Ford Excursion :: 7.3 Crank But Won't Start - White Smoke Comes Out Of Exhaust
Jan 17, 2017
My 7.3 won't start after sitting for almost 2 months, the wiring for the injectors was bad, and the first package was damaged, so I had to order a new one, and wait trough Christmas before I get the new parts. The valve cover seals have now been installed, and all parts fitted. Thieves stole my batteries so I had to buy new ones there as well.
When I tried to start it, it will crank, but not start, white smoke comes out of the exhaust, and glow plugs seem to be fine. One thing I did notice is that the fuel pump under the driver side of car was making a wired noise when turning on the ignition, it was not a constant hissing sound that I used to on my other cars. I poured a small amount of condensation remover in the tank, the tank is half full, but still no start.
After trying a few times, it did sound like it would get better, but that only lasted for a second. Strange problem, I think my fuel pump is acting up, but I don't know for sure yet. The fuel pump did work when I parked it. Could it be a fuse that does it? I checked the hpop to see if there was any oil there, and it was.
View 2 Replies
Advertisement
After a hard rain overnight, my truck would not stay on. I had to give it gas while still in park or it would cut off. Also I noticed white smoke from the exhaust while doing that. Eventually car stayed on. But now at when I come to a stop, the car will cut off when I put my foot on the gas to take off. I also.noticed the overdrive button will start to blink. Once the car gets going a few miles, then it's fine. Then this process starts all over again once the car is parked. Also the service engine soon light came on.
View 1 Replies
I've been chasing a problem all summer. Began with crappy batteries dying intermittently. I replaced the batteries, FICM, finally cleaned EGR valve and replaced ICP with pigtail. The problem is still persistent. Basically a rough idle, puff of whit smoke on cold startup, rough running at around 1500 rpms( driving at 50 mph). The ICP was soaked in oil so i was confident replacing it would finally cure my issues. It actually got worse with the rough idle turning to a surging idle and quite rumbly at 50 mph speed. I guess its time to look to injector issues but i thought id check if after replacing icp/ cleaning egr. I also have a slight exhaust leak at turbo out that i can see. The clamp is not seated properly. This after turbo connection to exhaust.
View 1 Replies
2002 F350 7.3PSD, lariat 4x4 dually , 212k miles, automatic, crewcab, bone stock other than k&n filter in factory air box.
Bought the truck from used dealer with 168k miles on odometer. Drove it for two months and the radiator started filling with diesel. Had injector cups replaced. Had new o-rings on injectors and valve cover harness (both sides) at this time. While in shop they wanted to put injectors in truck but limited funds haulted that. Got the truck back and drove it for a while and noticed that when starting the truck it had a miss till it warmed up, but went away. This has been going on for over a year, but now has gotten much worse. Over the past year it has gone from slight miss to a full on dead cylinder that you have to make the truck pick up as you drive it. If you leave it sitting for more than roughly 10-12 hours you have to plug it up or it has trouble starting.
The final push from this ole girl was the other day. Left for work, normal hiccups and such from the truck. I pull up to a stop light and notice the truck is not sounding like its running correctly. No biggie it will smooth out, or so i think. I head towards work and the farther i get from home the worse it runs...
It wont pull its own weight, barely creeping at times. So i stop and check all my normals(oil mainly... just replaced hpop fittings and o-rings) and add fuel to it to get it over half tank. Start truck, still missing. Pull out on highway and dump foot to floor. It takes off only to fall on its face and start blowing white smoke out exhaust and die. It starts back but apparently I pissed it off cause from there it only got worse!!! It done that all the way to work, one time being so bad i had to stop and let traffic go by as the smoke cleared the roadway.
I get to work and check oil and it was way low. I add oil and drive it to lunch and it runs good, no hiccups misses or anything. Yay, problem solved!!! WRONG!!! Head home after sitting for a few hours and i pull out the parking lot and it falls flat of its face and goes into its dieing and such again. I limped it home and its sat in the yard ever since. Tried to start it today and after being plugged in for a couple hours it only sputters on a couple cylinders till it slowly dies. All Ive got for my troubles today has been two dead batteries...
This truck has always been underpowered as well. And gotten terrible fuel mileage (8-10 avg)... But it sure is pretty!
View 2 Replies
It's a 2001 camry Solara .. When I start my car for the first time every day, I have white smoke come out my exhaust usually for about a minute or two but it runs fine after that. But it's like a cloud of white smoke. I checked my oil and it's fine. What it could be?
View 17 Replies
Recently purchased a used 2003 Toyota Camry LE. After a recent oil change at the local Toyota dealer we noticed that when we start the car in the morning a puff of white smoke spews out from the exhaust for a few seconds and stops. There is no more white smoke while driving the car around. The car runs perfect and has no power loss. Initially we had noticed it was losing coolant. All the discussion on the internet pointed to a bad head gasket. We had a mechanic look at it and it turned out that the radiator was leaking and hence the loss of coolant. He also noticed the oil was overfilled so he brought it down to the normal level. The mechanic also checked the head gasket and claimed there were no issues with it. Replacing the radiator took care of the coolant loss but the white smoke still comes out only the first time the car is started.
View 8 Replies
My beloved excursion is 300 miles away from me in a no start condition. Vehicle has 270K miles. Very well cared for. No issues to date since purchase 5 years ago. Went to back up and the vehicle starting Caming like it had a big cam in it. went from reverse to drive and problem went away. Drove vehicle for 2 more weeks without issue. Then all of a sudden it dies. Restart driver on down the road 1/4 mile, dies again. Restart, make 45 mile drive home vehicle is low on power will hardly pull a grade but I got to my friends house. Went to start vehicle next day and no start. Puff white smoke while trying to start. It hits every once in awhile but wont run.
The vehicle is throwing NO CODES other than an open glow plug on 1&8 which it has for sometime now. I have changed, fuel filter, fuel pump, CPS(genuine ford), IPR and IPS. No real changes still wont start. I disconnected the IPS and it started but it sounded like it was only running on a couple of cylinders. It would not accept throttle. The local Forddealer does not have a Ford diesel tech. Ive called a couple of diesel shops and I hear could be a bad HPOP, or bad ECM or a bad IDM but without seeing it. I am at my wits end with this thing. I am an electronic engineer by background. So I have a good sense of the process. I have checked all fuses, relays, etc. I will say I did have one issue with it a year ago where the UVC problem popped up but the dealer fixed it and it has been fine ever since.
View 14 Replies
I recently purchased used from a dealer. On two occasions recently white smoke came from the exhaust when starting the car. One time after sitting at work all day and most recent upon starting first thing in the morning. 30,000 miles and still under warranty.
View 4 Replies
yesterday I went out started my truck and white smoke started coming out my exhaust so I turned it off waited a bit started it back up let it run for a bit smoke went away drove it about 60 miles. Later that night it did the same thing but I was 2 gallons short on coolant drove it another 60 miles ran fine. Next morning decided to take it to a shop put more coolant in it drove maybe 20 miles to shop got there turned it off everything was fine never over heated once. So this shop is now telling me my trucks hydro locked and I steamed the EGR valve. And there telling me it's gonna be $8000 to fix it .
View 3 Replies
I was passed the other day by a newer (square mirrors) nice-looking Super Duty that was slightly spewing white exhaust smoke. As a life long truck driver, I know a few diesel smells (and I kinda like some ). But, this was so pungent that it was irritating my eyes inside my own cab.
It was so irritating and nasty smelling, that I had to slow down (to let him gain some ground) and open my windows to clear out my truck. So that I may be better informed, what could've caused this?
View 14 Replies
I have a 2006 F350 6.0 litre diesel. The other day I started it up drove away and it was blowing huge plumes of white smoke out of the exhaust. Shut it off.....started it up again after a while then went on a long drive and it went away. What that was?
View 6 Replies
I have a 2005 F150 4X4, has 43,000 easy miles on it. When I started the truck I notices white smoke come fron the exhaust. It was a cool morning and the truck was sat for 24 hours, I have read some post about how that could be the reason. I was also told that adding a quart of lucas in place of one of the (motorcraft synthetic) quarts.
View 3 Replies
My 1990 Ford Econoline Conversion van (75,000 miles) recently started emitting white smoke or vapor from the exhaust pipe. I've been told it is steam caused by one of two things - either coolant or automatic transmission fluid leaking into the engine and being burned off. I've checked the oil and no sign that coolant has contaminated the oil (no chocolate shake-like substance). My coolant was a little low, so I topped it off. One possibility is this could be a head gasket issue. I have two questions. First, could it be something other than the head gasket? And second, is it safe to run the engine or drive the van while it is emitting the white smoke?
View 2 Replies
2005 6.0 & noticed on Friday there was white smoke coming from exhaust that started when I'd turn on truck then aster 1st light or stop sign it would be a cloud of white smoke. Once I start to drive it stopped & I didn't see it again that day. I noticed the same thing again on Saturday & Sunday but the smoke was thicker on these days but would stop like the day before.
I had a code come up a month ago which I believe was P404 but read something about EGR valve. So I replaced the EGR valve 3 weeks ago & light never came back.
Today I had a Dr's Appointment and had usual white smoke in morning but once I got to the Dr's appointment the truck sounded like the turbo got louder then usual and started to see cloud of white smoke again. While sitting in parking lot I check to see any codes but nothing came up but the cloud of smoke started.
When I left my appointment, the turbo sounded louder still and noticed white smoke every single time I stopped at a light or stop sign.. Then the coolant level was high with the engine giving me the warning of over heating coolant or something like that.
View 2 Replies
I have a 2003 F150 with a 4.6. Exhaust is pouring out white smoke with a sweet smell. I have replaced upper and lower intake gaskets. Compression test on all cylinders are at 145. Confused and don't know where to go from here.
View 1 Replies
Our family recently purchased a used BMW 528i (40K miles). Perhaps this is nothing, but I just wanted to make sure anyway.
Today, at around 2AM (maybe 50 degrees C), within minutes of starting the car, we drove into a McDonald's Drive Thru. While I was ordering and pressing on the brakes, I noticed continuous discharge of white smoke/vapor from the exhaust. For maybe a minute this continued. When I moved the car a little bit to get closer to the window, the smoke stopped. But when I stopped again to receive my order, I saw the white smoke/vapor again. My friends who were with me told me that it might just be water vapor, but the hypochondriac in me wants to make sure this isn't a blown head gasket or anything else I've read about in the internet. BTW When I drove away from the Drive Thru and continued driving, I stopped seeing the white smoke/vapor.
I'm as clueless you can get with cars. Do I need to be worried?
View 6 Replies
Having trouble with 6.0 powerstoke white smoke out exhaust. We have installed egr delete and still have white smoke and water coming out of exhaust not as much as before. Took it back apart to see if we did anything wrong everything look ok. We did a compression test on all cylinders they check out ok.
View 6 Replies
I'm losing coolant have, excessive white smoke coming from the exhaust, and rough idle. Doesn't over heat or even try to overheat. The oil fill cap looks brownish white. It drives fine other than extremely rough idle. I know how to check a blown head gasket with the combustion gas test.
From what I've read blown head gaskets on 4.6 fords are fairly uncommon but a blown intake gasket is fairly common. How can I tell the difference?
View 13 Replies
After a couple of setbacks, including forgetting to install 3 out of the 4 orings on the oil cooler, I got the IPR Gen2 delete installed. I have a couple of issues since getting it started. I have low boost, I know the up pipe for the turbo is seated well, really surprised about that. However, the exhaust pipe may have a slight leak, but not positive. Finally, the last on this issue, I have a ripped MAP hose that I'm going to replace.
Next issue is that I hear what almost sounds like a gas engine exhaust rumble from the front of the truck. What it could be? I had white smoke initially coming out of the exhaust, but it cleared up after getting everything up to temp and taking it for a ride down the road. On a side note, the leak that I had from my previous thread seems to be gone now.
View 3 Replies
I have a 12 F150 with the 5.0L. it has 27000 miles on the clock. Noticed twice a small puff of white smoke coming out of the exhaust and decided to check the oil level and it was a quart low. The last oil change was done at 23000 miles and used Full Synthetic Pennzoil and a K&N filter. Called the local dealership I purchased at and they told me NOT to use full synthetic and should only be using Motorcraft semi synthetic with a Motorcraft filter. I know the dealerships will only endorse and advice Motorcraft products but what does everyone else use and think. In the meantime I added a quart of oil and all is fine.
View 5 Replies
I've been googling for about 3 hours now, and no answers for the gassers, just diesels. When I start my excursion (v10) it pours white smoke for a while, then stops. It does this every time I start it no matter how far I go or how long it sits.
There is plenty of coolant in it and I've never had to top it off, so I don't think it is getting coolant in the cylinder. With that much smoke it wood definitely need coolant if that's what it was. Oil consumption is kind of high in my opinion, but the smoke smells rich.
View 10 Replies
