My friend who has two of my old Ex's and her silver '04 shut her hatch window first and then went to close the barn door and, well you know how that goes.
My question is, she has my old 2000 Ex for parts. Can the window be removed from the hatch itself or do we have to swap the whole hatch between trucks?
I think my rear window shocks are shot. Last week when the temps hit -15 they completely failed. Are these a rebuild-able shock or do I need to purchase new ones?
Why do I have a bad feeling that this will be an overpriced item????
I may not be searching correctly...? How the back inside trim is removed from the hatch window. I know the handle has the two Torx screws does the trim pull out or are there clips? Don't want to break any plastic parts. I found how to fix the back lock. I found the back barn door trim removal.
View 2 RepliesDoes the rear hatch come from the factory with a different key than the ignition? My key will not open the rear hatch lock, it doesn't even go in the whole way.
View 4 RepliesSo I hooked up to the camper on Friday, threw some gear in the back off the Ex and hit the road. 4 hours and a couple hundred miles later I set up the camper and tried to pop the rear hatch. It's a no-go. It appears that the passenger side latch is releasing but the drivers side is not. My tool selection is limited since I'm on the road, any tricks to get the hatch open? Probably just deal with it till I get home since I don't want the reverse problem and not be able to get it latched again.
View 3 RepliesWell I have had my T-Reg for 24 hours and only have one issue. The rear window on the hatch will not open. We read the manual multiple times and it states you just unlock the hatch and than hold the button underneath the wiper and it should open. No luck. Looks like it could be some electrical thing.
View 1 RepliesOk, rear latch handle, the black trim around it?
My idea was to wet sand it in place and repaint it. Does that sound like a good idea?
What kind of paint / clear coat to use on her?
I've noticed that when I lock the truck, the rear hatch stays locked most of the time. I have to manually lock it with the key if I want my truck to be secure. When it does work, it doesn't sound weak. When it doesn't, it's silent. Where should I start looking?
View 9 RepliesWeather is getting colder and I need defrost every morning. Rear defrost doesn't work, and I found this when I opened up the rear body panels
Driver Side
Passenger Side
I cleaned both sides on the loose contact with sandpaper, cleaned with alcohol, and then superglued back together. Will the superglue allow enough electrical contact for it to work? Is there a better adhesive or way to fix? I want it to fully cure/dry before I fire up. Hopefully in the morning my fix works.
Experienced, rear window shattering after you shut your hatch? Weather conditions: Snow, unsure of what the temperature was at the moment, but i was brushing snow and scraping ice off my window.
View 5 RepliesThe rear hatch on our ex, is starting to dig into the fiberglass of the barn doors. Paint is already gone, just white fiberglass. This wasn't an issue was first, however we have been opening and closing it quite a bit more than we used to. How to resolve this issue?
View 14 RepliesSo yesterday I tried to tackle this project. I soaked the latched in penetrating oil got it all loosened up were I could actually lock it with the key. So tried it with the key fob and no lock or unlock. So I pulled the actuator out and did the "tin foil" trick. Still wouldn't work. Didn't push the lock far enough to Lock the glass. However, it did move the latch. So I went down and purchased a NEW one from auto parts store stuck it in and whip-bang-boom it don't work either. As it don't push the lock far enough to lock the glass.
Vehicle 2000 X 4x4 w/ v10 Yes lock moves freely with little effort
Having problems with the vertical rear hatch window shattering? Mine is completely shattered, only the tint is holding it together. I can't see a single impact point (and don't think I backed into anything). It looks like a network evenly distributed over the entire rear window. But maybe this is the way safety glass breaks when it is hit at one point???
View 4 RepliesIt's not the lock, it's the linkage. The actuator has been replaced and still can't lock/unlock it. Using the key is really tough to turn, but it will with enough force applied. Last summer I sprayed it with lube and it worked for a while, now we're back to square one. It's really clean, just acts like something is bent/worn.
View 6 RepliesSince I bought the Ex last December the rear lock worked sometimes. The key cylinder wouldn't turn, but the actuator would work from time to time.
So since it is hunting season and I want to lock up the Ex when I am in the field I dug into it tonight.
I want to know how do I remove the actuator from the handle/lock mechanism. It looks like it just snaps on. I pulled the actuator back a touch and the arm feel off that drives the lock mechanism.
So after pulling the handle and trim piece, removing the lock cylinder and hosing it in PB blaster and brake kleen and more PB blaster I now have a lock cylinder that turns freely.
After turning my attention the lock mechanism and flooding it with PB blaster, I now can lock the Ex. That mechanism is not a smooth item! So do I need to remove the complete lock mechanism assembly to remove the actuator? Can I buy an actuator with a metal arm?
While sitting at the heliport waiting on the rain to stop I noticed my rear window is leaking right above the sliding window. I'm kinda worried about this while I'm offshore because I have a power sliding window and I don't want it to ruin anything that moves the window. Do these trucks have a problem with this and where do I start to look at to fix this?
View 2 RepliesRear passenger window will only go up. I tried new motor, same problem, swapped switch with other back door the problem stayed on the same side. Drivers main switch to that rear window does same thing, up but not down.
View 12 RepliesWhen i try to use rear window washer the fluid comes out on the front window with front wipers not activating and rear one moving. The front washer works fine. The hose was disconnected above the headliner.
View 12 RepliesHow to get the struts off the rear window of a 2002 excursion?
View 14 RepliesMy passenger side rear vent window is leaking and I was gonna redo the weather stripping but I can't figure how to release the latch from the motor. It looks like a ball and socket type connection with a little wire clip in it, but I tried pulling it out and it wouldn't come out very far, and tried pushing in in more but no luck. I don't want to break the darn thing for sure.
View 9 RepliesSo the rear defroster tab has popped off the window. I purchased this kit from O'Reillys but when I clipped the wire back onto the tab it popped the tab right back off. I even waited 48 hours instead of 24 so it had plenty of time to set, even with the cooler temperatures. Okay, so I forgot about it until I took the stroller out and noticed the trim laying in the back of the X... but still, plenty of time to bond well. I'm thinking of calling a glass shop & seeing what they'll charge to reattach.
View 2 Replies