Ford - Explorer :: 2002 - Won't Start / Crank Till Battery Dies But Is Not Getting Fuel
Nov 7, 2016
I've got a 2002 Ford Sports Trac that won't start ! It will crank till battery dies but is not getting fuel. I have had it towed 4 times in the past year. of the 4 times,this last time it wont start. Every time that I have had it towed back to my house and dropped in the driveway it has started up with no problems. It will run for a few months or more.This last time it would not.
Could this be an electrical problem.Maybe loose ground somewhere or something else. Would like to rule out some things before investing in a fuel filter or fuel pump. Would hate to buy new FuelPump and that not be the problem. Can't find free wiring diaghrams for this issue.
View 3 Replies
Advertisement
1997 Jimmy, 4.3 ... This has gone on for two years and over two grand. I am slowly going insane. When it starts, it runs GREAT...but if it is moist outside, it is not going to happen...can crank it til the battery dies. I have replaced: spark plugs, fuel pump, MAF Sensor, distributor cap and rotor, stupid poppet fuel injection, battery x 2, and the ignition switch. It used to pull a random misfire code, but now has NO codes. I have been through five garages and four really good at home mechanics. When it is not starting, it has spark at the plugs and good fuel pressure. Last mechanic wanted to do a second fuel pump with the new injection system...I swear I think it is because I am a girl.
View 15 Replies
I've been working on this explorer for a week now and I figured it's time to ask around. My explorer won't start/crank, I've replaced the starter, battery terminals, tested voltages/amps/relays and fuses, still nothing. All i get is a heavy clunk, like the starter is engaging but the flexplate won't budge. It's a 2002 4.0 xlt automatic.
I'm fearing the engine is seized as I've tried manually turning the engine with a socket on the crank pulley bolt and even with a breaker bar I can't get it to move. The thing ran fine a week ago and I can't imagine this thing would seize at barely over 100k miles, not hydrolocked or anything I can think of, are these engines prone for spontaneous seizure or am I missing something?
View 14 Replies
I have a 2002 Explorer. Front right howls. Local shop put new tires on, said wheel bearings are good, it Starts to howl at about 10 mph & keeps howling up to hi-way speed. While driving 55 cornering makes steering wheel vibrate a little, then straight it just howls. I have put on over 15,000 miles while this noise is happening. now seems to be getting worse...
View 1 Replies
I have an 04 Ford Explorer XLT 4.0 Flex Fuel. There has been loss of power to fuel pump. Relay and fuse both good, replaced the inertia switch...still nothing. Could a FPDM (fuel pump driver module) have anything to do with this issue? Or what should I check next? I am definitely at a loss as to what the issue could be! I know it is fuel related because I used starting fluid and it started right up and run for just a few seconds, so that should rule out ignition I think.
View 3 Replies
Sometimes after running my 94 Limited, it doesn't want to start - it does crank - like it's not getting fuel. I have found the work around and want to know if it would be fixed by replacing the fuel pump relay.
The symptom is just after starting, it starts to run poorly, and then dies out, then will not start at all. I use to keep trying to start it for 20-40 minutes and suddenly it seemed to work.
It seems the work around is to turn the key to on for about 5 seconds and then turn it off - then it starts and runs as good as ever.
So, is this a symptom of a bad relay? I thought I'd start there because of the cost of the relay is fairly cheap. 1994 Explorer Limited 4x4?
View 14 Replies
So my 2002 ford explorer with the 4.0 L V6, has been cranking along time before it starts. I thought i had this figured out already, i put a brand new fuel pump in it from the ford dealer. That seemed to work, but the problem came back.
Especially when it is cold, it cranks a lot longer than normal to start. and when it does start RMPS go way up briefly and come back down. Seems to only act up when its cold out, say 35 degrees and lower.
So the remote start wont work because it only cranks for a few seconds and then stops. it tries this three times and it gives up. i go out there to start it and cranks for 10 seconds it seems like, sometimes i have to feather the fuel pedal.
View 7 Replies
Black Beauty finally gave up. Replaced battery, replaced fuel pump relay. Would only run with starter fluid sprayed into the air intake. She'll crank but not start. Here she sits at the dealership.
View 14 Replies
1995 Ford Explorer, 4 ltr. engine, pushrod. Will not start. Replaced fuel pump, fuel filter, every relay, pressure regulator, and the crank position sensor. I realize there's a whole bunch more parts under the hood, but I am ready to give up. Before the fuel pump would not run. Reason for replacing the parts. Now it won't stop running and you can feel the fuel by-passing at the pressure regulator. When checking the pressure at the rail I get zero !! I used a tire pressure tester for this. And, like I said no pressure. This vehicle has around 170,000 miles on it.
View 8 Replies
My parent's bought a 2002 Explorer 4.0 V6 very early, either late '01 or early '02 when it first came out. Besides the dash blackout (which I found a fix for, need to do) it's been plauged latley (since Nov/Dec 2010) with the intermittent issue of when... You turn the key on to start, you dont hear the fuel pump enguage, thus no start. Get towed, it works like a champ.
It's blown a fuse 1 or 2 times cause of this, had the fuel pump recently replaced (dec/jan this year) and just did it again. Our local Ford dealership figured the fuel pump went bad from sitting, the vehicle only has about 33k miles on it (dad dont drive much). What appears to be a bad fuel pump, only to have it get towed, or sit overnight and start like nothing ever happened?
Dad's ranting about not trusting the vehicle anymore, he's 80yrs old so I can't blame him for wanting to feel comfortable with knowing his vehicle should start, but it is a machine, they do break but we cant seem to get this fixed.
View 14 Replies
I just got delivered a 7.3L from down south. Batteries were dead so replaced both. Fuel was a couple notches above red line (much closer to red line than 1/4 tank) so I added about 7-8 gallons.
It will crank forever and ever...Won't start.
With starter fluid it starts but not strong enough to pump the pedal and rev it up to keep it idling.
I know s-fluid is bad but if I continuously spray with key turned forward it will run but as soon as I let go of key it shuts off.
20 degree weather and it was delivered to a parking lot so I cannot plug it in.
Was told to check filter cap, turn key, and see if it fills bowl with fuel....if not then it is fuel pump. Someone else mentioned that it could be bad crank position sensor? Does this sound like fuel pump?
View 2 Replies
2002 explorer 4.0l. No crank just click new starter in and cables hooked to battery...
View 1 Replies
Kids called and said the battery was dead, truck would not crank over. 2002 EXP 4 L. Drove 90 miles and checked battery to be o.k. Changed out with my truck to double test... no crank. Decided the starter must be bad. Banged on it with a long pipe from above - no start.
Winched onto a trailer and brought it 90 miles home. Winched it off and pulled to the garage. Looking from above i looks like this is a straight forward solenoid / starter / hot wire to the battery. No switches/ etc in between. Though i would try it one more time ... clicked key on and off 3 times and truck started on the 4th turn.
Tried it 6 times over 2 minutes and it started every time.. I am thinking the starter and solenoid don't owe me much after 11 years and 165k miles. Plan to check the cable and ends also.... Just wondering an specific known problem with the starter / cables before i jump in.
View 5 Replies
248k miles on it, was taken from a body shop and put on side of road, I know who took it but can't prove it. He is known for messing with ppl vehicles. . Started up just fine when found, but you can hold foot completely down on gas and it's like it is losing pressure (?) , it rumbles and shakes when running and you can watch the RPMS fall while holding gas pedal down (in park) until it just dies. It has an "egg" smell and one side will get hot while the other stays cold. It was something intentionally done to my vehicle. .already checked Cadillac converter and cleaned/removed muffler. I'm not sure where to start looking now, I'm a single mother without the money to take it to a repair shop. We could drive it onto the trailer to get it to a friend house, but barely made it up it without dying...
View 9 Replies
2001 Celica, battery dead after seeming to crank more slowly each time it was started during the day (wife was driving). I disconnected the battery to charge/test it, after reconnecting it started immediately but after 1-2 seconds engine dies. RPMs can be coaxed up to 3,000 in that time, but even though it seems to be running fine it shuts completely off, no coughing or sputtering. Won't start at all unless key is turned off and then back on, then it will do the same as described above.
It's giving a P1300 Igniter Circuit Malfunction No. 1 error code. Possible causes listed are:
- Ignition Coil No. 1 harness is open or shorted
- Ignition Coil No. 1 circuit poor electrical connection
- Faulty Ignition Coil No. 1
- Faulty Engine Control Module (ECM)
Seems to me a lot like the last, the ECM.
View 2 Replies
what part is causing car to be unable to idle without me keeping my foot on gas till it's warmed up in morning? It does not act like that at lunchtime & 5pm no matter what the temp gauge reads when I get in it at lunchtime & 5pm: at those times, it just cranks and stays on till I shut it off.
View 1 Replies
I have a 1999 Ford Explorer that when it starts in the morning sounds like a tractor and stalls out till it warms up after 5-10 minutes. This is of course wasting gas and I've replaced spark plugs and wires and 2 oxygen sensors. After the truck warms up it runs fine but it's very frustrating in the morning and good that I have a strong battery-check engine light is on-what could be the problem?
View 2 Replies
We have a 94 ford explorer and every now and again it has issues on the start up. It will sound like it will want to crank over but just won't. If we wait 20 mins it will start up no problem. We have changed the fuel pump, fuel filter, ignition coil, and fuel pump relay but it still has this problem. Also occasionally the a/c blower wont turn on. Tonight it happened again and I pulled the fuel pump relay out and it was really hot, after it cooled down and was put back in the car started. I am beginning to think it maybe an overheating issue that is affecting the relays but am not sure. I was also wondering about changing out the relay box...
View 6 Replies
I have an Explorer Sport 2001 that will not crank nor start. I have replaced the following:
Crankshaft, camshaft sensors
Ignition coil
Ignition switch, neutral safety switch
Fuel filter
Fuel pump
Starter
The battery is less than 6 months old .. Still, the car will not crank, will not start. I have spark, voltage and fuel.
The PCM does NOT communicate with the scanner. I purchased a used PCM off of eBay. This one does communicate with a scanner and gives the following DTC codes:
P1120-- Throttle Position Sensor out of range
B1601-- Unprogrammed Pats Key
Since the car is in the Caribbean I can't tow it to a dealer.
View 2 Replies
I was driving my sport trac when it suddenly died on me. We are leaning toward the fuel pump. But is there any other causes for fuel to not get to the engine? We changed the fuel filter out already...
View 4 Replies
2002 X w/ V10..
Drove to walmart the other day. Ran Great. Put a new battery in my spare key and tried it but anti-theft light came on. thought maybe battery was in backwards so turned it around and tried again still nothing. So tried original key and would not start. It would crank but not fire. (found a post stating that it was part of the anti-theft system to keep from just trying different keys) I let it sit for a little while and it started.
Drove home put new locking hubs in the front and took it for a drive. Started fine. Wife the next day went to work with it ran great. When she went to leave, it would not start. after about an hour it started for her and drove home with out issue. Next day I went out and it started for me first try. Then it started to just crank and never fire. After a while it started and I was able to start it a couple of times with out a problem then it stopped again. Since then I have not been able to get it to start.
I say I have no spark only cause I have tried to use starting fluid to at least get it to fire but nothing.. It doesn't sound like the fuel pump is kicking in either. Is there something that would shut these systems down that I am over looking..
View 10 Replies
