First time it acted up truck started after it cooled down , and several other times I had the same outcome, last week it left me stranded and now it won't start at all, Not getting any fuel...
View 14 RepliesOn a recent long drive home through some very hot weather, I noticed a strong smell of gas at the back of the truck. Now, I've caught a whiff of gas before the trip but it was always faint. Figured it was some gas that dripped on fill up.
At a rest area, I go and look around see no leaks and finally check the fuel cap. Lots of pressure trapped. I ended up leaving the cap off the rest of the run home. Can't find a cause.
I just bought the truck and the previous owner said sometimes when the truck is parked in an angle, like in a drive way it will not start unless you use a screw driver and touch both posts on the solenoid. It happened to me today and I do not like it and need to find the cause? Why it would do this?
View 9 Repliesthe wifey went out to the Ex this morning to make a coffee run and came right back in. "truck won't start" hands me the keys. So I go out there and turn key, ALL lights and power comes on but when you try and crank it there's a tiny 'click' and then NOTHING AT ALL. Alternator's brand new and so is the battery (less than 2 months old).
View 14 RepliesBeen having an odd problem with getting my truck to start. Pass couple of days I've gotten out from work and gone to start the truck. It cranks just fine but wont start, acts like there is no gas. Let it for a minute or two and try again and it will start right up and keep running with no other problems. Go to leave for the work the next day and the same issue. Weird thing is the problem only seems to happen when its cold out 30F so or below. I was thinking fuel pump but I'm not sure. What to check?
Edit Its a 2002 Excursion XLT with the gas 5.4
Having some problems with my truck.... First off I bought a 2002 excursion and drove it for one day. Then I was at the car wash cleaning up the truck. Then I saw the window fogging up so I turned the car off. Now it won't start.
I had previously installed a new stereo, but had some problems, so I ran the remote wire to the fuse box, because the wire in the harness wasn't getting power.. So after a little trouble shooting we found out that the fuel pump wasn't working or was bad.
We replaced it, now it has pressure but will not start, will start with starting fluid but will not crank on its own. someone told me it may be a bad PCM? and a dealer can only replace it... I don't have tons of cash, as i bought this truck on 8/30/12 and this happened the day after i bought it.
The previous owner has paid or the fuel pump replacing but I don't think its right on my part to have him pay more money as this may be a mess up on my part with hooking the radio up to the fuse box... we have tried the fuses,realys, crank sensors...
I ran out of CNG - truck won't start on reg fuel. Fuse good, relay clicking and I believe I have voltage going to plug connector going to tank. However, I do not have any wiring diagram to know what I'm looking for. The plug is four wire - yellow- 11 volts, red / black stripe 7 volts, black / red stripe and black wire no volts. What checks can I make before dropping the fuel tank and pulling fuel pump? 2003 F150 7700 Bi-fuel ....
View 6 RepliesBefore I left on Spring Break last week, truck wouldn't start. It was a Saturday morning, so I had it towed to the only open shop in town. He said the fuel pump was going out. He got it started maximizing the fuel pressure with his scan tool.
The unusual thing is I replaced the fuel pump (I have a V-10) earlier this year with a Motorcraft Pump from Amazon. I also replaced the fuel filter about 60,000 miles ago.
Does this sound right? I have never heard of turning up the pump with a scan tool.
It did fine over Spring Break, but is in my driveway right now refusing to start. I can't believe the fuel pump went out that quickly.
Does it sound like the fuel pump?
2000 7.3 Excursion. Truck ran fine on a 5 hour trip for family vacation. Pulled and to where we were going turn the truck off then what I had to do I came outside try to restart the truck for the next three days it would take 2 to 3 cranks before it was would start. Then on day number three tried six times and didn't start went to bed woke up the next morning and it took three cranks to start. drove it down to mechanic shop near me they have been troubleshooting and think it's an electrical issue the code is P1280; he said there were a couple other codes too and he would tell me what they were later but he never has. I took him a new CPS a new ICM and a new PCM, none of that fixed it. I am at my wits end here and really have to have my truck for work every day.
View 12 Replies2000 excursion V-10. I parked the truck, went back to start it and all my gauges blink, and the number one relay under the dash (interior light relay) begins clicking. The truck will not even crank. The relay will continue clicking (even with the key off) until you remove and replace the relay. Sometimes I will get absolutely nothing when I turn the key. I have tried jumping the battery, no change. Also tried starting it in neutral to trouble shoot the NSS, but it won't even click when in neutral. I checked battery connection, and followed the battery cables to look for a short but found nothing.
View 3 RepliesMy 2000 Excursion 7.3 Limited started something all new this week. No brake lights, signal lights or flashers. The signal flasher relay is only a couple months old, but I don't think that's the issue. If I sit for just a moment with door open or park lights on, the truck is too week to start. Batteries seem fine and ALT is 14 volt charging when running (ALT replaced with used ALT about a month ago). Further, it has started having long starts like the glow plugs are not cycling. Any clue as to what might be going on?
View 1 RepliesHow do you test the fuel pump regulator, the truck wont start. I tested the schrader valve and it does have pressure but didn't seem like much. (need a gauge) I replaced fuel pump a few years ago so was wondering about the regulator. Is there a test procedure?
View 7 RepliesI bought the truck now it won't start has to fuel at the fuel rail cranks but won't start when I spray starting fluid it starts but won't stay running....
View 1 RepliesMy truck is a 1990 Ford F150. It seems like when I let it sit for a few min that the gas just drains back into the tank and there for it wont start up that fast, it takes a while to get it going but when I shut it off and start it back up its like a new truck. It starts right up!!! Any tips on what might be wrong, maybe the gas cap is letting pressure out? Im 17 and my dad knows alot about trucks but he cant tell whats wrong.
View 1 RepliesAs in a previous post, i have been having issues with my truck starting then immediately dieing if i dont keep my foot on the gas.
Ive learned how to drive with 2 feet because of it, but I'm afraid i might be doing some type of damage since it keeps dieing and I have to keep starting it.
Once i get going for about 10-15 minutes its fine but its happening every time i start the truck.
Before it starts running correctly, it only idles around 400 rpm.
I think its the fuel pump, since my mechanic put a code scanner on there and it didn't throw any codes, he thinks it might be the fuel pump.
My question is, should i go with a ford pump from the dealer or are the ones sold from discount/o'reilly/napa just as good?
This has me puzzled to no end. After my son had put fuel in my truck it began to run rough, and had to be towed home, and now won't start. Now the first thing I thought was that he put regular gas in. But he was sure he had not ,and the receipt from the pump indicates diesel. It was hard starting before this happened.
1st Misfortune of having gas put in instead of diesel and did your vehicle run afterwards.
2nd Here are my readings from my scangage:
Sync Yes/1, Ficm main power 48.5 v, ICV .17 (2.01 when cranking). ICP 1572. IPR 50.7.
Checked upper fuel filter for bubbles, none.
Engine oil pressure comes up immediately on cranking.
Don't know what else to check, these readings look fine to me. Only the fuel is something I'm not 100% sure of. It does smell like diesel not gasoline.
I own a 2003 Limited with the 6.8 V10. I drove the truck on Sunday and all appeared to be fine, gas gauge was setting just under a half tank. When I went to start it yesterday, it would not start. Strong crank, no start. I checked my fuse and it was fine. Fast forward to this morning, since I had kind of depleted the battery with attempting to start, I put my little jump start pack on it and gave it a whirl. Truck started fine but the gas gauge was sitting on empty. I had five gallons of gas in the garage so I added that to the tank then drove to the local gas station to add more fuel. I put another 10 gallons in the tank so it should have roughly 16 or 17 gallons in the tank. Gauge shows 3/4 tank but miles to empty is right around 175 miles which would seem right with 17 gallons in the tank. I suspect the fuel pump. I don't really want to spend $500 on the Motorcraft unit but was wondering if the group believes the Delphi or the Bosch units are quality replacement parts?
View 7 RepliesI have a 2001 F-250 XLT 4x4 with V10. Truck will not start. No fuel pressure. My Haynes manual does not show ignition or fuel delivery wiring. I have found the relay box behind the radio/dash. I need a wiring diagram and info on which relay is the fuel pump relay. Want to know so I can jump relay to see if fuel pump is okay.
Truck had sat for a few weeks being ran very little, so had to jump start yesterday. Ran for about 15 min, the shut off, re-started and ran for 30 min. Truck sat for about 1.5 hours then would not start. Charged battery overnight and it is 100%.
Black Beauty finally gave up. Replaced battery, replaced fuel pump relay. Would only run with starter fluid sprayed into the air intake. She'll crank but not start. Here she sits at the dealership.
View 14 RepliesSometimes the check engine light comes on and truck will not start,the fuel pump runs non-stop.. when check engine light goes off,the fuel pump runs for a few seconds and stops,truck will start.... driving down the road check engine light will come on and truck runs bad....
View 2 RepliesThe truck just quit having any throttle control which seemed to be ignition. Way old stuff needed replacing so I went after that. Installed complete new distributer, coil and spark control module. No good. Found spark using checker but not sure what this should really look like. While checking compression found a lot of fuel coming out of number 6 cylinder and nothing out of any of the others. Compression in all cylinders is around 120. Distributor timing at number 1 TDC looks good. I am thinking some fuel system related issue but cannot figure out why so much fuel comes out of the number 6 cylinder.
View 3 Replies