Ford Excursion :: Noticeable Shutter / Vibration From Underneath
Apr 7, 2013
We went to an out of town zoo over the weekend and the exit is going up a short but steep incline. When going up I get this very noticable shutter, vibration coming from underneath but thats the only time it does it. This is the 3rd weekend in a row weve been there and its done it everytime. Is there anything I could check? Normal driving is non issue, and going up this incline were only going like 5 mph or so. Im stumped.
View 3 Replies
Advertisement
I had the ball joints and u joints swapped out in my Ex a week ago and something's been bothering me. I get a vibration when cresting 65mph that I can't pinpoint. It's not violent and it doesn't appear to be in the steering wheels as it's straight and not jerking at all. It doesn't really affect anything that I can tell either... it's not the vibration from out of balance tires or cupped tires, it's just enough to be annoying... and a concern.
I can't tell if it's coming from the front or the rear either... just seems to be a hum that I can feel that wasn't there before the repairs where done. Where to start?
View 14 Replies
I have a 2012 4x4 f150 163" wheelbase 8' bed that vibrates/shutter when you take off you fell it more when you are on an incline and a WHOLE lot more when you have a load on the truck (trailer/load of fire wood).
View 3 Replies
Have a 1997 2wd F-150 XLT auto trans with 305,000 miles that has developed at vibration that is most noticeable at 55-60mph. It seems to start at about 35, but at 55 you can feel it in your seat. When it's vibrating shifting into neutral doesn't change anything.
Drive shaft u-joints: two rear replaced not too long ago (5+ years?), front joint by transmission seems to move freely, but isn't excessively sloppy, carrier bearing okay. Have done the following with no improvement:
Re-balanced all tires, no problems noticed during the balance;
Replaced first right and then left rotor and wheel bearings, no change.
Several mechanics have driven it and made different pronouncements, it's not: transmission, rear-end, tires, u-joints or carrier bearing. One mechanic ran it while up on his lift and didn't see a driveshaft balance problem. Last suggestion was that the left wheel bearing were "on their way out", so they were the most recent change. It's drivable, but not fun and it produces a lot of noise in the cab.
View 14 Replies
My X has started shuttering in overdrive this morning. I have taking it out of overdrive and seems to go away , maybe a slight notice.....
It did shutter one time at about 2000 rpm while power braking.... but cant get it to do that every time.... possible coil...???
View 14 Replies
I have noticed, and this seems new and not a change in my driving habits, but when driving the prius c, and I am on rolling country roads, I like to loose speed as I go up hills if no cars are behind me, but here is the problem that has become noticeable.
View 9 Replies
Just got my 2014 SCREW 6.5bed with eco boost. Truck has a high frequency vibration very noticeable at 45-55 MPH. So bad the rear view mirror is blurry. Took it to the dealer and they said the e-brake was dragging and fixed that and said the vibration was gone. Not gone. Did some searches and found a number people reporting vibration issues possibly related to drive shaft issues.
Took this video of the slip yoke at the T-case idling in first gear, sent it to the dealer and they said that's normal. I don't think that looks normal. Does that looks normal?
Slip Yoke at T-Case ...
View 14 Replies
I just purchased my brand new 2014 F150 4x4 STX 5.0L single cab short box about a month ago. I noticed when I drove it off the lot that it had a slight vibration at low RPMs. I boiled it down to brand new stuff working out all the kinks and running around for the first time, bought a brand new jeep in 2005 and it made interesting noises and had funny vibrations for a while, but this is starting to get annoying. I have a very noticeable vibration at low RPMs both in park and while driving, more noticeable at speeds between 35-45 with RPMs anywhere from idle to 1500 or so.
I have not had it at the dealer yet, I want to be armed with a little bit of knowledge when I go in an talk to them if possible. I know how stealerships work and since it seems similar problems are somewhat common in these newer F150s, I don't want to get the "oh it's common in these trucks and perfectly normal". In my opinion a brand new truck should run smoother than melted butter on hot flapjacks, especially one that only has 1400 miles on it.
View 7 Replies
The subject: F150, 2007, 5.4L, FX4 version. It has only 80K miles and was very light used by my sister. It seems to me come with a 4R75E ....
Recently I notice a strange vibration every time tranny downshift from 4 to 3, specially noticeable going uphill. Some times can be feel when tranny shift from 3 to 4th...
A friend in my town comment to us, this is a very common condition here because there are just small streets and avenues so that truck shift very frequently betwen 4 to 3 and then back to 4th...
Sounds like a excessive wear on a bearing thrust ??
View 5 Replies
When my RPM's get up there I get a rattle going on from underneath. Not sure what that is. Rattle/Vibration becoming more pronounced. What it is.
View 2 Replies
On my 2003 6.0l Excursion, the 5R110 is having some issues with reverse lately. Sometimes when you put it in reverse it doesn't actually engage. The only way to make it "fall" into gear is by giving it a little fuel, which then sends it into reverse. Now here me out, I'm not hitting 3,000rpms when I do this, just a light raise in rpms will get it in gear. Solenoid issue, possibly?
I haven't noticed if it does this when it won't go into reverse or if it does it no matter what, but it will make a light clunk when going forward after using reverse. A very light, but noticeable clunk. Is this most likely a U-Joint related issue? Got under it and moved the driveshaft around, didn't notice any play at all, but perhaps I wasn't checking properly (wiggling it left and right).
Excursion is RWD (2WD) and has right around 183k miles on it, acquired in October with 172k miles, so not positive on previous history of the transmission. Also I know my gear selector mount is broke, so it cluster is off, but I certainly don't think that, in of itself, is the cause of my issues. Maybe I'm wrong?
View 7 Replies
Vibration/shuttering feeling when on electric driving at low speeds 5mph or less or when letting car pull itself under creep in reverse/forward gears. it is almost like your driving over a rumble strip at low speed with no unusual sounds or noises. just feels a little jerky. it has been doing this since i got the car a year ago and no codes are thrown. trans fluid was changed about 5k miles ago at 87k and there was no unusual coloring, or metal in the fluid or on the plug. it was darker red but not burnt or foul smelling by any means. could this be a loose cv joint or drive shaft?
View 4 Replies
I've got a 2002 F350 DRW 7.3 truck I'm having a little concern over. It started this summer, when under very heavy pulling I was getting a very noticeable vibration between 20 and 25 mph. I did not think much of it, as it only happened under extreme conditions.
Now I'm getting the vibration all the time, and it's started another band which is 40 to 45 mph. It's much worse if you are very light on the throttle, if you're full throttle it's much harder to notice.
Truck has 154,000 miles.
View 12 Replies
I've been hearing this whining noise for a while now and sounds like it is coming from underneath the truck somewhere. Sounds more like a power steering pump whining when turning too far on my old chevy!
It is loudest when first starting and is quite loud at times. Sound varies in pitch. I have crawled around under the truck a couple of times and could not tell where it was coming from. The resonance seems to throw the sound around. Once I start to drive, it tones down where it is not noticeable.
This past weekend, I decided to top off fuel before I changed state lines and had to pay more. was about 1/2 tank. Topped off and surprised it only took about 7 gallons. Usually it is about 10 gallons per 1/4 on the fuel guage, so I was expecting near 20 gallons.
Got back in truck and fuel gauge was just under 3/4 tank reading! I had the neck full as I didn't think 7 gallons was right, so I was suspecting the gas station pump was not working right but it was full in the neck for sure.
So, now....thinking that this whining noise is the fuel pump........ How difficult will it be if it is the fuel pump? I have about 144K miles now.
View 6 Replies
I have a 2001 Ford F150 with 165800 miles. I just had my power steering pump, PVC valve, and serpentine belt replaced by tire kingdom this Sunday 3/2/14.
After they replaced those parts, and I picked up the truck. I noticed the truck was making some new noises, these noises occur when I brake an it sounds like a small vibration on my dashboard and there is a noise underneath the truck. the sound also get louder when I roll up and down the window and run the ac. This had never happened before the repairs.
I took it back on Thursday 3/6/14 back to the mechanic and told them about the new problems. Now they said I had a brake problem. So they replaced the calipers, brake pads and rotors. But I still have the weird noise.
The truck still needs two rear tires a new high-end ac line and a freeze plug. Would any of these cause the noise underneath the truck or the noise in the dashboard or is there something else?
View 14 Replies
My current 08 duty was bought with what I believe to be a procomp 6" lift modified to an 8" lift. The 100 mile drive home after buying the truck showed a tiny "hop" in the rear. I ditched the 37s for some new 35s. Still a tiny hop, mostly noticeable while under a load like climbing a hill. I pulled the rear driveshaft and had it fully rebuilt with a new carrier bearing as well. Still gots the hop? The truck has a carrier bearing drop bracket but I think it may be insufficient for the lift.
The rear driveshaft still has a slight bend in the middle of where the two driveshaft pieces connect. Are the 2 piece driveshafts on your 8" lifted trucks sitting straight with each other or do they have this bend as well?? I am thinking if I get a bigger drop bracket it may cure this slight hop I have? Lots of lifted trucks where I live but they are dam near all shortbox with 1 piece rear shafts so I haven't been able to find one to compare. By the way, my truck also has pro comp rear traction bars..
View 7 Replies
Vibration in my 2014 Prius v (lowercase for the Prius v wagon, not an uppercase) Three. It happens at all speeds but is most noticeable between 68-72 mph. It is felt throughout the car. I am about to go to arbitration with the state (Florida). I had a Lemon Law arbitration hearing with the Toyota sponsored program (NCDS), and the claim was denied. He said he could feel the vibration but it was normal vibration for highway speed. It was quite obvious he knew the Toyota reps too.
Toyota's solution to the issue at the "final fix" attempt was to install new Michelin tires and Road Force them. After getting the car back, I also found they had lowered the PSI in the tires to dampen the vibration but can't prove it. I put the PSI up to what is printed on the door and the vibration came back and got much worse after the tires were rotated.
View 5 Replies
Recently purchased my first Prius, it's the v wagon.
When accelerating from a stopped position in eco mode there's a relatively severe drivetrain shutter/vibration for a a short period of time until I back off the throttle, almost feels like a clutch slipping with added vibration.
It's probably a normal noise produced by this style transmission, just looking to verify if this is true so I can stop worrying about it.
View 19 Replies
Just picked up an 01 Excursion V10 for $2900 with 170k on the odometer. Has some damage on the left quarter panel, but it runs perfectly.
Since I bought it, there has been a squeaking noise that I could feel underneath the driver's side floorboard. I figured it was body mounts. To find out if that was the case, I first sprayed both the sway bar bushings and the body mounts with some oil. The noise went away, but came back the next day.
The second time, I sprayed only the body mounts, and again the noise went away, only to return again. Aside from which, the sway bar bushings look like they were installed very recently.
So, it's the body mounts, but I've come across threads here and elsewhere that these were a common issue, but I haven't seen a fix for them. I assume new mounts would eventually develop the same noise.
What am I looking at here? Just some new mounts or do I need to do something else?
View 5 Replies
The other day while putting on some highway miles on a smooth road I experienced some new vibrations. Not good vibrations, unfortunately. She is an 02 Leg Wagon with 115,000 miles. The vibration was low amplitude and relatively high frequency and was most noticeable at 65 mph or above. Although pronounced at the steering column, the vibration seemed to be throughout the car. Struts? Motor mounts? Imagination? I cant handle the truth?
View 6 Replies
I bought 2012 Prius ii around 6 weeks ago. From day one I started noticing vibrations in the steering wheel most noticeable at highway speeds. I can describe this as high frequency vibrations that become very very annoying especially if you drive to work for an hour every day. This car has OEM Bridgestone Ecopia EP 20 tires. I took the car to the dealership twice already, they balanced the tires twice and road force tested it twice. They replaced front tires for me because based on the test results one tire was at 16 lb the other one at 19 lbs.
The new tires are at 8 and 10. They keep on telling me that this is by design and is a characteristic of the vehicle. However the Prius I test drove when I was buying it did not have this problem, otherwise I would never buy it. This vibration happens in any mode and I can even feel it at lower speed now though it is not as noticeable. I had a few people including Prius owners drive my car and everyone feels the vibration. With so many Prius models sold I highly doubt that everyone just accepts it as a feature.
View 19 Replies
