Ford Excursion :: 2WD V10 - Front End Shaking / Wheels Wobble
Sep 6, 2013
Have been battling this for months. Thought it was warped rotors, but has continued to go crazy. Truck is fine until braking at freeway speeds to 0 at about 35 front end goes crazy with shakes. Wheels physically wobble. Thought it was bearings replaced them. Put on rancho 9000 shocks replaced all steering and tie rods had aligned. Put on EDC slotted and drilled rotors with yellow stuff pads, new calipers. Each time worked for about 15 miles than started again until crazy wobble. Scaring the wife and kids to point they will no longer ride in truck. Steering is now slack need to adjust and probably need to look at everything again but it still is rectifying symptoms not problem.
View 5 Replies
Advertisement
I have a 2006 scion xb with 106000 miles. It has 17" custom wheels on it. When I test drove it I noticed some vibration up front and assumed the tires were not balanced good. I rotated the tires and noticed a slight difference but it still shakes around 70-80mph. I cant feel any vibration from the back of the car. Sometimes at 65 mph it's fine, other times it will shake. Since the shake isn't at 65 all the time, could my problem be worn out struts?
View 2 Replies
I've only had the Ex for a few months so I'm still learning... After a trip to Orlando this weekend, I noticed a very faint odor of differential fluid from the driver's side front and rear wheels.
Nothing on the passenger's side. I've inspected the pinions and axles and found no wet areas at all, so I'm a little perplexed. The wheels and axle housings were pretty cool considering a 5 hour round trip.
I was also wondering if what I am smelling is due to the axle vent hoses?
View 5 Replies
I have a weird problem with my alignment. I have had this car about a year and in April put my summer wheels on. I have a staggered set of rohana's 20x9 up front and 20x10.5 in the back. When I took the factory tires off I could see inner tire wear. I figured just needed new tires cause I don't feel any pulling or known alignment issues.
After a few months I started getting a little wobble in my wheel and more road noise on the summer wheels. When I finally got it looked at just the passenger rear tire had inner wear. I took it to get aligned and the alignment shop said this thing is really good it was all in the green. They did do a little adjustment but nothing major. Showed me the print out and everything. My car is not lowered at all. I've attached pictures......
View 7 Replies
I think I need to have them done some where else. but around 65-70mph my wheels shakes. even after alignment!!!
View 3 Replies
We have an 01 Sport Trac as a backup vehicle and it has the 3 position rotary switch on the dash for 4wd.
The transfer case engages and disengages but the front wheels seem to stay engaged with the front differential.
There are no manual hubs and I really don't think it should ALWAYS be engaged like that.
What is the probable issue and ALSO can manual hubs be installed on this truck?
Someone mentioned vacuum engagement? but I didn't see any vacuum hoses near the spindles. Didn't see any wires either other than ABS...
View 11 Replies
Recently I notice, when I'm going 60+ and then I need to slowdown, my steering wheel starts violently shacking. Plus I have watch with metal band and it it's making even more noise when it's starts to shake. Sometimes it's not that much to slowdown, but that shaking is too much. It's not ABS, because when ABS working you feel it in brake pedal, here is in steering wheel.
Also, I would like to mention the fact that I need to change my brakes! Now I don't know if its because of my brakes or some other problem.
Not that I need it, but this though keeps popping up every now and then. My speedometer shows 160, but I can go only 125! I was told that its some kind of chip that prevents to go higher. Is there a way to take that limit off? This question is purely for my curiosity.
View 13 Replies
I got a 97 f150 single cab short bed. My 4x4 shifter is on the floor and moves. I put in 4x4 and the relay clicks and the light comes on. Same as 4low. Front driveshaft spins but front wheels don't. Could there be a leak in the auto locking hubs? Also I want to manual convert the auto hubs. It can be done but how?
View 1 Replies
I have 2011 RX AWD and noticed when driving downhill and braking, car will shake. It feels like the wheels are shaking but the steering wheel does not. Is it rotors or something else?
Also RX is certified pre owned warranty for another 30k miles and I want to do alignment on it but not sure if warranty will cover that ?
View 6 Replies
Whenever I am driving my Subaru Impreza, the steering wheel shakes above 60mph and is a violent shake at 65mph making it unbearably frustrating to drive to school each day. Recently I had slipped on ice and hit a curb with the tires on the right side of the car. I took it to a shop to get the rims looked at, and ended up replacing the back right. The mechanic said nothing about the front one however. My question to you is; could it be that the front rim is also bent? Or that it could just be a buildup of ice. It is cold here, snows often and is never above 20F.
View 4 Replies
I am growing very frustrated with the constant shake in my 2002 Passat wagon. A couple of years ago my wife had a blow out and I ended up replacing all 4 tires since it was time. I went with Michelin Primacy MXV4 (which I think the suck anyway). They have about 27000 miles. I have had the tires rotated about 3 times and the balancing always seems to go out. I purchased the tires at our local Discount tire and I have had to Road force balance them yet again. I do have a special warranty that should replace them in case one or more of them are defective. Before the last rotation the tires were fine I also had the rims inspected and they seem to be fine. I feel the shake mostly in the seat and the steering wheel does not suffer from usual side to side vibration
Another very curious thing is that they tend to shake a little bit more when I am going up hill. We live in NC and the highways are a bit hilly depending where you live. It happens in the 65 to 75 MPH range.
Everything else in the front end and suspension components seems to be fine.
View 9 Replies
What to do with the worn out steering wheels on these rigs? Mine is worn to the point that it's getting loose on the top section.
View 14 Replies
Had the death wobble a couple of months ago. Changed all shocks, steering stabilizer to bilsteins; new tires (stock), ready lift stabilizer(stock, no lift) had it digitally aligned. All was perfect. Until my new intermittent steering issues. It appears to happen when making a 90 degree turn, say a right or left onto a perpendicular roadway. As truck straightens out, you'd think the front drivers side wheel is going to fall off(you'd think the lugs are missing).
Pull int a parking lot, drive in a few circles, and all back to normal. Can't replicate every time, force for s few days with no issues, then it might happen again. Other intermittent issue is sometimes, again out of no where, truck will pull and track to the right or left. Pull the steering wheel the opposite direction, it'll track the other way. Again, pull int parking lot, do a few figure eight circles and back to normal. Alignment shop and regular mechanic say everything is tight, ball joint look fine.
View 3 Replies
Vehicle is a 2000 Ex. Limited 2WD 6.8, 3:73 rear, 135,000 miles purchased at the end of December (Merry Christmas to me!). When I purchased the vehicle it had some vibration at speed, that I chalked up to the completely worn tires, tire rod ends and ball joints, all that I knew about when purchasing. The vibration slowly builds up to 70mph, and then comes on like a light switch where it is nearly violent, then slowly dissipates over 80mph. First on the vehicle were new BFG TA/KO2's 285 75 16. No change in vibration. Next were ball joints and tie rod ends. No change in vibration. Next were new inner/outer front hub bearings, rotors, pads. No change in vibration. At this point I was scratching my head a little. I had the tire balance checked twice by two different shops. Alignment was also checked by two different shops.
The vehicle has 2" spacers under the front coils and an aftermarket 4" lift block in the rear of unknown manufacture. I decided that the vibration may be due to an incorrect taper on the block causing a pinion angle issue. I replaced the block with a stock F-350 block for the same wheelbase truck. No change in vibration.
At this point I figure all that is left is the driveshaft and I am very fortunate to have the great guys at Driveshaft Specialists about 2 miles away from my office here in San Antonio. They took it out for a drive and said "we'd love to sell you a new driveshaft, but we don't think that's it." They put it on the lift, jacked up the rear by the differential and ran it up to speed. By 50mph the rear wheels had VERY VISIBLE "hopping" at the hub. You would have thought there were 5lb weights attached to the inside of each wheel. It was vibrating like crazy. There isn't any noise or play to indicate bearings (and with the amount of wobble/hopping/vibration I was seeing the bearings would have to be reduced to dust). Their best guess is that somehow the axles are bent
They referred me to another shop where the Ex will be going today, for possibly new axles. I am leaving for a 2500 mile round trip road trip Thursday and am at my wits (and wallets) end.
View 14 Replies
Couple of days ago I started hearing a wobble noise coming from the right front. Almost sounds like a worn wheel bearing. Driving the car there is no signs of misalignment, and unbalanced wheels. Haven't hit any curbs or large potholes.
View 15 Replies
So I just bought an Elantra and I just took it on the freeway. At 65+mph there was a huge amount of wobble in the front of the car. It felt like I was driving in a groove in the road or driving in really high winds. The car drives fine under 60mph...
View 5 Replies
My 2005 Malibu Maxx LT started shaking on the front end for about the past month. I took it on the highway the other day and realized that the faster I go the scarier it is to be driving it. Apparently this is a"Maxx thing" from what I have read online, but GM does not acknowledge that this happens to many owners of this vehicle and refuses to offer any solutions or reasons. So now I am stuck with it and need to figure out how to fix it.
The 2 mechanics I have taken it to assumed I was referring to the tires and said the tires look fine and there is nothing wrong the the bolts. The first guy gave the bolts a slight tightening and sent the silly woman on her way. The second guy I made drive it, he took it for 2 minutes and he said it is just lousy pavement we have in this area and that I was being paranoid. Could this be caused by tie rod issues, or maybe rack and pinion?
View 4 Replies
My 2002 X won't shift into 4wd. The dash light comes on, but only my rear wheels are engaging. Trying for a half hour, I intermittently was able to get it into 4LO without the front wheels engaging still, but it took me a long time to get it out of LO. While in neutral, I would switch the dash selector out of 4LO into 4HI and it wouldn't switch. Id move the truck a few feet forward and then back and try again and finally got it out of 4 LO, but it went back to just the rears, even with the 4x4 HI dash light on. I replaced the ESOF hubs with warn hubs a few months ago, so the ESOF aren't the problem. The only thing I didn't do when I swapped out the ESOF was plug the vacuum lines, would that affect manual hubs? I am visiting relatives in eastern WA and it has snowed 5 inches in the past few hours. I need to make it 180 miles home tomorrow.
View 3 Replies
2006 gs300 AWD , stock everything ,
I am experiencing heavy wobble,front section from 5 to 20 kmh , , like an unbalanced washing machine starting the spin cycle And again milder around 60 to 80 kmh. This is after tire change over to michelin pilot hx mxm4 65% thread .. professionally balanced .
I could still feel it with the blizzaks at low speeds, but way way less. Both sets are 225 50 r17 93v 35psi on original mags as per book
I was wondering if it could have any thing to do with tire wear geometry, or perhaps drive shafts ,but no clicks or noise from them.
View 3 Replies
I purchased a used 2006 Toyota Highlander AWD about 4 months ago. Ever since I bought it, it has had a vibration / wobble from the front end that can be felt through the steering wheel and acceleration petal. Only happens between 40-45 mph. I have brought it to the dealer many times and every time they balance the tires. Last time they said it was a faulty motor mount and replaced it. The problem has not been fixed with this repair.
View 1 Replies
When I turn the wheels to full lock, either right or left, I hear a clunking sound. Usually pulling into parking spots, into the driveway, etc.....but only going forward, not in reverse. Where do I start?
View 9 Replies
