some big time slop in my steering wheel, and what started as a type of binding when turning sometimes, is now really sloppy - almost dangerous
Is this the intermediate steering shaft? I just want to be 100% sure that I get the right thing before I buy it, as it's a dealer only part.
View 2 Replies
My truck is vibrating and shaking when you go over 30. but occasionally stops. I replaced the whole rear end, rear shocks, rear brakes, rear drive shaft U- joints, rebalanced the rear tires( they needed that). at least that fixed the noise (grinding) from the rear end is gone but it is still vibrating.. Over $700 in it this week. at least i did the repairs myself and saved a bunch of money. But i am now stumped... I dont know it if is front end issues, transfer case issues, transmission issues....
View 4 Replies
