Ford Excursion :: Strong Smell Of Gas At The Back Of The Truck / Fuel Tank Pressurizing
Jul 7, 2012
On a recent long drive home through some very hot weather, I noticed a strong smell of gas at the back of the truck. Now, I've caught a whiff of gas before the trip but it was always faint. Figured it was some gas that dripped on fill up.
At a rest area, I go and look around see no leaks and finally check the fuel cap. Lots of pressure trapped. I ended up leaving the cap off the rest of the run home. Can't find a cause.
View 5 Replies
Advertisement
I have an 01 6.8L v10 Limited 2wd with 143K. I have had it for about 3 months and have noticed a raw gas smell sometimes at the back of the vehicle. I come home from work, get out walk to the back and can smell it. Noticed it once or twice while at a stop light with windows down.
I have looked at some of the other post about this and eliminated some of the options , I think. There are not any trouble or pending codes when scanned. The gas mileage around town is about 13.5 mpg. Pulled all the spark plugs and they look good. Performance seems good to me being that I have only had it for a few months. Idle is smooth.
Smell is definitely from the rear / gas tank area. I have test driven it down the street and then start checking immediately without finding anything obvious. I do not see or smell anything under the hood. I have looked at the fill tubes and they are not wet or rusted. I have not seen any drips or wet areas looking around it immediately after driving. Just the raw fuel smell at the rear.
So I think it is something in, on or with the tank...?? Also can the metal skid plate/box be removed from around the tank without the tank itself dropping or is it all one big unit that drops down?
View 14 Replies
Yesterday afternoon, after a 90 minutes stop and go commute, a strong gas smell developed in the cabin of my 2009 LS460. The factory call-back service was performed on the car few months ago.
During yesterday's long commute, the LS460 passenger side wheels run over some garbage on the high way at high speed, and after that I can hear some noise from passenger side, sounds like a flag's flopping sound.
Other than that, recent incidents that I can think of that might be related are:
1. All 8 control arms of front wheels replaced about 3 weeks ago
2. Have been using Sam's Club premium 93 gas for the past 4 weeks
View 5 Replies
I have been smelling fuel on and off for the last few weeks. I thought it was the fuel bowl drain valve so I ordered the kit for the whole fuel bowl from diesel o-rings. I did the rebuild this morning and I don't see any visual leaks. Still smell a strong odor of diesel though. The lower engine cradle is all wet and the valley is still a little wet too. Could I still have a leak and if so where to look? Could it be just wet still from draining the fuel bowl and needs time to go away?
View 14 Replies
My vehicle:
1976 F150 2wd Extended cab
390 4bbl
c6 transmission
4BBL Edlebrock Carb
Dual fuel tanks, only rear main tank connected
My problem: For the first year I owned the truck, everything ran fine and it started up really quickly even after it sat for a few days or a few weeks. I have since, for about the last year or so, had to crank it for 30-45 seconds to get it to start. This all started around the time my fuel pump went out. I replaced it with an Airtex fuel pump from Autozone. I also installed a glass in line filter before the carb in front of the distributor.
I noticed that after about 4-6 hours, the fuel had drained out of the filter and that's when I would have to crank it forever to get it going. It also seems like there is no fuel in the carb as it doesn't even try to start when it first gets cranked. I thought this was a bad pump, so I bought a new one last week and tried it again. Sure enough after about 4-6 hours, everything is empty again and it takes forever to start it. So it's not a bad pump, or so I think.
The other day I backed it into my driveway and left it, something I never do. I checked about 4 days later and there was still fuel in the filter. This makes me think that gravity is making it drain back to the tank.
Is there something that would cause this? Also I have found a one way fuel check valve online that is supposed to remedy this type of problem. Do they work for this situation? Or is there something else I should be doing to fix this? It has taken a bit of a toll on my starting system having to crank so long all the time. I have so far had to replace my starter, starter solenoid, and all the battery cables, starter cable, terminals, etc. due to excessive wear.
The valve I found is here : [URL] .....
View 3 Replies
I just changed my fuel tank and now when I try to fill it up it keeps blowing back it never did this before.
View 2 Replies
Today while leaving work my car was giving off a strong fuel smell. Wife noticed the garage stunk of gasoline when she got home.
I removed the engine cover just now, and ran the car and checked for any leaks around the fuel rail area, but didn't notice anything.
View 14 Replies
So I had my sikky headers installed about 3 weeks ago by JE import. Since then they have been a constant hassle by installing a faulty O2 simulator which made me have to get in the car yet again drive to them an hour an a half away.
After another week I got CEL for a second time. After they fixed the faulty O2 sim....
Recently I have noticed a very strong fuel smell while driving. I understand you might get a fuel smell while at a light and the windows are down but I am experience one at cruising speed. I have gotten my car lifted three times in the past week to tighten the flanges connecting to the joeZ as well as checked for leaks (none were found) and there still is this strong smell
I do not want to install high flow cats.
View 12 Replies
I have a 2007 Hyundai Santa Fe with 83k on it. For some months now, I have always been smelling strong fuel scent in the cabin. I took it to the workshop and was told it's my fuel canister so i handed money to the Mechanic to buy one to replace it. He called back to tell me he cannot get one to but can work on it by blocking the pipes or lines. I am not that convinced because i know the canister is there for a purpose so if he goes ahead to block the pipe or whatever, then it means something else can go wrong in the interim; but I'm in a quandary now and want that fuel scent to stop.
View 1 Replies
I'm getting a strong fuel smell inside my car typically after i fill the tank regardless of how much i fuel i put in. What could be causing this?
View 4 Replies
My wife was driving to work today and she called me when she was almost to work and said that when she was at the red-light and said when she started from the red-light the car was fine and she hit a certain rpm and the rpm's dropped and there was a strong smell of fuel. The car was still running and would idle fine but was running almost like it was flooded or had a miss like a coil pack or spark plug. There was no check engine so I am not sure I haven't got to look at the car yet.
I forgot to mention a few months back she had a check engine for the intake manifold runner flap called the dealer and set up an appointment to take it in. Took it up and by the time we got there the check engine was off and car was running fine no issues. They said no sense in bringing it in now just set another appointment if it comes back on which it never has and still isn't on but I am wondering if this problem is related to that? I know for sure that the car is still covered under the enhanced warranty for the injectors and intake manifold.
View 6 Replies
Ok, 04 Passat, 1.8T AWM
CEL is on for po456 (very small evap leak) and every time I fill up on fuel, I can smell a STRONG fuel odor, from near the fuel neck, and inside the car. Stops after it hits around 3/4 area. No leaks, and the car runs fine. Gas cap, and N80 valve were just replaced, both parts are from the dealer. I'm going to bring it in for a smoke test soon. All recall notices have been done too, I just did the timing belt.
View 1 Replies
I have an Oct 2001 2.7 GLS which apart from the odd ABS Tone Wheel and speed sensor issues has been uber reliable and a real pleasure to own (I've had it from new).
We had a problem about a year ago when the wife didn't get the fuel cut-off when filling up and over filled the car resulting in fuel pouring out of the tank vent and down the fuel tank under the car but after a long drive that cleared up and has not happened again. Interestingly we didn't get any engine CEL's or have any codes turn up at all when checked by my mechanic.
Over the past couple of weeks we have noticed a very strong smell of fuel under the car around the fuel tank. I can't see any indication that there is a fuel leak but have noticed when filling up that the smell is very strong and as the car runs the fuel down the smell reduces to almost nothing.
Today I removed the rear seats and the fuel pump access panels to see if there was any seeping around the pump gaskets but couldn't see anything and the top of the tank around the both pumps was a dry as a bone. Using a torch I did however notice that there was a darkening of the fuel tank surface in the centre which I guess is close to the vent valve, part 311990b:
Or maybe is where the fuel vent pipe runs to?
View 2 Replies
I own a 2003 Limited with the 6.8 V10. I drove the truck on Sunday and all appeared to be fine, gas gauge was setting just under a half tank. When I went to start it yesterday, it would not start. Strong crank, no start. I checked my fuse and it was fine. Fast forward to this morning, since I had kind of depleted the battery with attempting to start, I put my little jump start pack on it and gave it a whirl. Truck started fine but the gas gauge was sitting on empty. I had five gallons of gas in the garage so I added that to the tank then drove to the local gas station to add more fuel. I put another 10 gallons in the tank so it should have roughly 16 or 17 gallons in the tank. Gauge shows 3/4 tank but miles to empty is right around 175 miles which would seem right with 17 gallons in the tank. I suspect the fuel pump. I don't really want to spend $500 on the Motorcraft unit but was wondering if the group believes the Delphi or the Bosch units are quality replacement parts?
View 7 Replies
My dad's Camry (which I also drive), has been having a problem since a couple of months now. Whenever I floor the vehicle, you can feel the power kick in but after a couple seconds you can feel a slightly lack of power. Its not like the car doesn't accelerates, but it does feels like if you release the pedal a bit.
The car also has the following issues:
-Shifting problems: The car has been having shifting problems due to the automatic transmission fluid temperature sensor (don't know if this may cause the ecu to go in some sort of "emergency mode" and reduce the power a bit)
-Strong fuel smell after driving: After some driving, you can smell fuel mainly at the back of the car.
I'm thinking in about changing the sparkplugs as we have never done it to the car. Car has 80.000km (50.000 miles) Car is a Toyota Camry 2007 V6 3.5 2GR-FE
View 8 Replies
I have a 2002 Oldsmobile Silhouette which has been a great car, but due to its age has had some issues in the past year. The most recent is that it does not start well. When I turn the key, it chugs but I have to push the gas to get it to start and then there is a very strong fuel smell. We had it "tuned up" recently, but that did not work ( in fact the starting has gotten worse).
View 1 Replies
03 Baja, 4cyl, automatic. 195,000+Every now and again I get a fuel smell. Full tank, empty tank, half a tank... doesn't seem to matter. Usually switching up the gas I put in clears the issue. This time, not so much. Really strong and causing me to banish the car for the garage due to it stinking up the house.The odor MAY be coming from the left/drivers side of the car. (I only say this as if it is outside in the parking lot, I notice it more on that side.
View 4 Replies
I am going to mount a second fuel tank on my excursion -- I have measured and build a simple cardboard model. even measurements that they have used in the past? I looked at the tanks on
[URL]
they don't have any specifically for the Excursion I am thinking that the shortbox 250/350's probably are too long for the excursion.
View 14 Replies
New to me 2003 F250 Super Cab 6.8 V10. Great condition inside and out. 68,000 miles. Began smelling fuel (gas) a few days after driving it 250 miles from purchase location. Traced leak down to the top of the gas tank. Staining was visible around the rear vent. Applied about 5 psi to the tank and sprayed soap around until I saw bubbles coming from a hairline crack at the rear vent connection. Its where the fitting for the hose comes out of the tank.
My first choice would be to hot weld the crack. I'm not very comfortable with the idea of a heat source near a gas tank. I'm not sure, but the heat from the plastic welder might be hot enough to ignite fumes? Second option is to try some industrial 2 part epoxy (PIG) and seal it with that. Is there pressure inside the tank, and if so how much? Can try this fix with epoxy or JB Weld?
View 5 Replies
I have a 1987 ford 350 when i go up a steep hill the truck starts to skip and break down to a point where I have to pull over i just put in new fuel pump in tank, what could be the problem only happens on hills.
View 11 Replies
I have a 92 f150 w 302 . My front tank leaks out of the gas cap and builds up pressure. Even though I have never put fuel in it (owned it 7 mos). I siphon fuel out of it weekly. If I switch from rear to front. The truck stalls out.
View 1 Replies
