Ford Excursion :: 2004 - Relay Click Under Dash When Turn To Start
Jan 5, 2013
I have a 2004 Excursion with the 6.0 diesel 189k kilometers. Had an egregious delete done about 3 weeks ago. A couple of nights ago the temperature was about 10 degrees f and Whalen I started her it sounded like electrical arcing or grinding. She started and off I went. The next morning it was 0 f went to start and made the same noise and then just stopped cranking. Now when I turn to start I get nothing except the relay click under dash. I tried jumping the solenoid and got nothing. Someone told me that my ground connection might be off the starter. Problem is I can't seem to get at the starter.
View 3 Replies
Advertisement
Ok, I have a strange no start issue right now. My excursion won't start. I have power to everything and both batteries are at 12 volts or a bit more but the starter won't engage. If you turn the key to start all that happens is relays click under the dash and the airbag light flashes. It almost seems like the transmission is in gear. It did this twice about a month ago and has been fine ever since until today.
View 8 Replies
Alright so I have a 99 7.3l. One day I went to start my truck and when I turn the key to the on position all is normal and then when I turn it all the way to crank it nothing happens. I hear a relay click ann thed that's it. Me and a buddy of mine spent quite some time on going through the entire truck. The starter was replaced, the neutral safety switch was replaced and the ignition switch was replaced yet the problem is still there. We then discovered that fuse #20 under the dash keeps blowing with every turn of the key. The manual states that this fuse is a starter motor relay coil PCM ( gasoline only). So if it's gas only why is it even in there. Let me just say that I can jump the fender mounted relay and the truck starts.
View 7 Replies
About a month ago I was using my driver side seat heater when I noticed it wasn't warm anymore. I looked over and found the indicator light for the heater was off. Here is what happens:
When I push the buttons, I can hear a relay click under the dash, the indicator lights come on quickly, but then they go right back off. It does not matter if I choose upper or lower heaters, and it acts the same for both driver & passenger seats.
I connected up a Snap-On computer to it yesterday. We went under the driver door module and it shows the heated seats, but no error codes were present. It displayed the heated seat as inactive. When the button is pushed, it would show active for a split second, then go right back to inactive.
My mechanic friend thinks that it may be a shorted heater module. He isn't 100% sure on if that is the correct diagnosis, or where to locate the module. I believe it to be under the driver's seat.
View 5 Replies
2001 6.8 Ex wouldn't start again today Get a loud click but starter doesn't turn over. Yesterday jumped it, took it to Advance where they checked battery and alternator; both checked out great. To start it this morning I ran my negative jumper from battery to engine block and it fired up It's about 12 degrees out and was same yesterday. Thinking dirty/bad ground somewhere ? Do I just start following the negative cable everywhere it goes or am I missing something here No garage and it is chilly.
View 3 Replies
Its and 09, I can hear a relay click under the dash. It has gotten really hot since i bought it in sept to the point where I had to turn it off because I thought it was going to burn my bottom. I am guessing its not an easy fix.
View 4 Replies
I have an 02 F250 6.8 with 51,000 miles on it. I recently replaced the battery about a week ago, and only actually drove it yesterday for the first time since replacing the battery. I drove it about 25 miles, parked, and when I went to restart, it wouldn't. The starter doesn't crank, so I mean its not a cranking issue as in cranking, and not starting. It only clicks at the relay when turning the key. It acts like when you try to use a wrong chip coded key.
All of the dash lights came on, and I can hear the relay clicking, but that's it. I swapped the relays around, and no luck. If I let it sit a while, about an hour, it will fire right up. The battery cables are tight and free of corrosion. I am curious, since I just put in a new battery, could this be the culprit? Why will it start fine cold, but not hot? I have NEVER had an issue with this truck until now.
View 14 Replies
I have a 2001 for f250 with the electronic shift on the fly and when I turn the switch to put it in 4hi or low nothing happens I don't hear a click and the lights don't come on but the 4wd light works it comes on when I first start the truck and I put different relays in that we're good and still nothing I tested the the relay box itself for power and there wasn't any.
I used the truck last year for plowing and it worked sometimes it wouldn't go In or come out but after a few tries it would end up working but I've tried everything I could think of I'm starting to think it's something electrical because the relay box isn't getting power to it but idk if a vacuum leak would do that or a bad transfer case motor or iwe solenoid or if it's something more like a broken wire some where.
View 1 Replies
I'm trying to get friend's 04 F150 4x4 started. I think it might be the ignition switch. Here's what I've done. Turn the Key and nothing happens. Not even a clicking sound from the battery.
-verified the battery had a good charge and that terminals were clean, connections were tight.
-checked the fuses in the passenger side kick panel, none were blown
-Determined there was power to the primary Pos wire going to the starter , but no power being sent to the smaller wire that goes to solenoid at the starter.
-Hooked a jumper wire to the starter solenoid and engine did crank (so starter is good and battery is making good connection)
This is why I'm thinking its the ignition switch.
1) Where is the ignition switch located?
2)How can I test the ignition switch?
3)Could it be the "cylinder lock and keys" that is faulty?
View 5 Replies
My friend (yes, really, a friend, not me) parked her 2004 Dodge Caravan in the driveway the evening before. The next morning it would not start. No crank, no grind, no click, and no dash lights, nada, nothing. She took it to the shop she's taken the car to for years for repair and maintenance. She trusts them. They've replaced the battery and run a full diagnostic on it, but are unable to solve the problem. The shop is telling them her it could run into the thousands just to figure out the problem. What could they be missing?
View 4 Replies
I have a 2000 LS, V6, that won't start, had the battery and alternator checked and are fine, last week i notice when I turn the switch to start up there was a 1 or 2 second delay then it would start, the other day the wife called me at work to tell she she was out and it wouldn't start as I was talikng to her she tried it and it started right up, didn't do it again until this morning, check the fuses and all were ok, it started 2 times then about 30 minutes, nothing, and i mean nothing, the security on the dash doesn't indicate a problem, I turn the switch everything lights ups as it should, everything works(radio...etc.) go to start and nothing but click, sounds like it comes from the fuse/relay box under the hood, starter maybe? relay?
View 3 Replies
About 2 weeks ago, my jetta decided it didn't want to start. Was getting symptoms of a bad ignition switch prior to this. Could get it to start one by jiggling the key. Replaced the ignition switch and now could hear the starter relay click but still no start. Yesterday, installed a reman starter and got it to start once. Could here the solenoid click when trying to start. Was reading on here or somewhere that it my be my power control relay, so took the top off to look at it and it was fine. Battery was down about 100 amps so it was replaced and still no start. Going to go see if my vag com will talk to to the ecu. Thinking about pulling the starter out and having it tested.
MK2 are so much easier.
View 1 Replies
My 2004 Honda Accord V6 got a new Diehard in 10/2010. AAA says it is not the battery or the starter. When I turn the key there is a click and all the electrical components turn on. What it could be?
View 5 Replies
I installed an EP27 electronic turn signal relay and changed the tail bulbs to Sylvania red 3157Rs in our Exped and everything works fine. I installed another EP27 in our Excur and the relay starts clicking when nothing is on and nothing else has been changed - all stock bulbs and working fine before.
No lights are blinking, but the EP27 turn signal relay is clicking away. Select left turn, right turn or hazard lights and they blink fine. Deselect the lights and the relay continues to click. Swapped the relay from the Exped to the Excur and it clicks, too. Reinstalled the stock turn signal relay and all is fine. There must be some difference or problem in the wiring, it doesn't make sense.
View 14 Replies
I just bought a 2004 hyundai accent 1.6L standard transmission on the 13th of June, ran great drove it everyday, was driving fine when I came home monday night, went to drive it yesterday and get nothing, turn the key no click, no crank, the radio turns off as it always did when you try to start, I checked the fuses, and the battery shows twelve volts on the meter, what could cause this to abruptly happen?
View 3 Replies
My son has a 2001 explorer sport that he keeps at college. The vehicle sits alot more than it runs these days. Recently it some times does not want to start, no click when you turn the key. He got it home today, and after I changed oil, it would not start. I have no ground to the starter relay in the power distribution box.
I have no electrical schematics, where the ground for the starter relay comes from ? If I remove the relay and run jumper wires from the box to the relay, i can make the vehicle crank when i apply another ground source to the relay....but it just cranks, will not start.
View 10 Replies
I have a 2002 F-150 xlt 4x4 5.4l V8, 96k miles. been sitting about 3 weeks i went to start it and nothing.. thought ok jump. We tried jumping/charging the battery nothing. then we switched batteries from running car same thing when i turn key just hear a click in dash. battery light remained on even when we swapped out. The theft light was off as well.
View 1 Replies
On my way home from work today I could not believe my eyes when the Hybrid Warning Light came on…yes, the RED TRIANGLE! I was just cruising down the highway and I heard a relay click and then I saw the warning light illuminate. Also I noticed the A/C air started warming up, the fan stayed on though, so I am guessing the computer shut off the compressor?
View 15 Replies
I have a real nice 2000 excursion v10. All great then dead, worn t start. The starter goes click cross starter it goes click, cross selonoid goes click. My anti theft light goes out. Battery is good fuses are good it just will click..could it be the ant theft needs to be reset and if so how would i do it?
View 1 Replies
I have a 2000 ex 7.3 and a couple of days ago I had the batteries die on me. Quick boost and it fired right up, drove it around for the rest of the day no issues at all. Yesterday I had a really hard time with the first start of the day, turned over slowly, but caught itself and fired up. I plugged in my OBDII adapter and fired up Torque on my phone and saw that I had 14.3 V about 30 seconds after the truck started. Took my father to pick up his car about 10 mins away, shut the truck off, and again, it turned over slow, was a hard start.
Drove it around for about 45 mins after that and everything seemed great. Today it won't even start...the WTS light comes on, everything sounds and seems normal, then when I go to start the truck it just "clicks"...Turn the headlights on and try to start it, and the lights don't even dim. So I checked and cleaned the battery cables and the starter cable...still no start. What it might be? I'm hoping that its a ground somewhere but wouldn't know where to being looking..
View 14 Replies
I have a 98 f150 Lariat 4wd Automatic with a 2000 4.6. When i turn the key the only thing that happens is i hear a relay in the fusebox in the dash clicking. I can cross the starter relay on the firewall with a screwdriver and itll start right up. Heres what ive done troubleshooting wise.
1. Checked battery terminals. Fine, it will start with jumping the relay so it seems good with that regard.
2. Tested the relay per the manual. Good.
3.Ohms Tested the white ignition switch box under the dash per manual. Good
4. Voltage tested the Trans Range Sensor per manual. Good.
5. Checked over all fuses, none blown.
6. No theft lights come on.
I figure since it will start jumping the relay that the battery, starter, and starter solenoid are all good. Only thing i cant seem to find is the Starter Interrupt Relay, or any sign of fusible links on the main battery cables. I am really at a loss here i figured one of the components ive tested would be it.
View 14 Replies
