Ford Excursion :: Noise Coming From Transmission At 2000 Rpm?
Oct 21, 2011
I cant replicate the sound when its in park so i did a very dangerous diagnosis having a friend stomp on the break in gear and rev the engine to exactly 2000rpm as i searched for the sound. The sound is coming from in front of the transmission. I had removed the inspection cover as per another members fix for this sound and its still there. Could it be the torque converter touching something after it flexes at that speed?.
View 14 Replies
Advertisement
Well I went to go to home depot and the key turned and my theft light started blinking and I hear a clicking noise coming from my fuse panel. By the way this is on a 2000 7.3l 4x4 limited. I found what was clicking (see picture) it is the second relay down, the one with the chipped plastic. My question is is this a relay I can replace or is it part of the fuse box? Where I can get a replacement? This is my daily driver so I need to fix this ASAP.
View 7 Replies
2000 Excursion V10 4x4. I'm getting a popping noise coming from the rear end when I apply the brakes and come to a complete stop and when I release the brakes to take off. It only happens the moment it comes to a complete stop and the moment it takes off. Not when I'm putting it in forward or reverse or accelerating or decelerating. U joints are fine. I was laying under the truck poking around the other day and when I roll it back and forth in park the few inches it'll go, when it comes to the end of it's travel the axle wraps a little and it seems like the transfer case output shaft flange is moving in and out of the transfer case and causing the noise. I'm assuming there is a snap ring holding the output bearing in place. I didn't have time to drop the driveshaft but am planning on it this weekend to see if it still does it when I roll it and to inspect the transfer case. I need to check to make sure the driveshaft splines are not seized up but they seem to have a little free play to them.
View 2 Replies
As I accelerate, there is a humming noise that comes from the transmission area of the car. It does not make the noise when I am in idle, nor if i put the transmission in neutral and rev the engine.
When driving slow the noise is very subtle. As I accelerate faster the noise gets louder. The noise becomes the loudest at 60 mph. Above 60 it seems to calm down some. The noise is like a constant, deep humming sound. The noise gets softer as I slow down and then is gone when at idle again. To me it seems related to the speed of the tire or the CV half shafts turning or something rubbing in the transmission as the car goes faster. However the sound doesn't change when the transmission shifts. It stays constant and only gets louder as I go faster and then softer as I slow down.
While driving and turning hard to the left the sounds almost disappears until the car straightens out again. I have replaced the struts on all four wheels and this seems to only have caused the sound to get louder. I have also inspected the CV joints. There doesn't seem to be any cracks or signs of wear to all 4 joints. And I repacked the bearings.
The only other things I can think of is the cv half shafts are actually bad and need to be replaced. Or the motor mounts are not aligned/worn out and need to be replaced. Or the kickdown band and low reverse band on the transmission need to be readjusted. Or the transmission is has a problem (however it doesn't slip when driving).
View 1 Replies
I have an unmodified 2000 Excursion 7.3. with 239000 miles on it. My transmission started to slip in overdrive. I could turn off the OD and it would run fine. I was in upper Wisconsin headed home to Georgia and figured the cold had something to do with it. Drove sixty mile with OD off turned it back on shifted fine and drove 750 mile to Paducah, KY stopped to eat and it started down the road and it slipped again.
Drove 45 miles stopped added 8 oz of tranny fluid and it drove fine back to a friends house and after I dropped him off and headed home it started again. The tranny is serviced every year, new filter, drained torque converter. I use Amsoil Synthetic ATF. I have used the truck to tow a 10000lbs trailer over 65000 miles. I was not towing when this occurred. What is going on? I guess what I am asking is my tranny about to become toast or am I looking at something that can be fixed easily.
View 14 Replies
My new/used 2000 4x4 excursion with 214000 miles on it has a transmission fluid leak.
It could be a rear portion of pan gasket but it seems to be coming out of the area where the transmission bolts to the extension housing.
I just put a transfer case in it. Thought all the fluid all over was due to exploded T case.
It seems the output shaft seal may be bad. I cannot seem to find an OEM part number for this seal.
What is part number for this seal, if one exists? Maybe the seal is in the extension housing and it's just the gasket between Trans and housing.
View 8 Replies
I have a 2000 Excursion w/ V10 and I have an issue with the transmission form time to time. some times it does not want to shift out of first. if I pull over and turn it off for a few minutes it will be fine for a while and it doesn't do this all the time. A few nights ago it did this so I pulled over and turned it off and it still did it but then it started shifting on its own just fine till we got on the high way which is started shifting in and out of over drive going around 60-65 MPH. didn't want to go too fast not knowing what it could or would do. it did this for a few miles then it started working fine. next day it did the same thing not wanting to shift out of first then started working fine. drove it around last night and it all worked perfectly. The CEL is on but I get a no communication text from the scanner so that is another thing I need to look in to. I'm guessing it is an electrical issue being when it works it shifts fine and it does not slip at all.
View 14 Replies
2000 EXCURSION 7.3 Powerstroke
Automatic Transmission My son was trying to back up my empty 12' flat bed trailer up a hill (approximately a 25 degree hill). Why'll I was at work, my wife said he was having alot of trouble, and it was taking him awhile. She said she saw transmission fluid on the ground and stopped him immediately,and he turned off the engine. There is a trail of fluid on the driveway about 100' long and a 1/2" wide. This transmission has allways been solid, and only leaked a few drops on the driveway in almost 300,000 miles. what probably happened, and what I will need to do to fix it. I have allways worked on all my vehicles. But I know better than to get very deep into a transmission.
View 5 Replies
As it turns out, my shift cable wasn't bad. The transmission lever coming out of the transmission doesn't want to move very easily. When in gear, it shifts fine as it should, so I'm thinking something is bad with the lever. Problem is, I don't know what could possibly be causing it.
View 8 Replies
I have a 2000 V10 2WD Excursion with 104,000 miles. Last week it started shifting hard between first and second, but only when I am between 1500-2k RPMs. If I rev the engine higher, it shifts smooth. I checked the fluid and it is fine. I rarely tow anything except my little trailer to the dump every few months. I have a few questions:
1. Should I drop the pan and change the tranny filter?
2. Should/Can I check the rear diff fluid? (haven't noticed any leaks)
3. Could an inline flush and fill work?
4. I saw a post about a speed sensor in the rear diff. Could this be the issue?
View 4 Replies
My excursion has come out of park a few times. Not good at the boat ramp.....
View 3 Replies
Just changed transmission fluid and filter at 175,000 on my 2000 V-10 and now I have a whinnying sound and shifting that does not feel sure footed. It worked fine before the change. Fluid is synthetic and filter is Ford Motorcraft. Did it just go?
View 14 Replies
2000 Excursion 7.3 unk transmission
Quick run down on the situation. It has been terribly hot here bumping 105 degrees. I was told by a man he could see fluid leaking and it was trans fluid. I checked it and filled it up and got it to the shop.
Next day they said it was not leaking and that it probably overheated. They recommended an after market trans cooler. They put it in and off I went. 60 miles later I got fluid all over the rear of the truck. I filled it up again and got it home. Shop says I need a new trans.
View 9 Replies
2000 Ford Excursion XLT 4x4 V10 ... Part store shows I need a 3G alternator ... Current alternator put on by PO in 2013/14 s a Duralast DL7764 from Autozone. Tag is still on it.
My battery light is coming on for a few seconds and going off for several hours before it comes on again. Connections are good....crappy Autozone alternators.
But for some reason my motor has a 6G alternator. All parts stores say I need a 3G. Did Ford put 6G'S in all excursions, or do I have a 2004+ motor in my 2000 Ex? Or will a 6G fit where a 3G is supposed to be? All connections look factory including electrical hook ups.
View 3 Replies
2001 Excursion V10 with E4OD. Transmission is around 4 years. Old with 40-50K on it. Here's my timeline of problems.
Day 1. Went to dive and it slipped and caught taking off. Never felt that before. I drove it about 7 miles, no problem, when coming to a stop it stuttered a little. Checked fluid it was OK. Added some SeaFoam. Seemed worse and thought I was outta luck.
Day 2. I dropped the pan and found the normal metal around magnet plus a few metal shavings(not brass). Not many. I took it to a tranny guy and he said something inside has failed but he wasn't sure what. I changed filter, used same fluid as it looked ok, put it back together and added Lucas treatment. It moves ok, still slipping around 15% of the time on takeoff. After moving it runs/shifts great.
View 8 Replies
I swapped a t5 transmission from a s-10 into my 52 ford f3. I am trying to rundown a grinding noise coming from the transmission. I replaced the throw out bearing and the input shaft bearing on the transmission. With the transmission partially apart I couldn't find any obvious problems. The noise is only present when the clutch is depressed either in gear out out of gear.
Left in neutral there isn't any noise. I initially thought the throw out bearing was the culprit and replaced both that and the input shaft bearing. What could be wearing out? The transmission shifts perfectly but there is a binding noise when the clutch is released in first and sometimes second gear. another binding noise is present when making a hard left turn while starting out. I am at a loss here....
View 2 Replies
Had this rig for 6 years, and I love it. Two weeks ago, wife was driving home and she and the kids saw smoke coming out of the dash, along with an electrical stink. Shortly after, she noticed the blinkers not working. While trying to diagnose, I have found that the radio, heated seats, headlights, rear AC, blinkers, front wipers, rear/mirror defrost do not work. On a test drive, the rig also has an odd idle, as if it is going to die, then catches up by revving... repeatedly. Sometimes throttle is unresponsive.
I started by replacing the battery. I cut back battery cables til there was no corrosion and reattached them. All fuses in the cabin and under the hood look good, and none of the relays (yes, I pulled them all) seem to have any damage, melting, etc. My battery to engine and frame grounds are good. I also tried spraying starter fluid around vacuum lines to see if that changed the idle -nope. The only code on the rig has been on for a couple months, both right and left banks lean.
I am not great at tracing down wiring, but I am starting on grounds, then will start on hots.
View 8 Replies
Yesterday morning taking off out of my driveway I heard a ticking sound. Kinda metal on metal sounding. It sounds like middle of truck underside. Only on acceleration. It does also clunk at times or ping when I put it in gear.is this u joints? Hopefully not rear end. Its a 2000 limited ex. with the v10.
View 7 Replies
I have recently found what sounds like a grinding/vibration issue that occurs between ~2100-~2300 RPM's in my truck. After some googling, I thought it may be the inspection plate being a bit bent/loose. I took the cover off and drove around and the noise still occurred.
Things I have noticed:
-Occurs between 1-2 and 2-3 (had trouble with the other gear changeovers as I just have slow backroads around me to test over my lunch break- can test further in the future)
-Occurs during acceleration and deceleration
-Starts at ~2100 and ends ~2300 RPM
Any thoughts for next steps to diagnose? Truck has ~160k on it and I don't really have many service records (purchased within the past 3k miles and problem just started occurring after this past weekend). Transmission fluid seems to be in decent condition.
Not sure if it would affect anything, but I just got back from my first trip with the Excursion where I actually needed to utilize the 4WD. There was much more aggressive terrain than what it is used to seeing on the pavement. Thought I should mention that as well.
V10, if that matters (I recall reading somewhere that '99 7.3s with the auto had documented torque converter issues that warranted a TSB)....
View 4 Replies
I've been hearing this whining noise for a while now and sounds like it is coming from underneath the truck somewhere. Sounds more like a power steering pump whining when turning too far on my old chevy!
It is loudest when first starting and is quite loud at times. Sound varies in pitch. I have crawled around under the truck a couple of times and could not tell where it was coming from. The resonance seems to throw the sound around. Once I start to drive, it tones down where it is not noticeable.
This past weekend, I decided to top off fuel before I changed state lines and had to pay more. was about 1/2 tank. Topped off and surprised it only took about 7 gallons. Usually it is about 10 gallons per 1/4 on the fuel guage, so I was expecting near 20 gallons.
Got back in truck and fuel gauge was just under 3/4 tank reading! I had the neck full as I didn't think 7 gallons was right, so I was suspecting the gas station pump was not working right but it was full in the neck for sure.
So, now....thinking that this whining noise is the fuel pump........ How difficult will it be if it is the fuel pump? I have about 144K miles now.
View 6 Replies
I have a 2001 Ex with the 6.8, stock motor, exhaust etc and I have had a rattle I have not been able to track down. I finally crawled under it the other day with a buddy (auto body guy) and we isolated the noise to be coming from inside the tailpipe, just about where it bends by the rear tire/wheel. I ran a fish tape up the pipe and it seemed to stop right in the area of the bend. My question is there a baffle of some sort in there?
View 2 Replies
