Ford Excursion :: Water Pump Leak Again - Gasket Deteriorated / Cracked?
Nov 2, 2016
I replaced my water pump on my 2000 Excursion 7.3 about six months ago because it was leaking from the little hole underneath. Everything was fine until today I noticed a big stain on my driveway under the front of the truck. I took a look and the new pump is leaking. It seems to be coming from the the back of the water pump where it sits flush against the engine.
Could the gasket have deteriorated or cracked? I bough it from a local parts store called part source, so it should be under warranty. Any thoughts?
View 8 Replies
Advertisement
Ok so my car kept overheating and I saw I had a small leak from the gasket on the water pump. I replaced the water pump and gasket but then it would zoom straight to overheating. I then assumed it was a stuck thermostat and replaced the OEM with a fail-safe thermostat. After topping off fluid and leaving the radiator cap off until I saw fluid running through it took it for a drive. The temp began to climb to overheating but dropped just as it was getting to the red and then began to fluctuate. Finally heat came through the car climate system and all was good until I had to come to a stop. It seems that whenever I have to stop at a light the temperature rises to overheating.
View 9 Replies
Recently, I bought a new-to-me 1994 Jaguar XJ6 which had a small laundry list of things that needed work. Amongst them was to have the waterpump and belt replaced. Long story short, after getting it back from the shop (I'm a repeat customer) and 50 miles down the road, I checked things out under the hood. I saw that there was a small bit of coolant sitting on top of the pump where the mating surfaces meet. It appeared that was some weeping from the gasket. I'm a little perplexed because this shop hasn't done wrong by me before, but there's a first time for everything. Is it possible that the cold weather in North Dakota (routinely -10) is a factor? It doesn't appear to be a catastrophic leak by any means, but I intend to keep my eye on in it. In the mean time, I made sure the bolts nearest the leak were adequately tight and put some red RTV sealant where it was leaking. Is it possible this problem will "go away" or do I have to try to shake down the shop and get them to re-check it/fix it? Frankly, I'd rather not have to deal with them again, but I paid them good money to get it fixed.
View 6 Replies
Just did a tear out and rebuild, installed motor, filled with water. Water is leaking out of the back of the engine somewhere. Leaking as if it were coming out of a 1/4" diameter hole. 1997 V4.6L F150. I guess I have to pull it no matter what. Cracked block? Freeze plugs were all new and installed by machine shop. Initial reason for pulling was water in cylinders and I assumed blow head gasket.
View 1 Replies
I thought I needed a head kit my truck runs and drives great till I run out of coolant no smoke doesn't get hot I run out of coolant I lose my turbo. Pull over fill it up I'm back to normal I just noticed I have sweat marks on my water pump pulley.
View 6 Replies
I was surprised by a leak and identified where the water was coming from, the bottom of my vehicle. It's from a gasket or seal on the front of the pan near the flywheel. 1994 Ford Explorer 4X4.
View 6 Replies
Recently bought a 2001. In the process of reading about this engine I discovered there is a some what regular breakdown of head gaskets causing water to leak into cylinders and oil pan, all of which is serious.
Given the vehicle is 12 years old and has 89K miles it appears it is in the age and range of where this leakage can occur. Any knowledgeable engine rebuilders that are familiar with this issue on the 4.2 have any comments???
1. Can this issue be avoided by replacing head gaskets now rather than waiting for future failure???
2. Are there new and improved head gaskets for this motor???
3. Does the problem occur on both heads gaskets?
4. Is that all that needs to be done or are there other seals that need replacement???
View 9 Replies
OK, we have a cavalier that is slowly dying but until we find a good price on a used car we are looking at it has to keep chugging along... It started to overheat about month ago, just when you go up a hill otherwise it is fine (doesn't overheat but a few lines from the red zone!). Mechanic said it was a head gasket and we have noticed that the coolant level is down slightly... can it be a head gasket yet still drivable? Also about 2 months ago the car needed a new water pump, flushed and filled, could it just be the new water pump was bad? No other issues, heat works fine, no puddles under the car etc....
View 14 Replies
We have a 2005 4runner with 75,000 miles that we recently took to the dealer because the coolant level was low. Turns out we need a new timing case cover, oil gasket, and water pump.Question 1 - is this normal to happen on a 2005 4runner with 75,000Question 2 - How much is a reasonable amount to pay for this repair? Evidently, it is a laborious repair.
View 4 Replies
I borrowed a friends 2000 Excursion with the Triton V10, along with his 3300lb, 28' trailer to tow a car from Ashland, OR to Reno, NV to begin a restoration project. His Excursion has 175,000 miles on it and made the trip down flawlessly, but as they say, "No good deed goes unpunished." When attempting to return last Sunday, had to turn around due to overheating problems. Analysis at a local automotive shop concluded a bad radiator cap. Attempted the return trip Tuesday and the same thing happened (only got farther due to the new cap and ability to hold pressure longer).
Finally got into a Ford dealer and have been informed that the truck has a bad head gasket causing pressure to leak into the cooling system. They suggest replacement of with a remanufactureded engine as opposed to replacing head gaskets, due to the time on the entire engine (who knows what else might be bad?). The vehicle can be driven around town for miles with no problems. But put that heavy load on it and grades and it spews out nearly "all" of the coolant.
View 9 Replies
I have a 1990 legacy and just replaced the water pump gasket and now it is leaking out of an upper bolt head on the pump and how to cure this....
View 1 Replies
Was heading to the coast to do some camping this last weekend. Overheated on the way, limped back to a safe parking lot to wait for a tow truck. Lost a bunch of coolant out the pressure cap, filled back up with water while I slowly pulled back into town.
View 14 Replies
1994 - 3.0 .... Back behind the water pump there is a stream of coolant what could that be. Water pump has been replaced earlier last year I thought that fixed it,there has always been a mystery leak..
View 6 Replies
I came out of work to see a fair amount of fluid on the ground under my excursion (2000 limited 7.3l 4x4). So I checked my fluids and found the coolant low and all the other fluids were good,. I had some in the excursion (not sure why I had it but it was there ). Filled it as much as I could started the truck and there it was a pretty big leak from my water pump. I was able to get one (new one lifetime warranty from an auto parts place, Ford was closed) so now on my day off instead of relaxing I will be installing a water pump. I guess it was about time. I figured since I was there I might as well flush the system. How many gallons of coolant this will take to refill the whole system?
View 7 Replies
My 92 Explorer 4WD has a coolant leak somewhere at the front of the engine above the water pump. I assume it's the lower intake manifold gasket leaking. The engine has 170k miles. I'm also seeing a small amount of white smoke, possibly steam when the engine is running. It's somewhat heavy when I start it up but mostly goes away once warm, so I suppose it could be steam, but could be coolant from either a head gasket leak or lower intake leak.
I also get a lot of water from the exhaust dripping on to the floor and the smell of the exhaust could be that of coolant, it's hard to tell. There is no coolant in the oil. I was wondering if I should go ahead and change the head gaskets while I have the intake out. Is there anyway to be certain the head gaskets are fine? I'd hate to change the intake gasket to find out there's a small leak in one of the head gaskets.
One other thing: I failed emissions because my CO was too high, but my HC and NOx were very low. Could this be an indication of coolant entering the combustion chamber? Just wondering why my CO was so high yet everything else passed (Massachusetts emissions).
View 8 Replies
One last issue with my 2000 B3000 3.0L. The leak seems to be on the left (passenger) side of the water pump very near where the bottom radiator hose connects to it. I can't find any loose bolts. It does not leak while driving the truck or soon after. It has to sit for several hours or overnight before it shows up. There are usually 3 or 4 wet spots where it drips from the water pump to the frame to the driveway. It is small enough that I only have to fill up my coolant tank every 1 or 2 months. Could this just be a small gasket leak? It's been happening for about a year or so I think. I replaced the radiator about 2 years ago. I've been expecting it to get worse or bust loose and have been checking it very often. I've never seen one not leak while running like this-has me puzzled.
View 6 Replies
Noticed about a gallon of coolant on my floor the last 4 days. Got it pressure tested and was told bad water pump. Had it changed with timing belt and tensioners. Got home, next day, same thing. Coolant everywhere. Also, do I really need to put G12++ in as coolant? I've been using it but the shop put some green stuff in it.
I have a 2005, V8, Phaeton with 181,000 miles. Also, my car overheated, got the coolant too hot warning, 270 on gauge, let it sit 5 minutes, no problem afterwards. Should the thermostat have been changed also?
View 3 Replies
Every time it rains I get a wet spot in the far left corner by the spare tire. Am I looking at a new seal or is this a trait with a different fix.
View 14 Replies
I have a 2004 Excursion 4x4 with only 85k. miles on it. My problem is that there is a water leak on the drivers side, either around the windshield or door weather strip. I say weather strip, because when I opened the door this morning, after a very heavy rain last night, there was some moisture on the inside of the door where the seal should have stopped it. My wife saw water on the emergency break pedal, and has felt a couple drops on her foot.
This is my second EX with the same problem, except the first one, a 2000 model, was much worse. It was leaking down on the GEM and fuse box. Replacing the windshield did not even slow the leak down. After several attempts to fix the problem with no luck, I decided to sell. I don't want to sell this one, but if I can't fix the leak before the electrical problems start, I won't have a choice.
View 9 Replies
So the water pump on my early 99 (158k miles) is starting to leak just sitting in the driveway, did a little research last night and read a few write ups. Just wondering if any tips or tricks I could use to make this go easier. Also any list of parts I should replace and/or might need. I read on one write up about replacing it with an Airtex water pump and was wondering about what people thought of those, I would rather fix it right then just go with the cheapest parts. Possibly there are better brand water pumps out there?
View 5 Replies
So I parked on an incline last night for ~an hour or so, and suddenly my coolant light came on and my reservoir was completely empty. Sure enough, all the coolant had leaked out of the car. I am sure it's the water pump, but it doesn't seem to be a complete failed one because I picked up and filled my car's reservoir back up today and it hasn't leaked at all.
My guess is the pump isn't bolted on right and on the incline, the gasket is breaking it's seal, or some oil dripped down onto it when on the incline and the gasket swelled.
Nonetheless, my dealership is covering it on Friday, and they said they finally are making them with metal housings instead of plastic, and recalls should be going out soon (win for the MKVI crowd).
View 2 Replies
