Ford Excursion :: 2003 - Transmission Fluid Leak Near The Front Passenger Side Of Truck
Mar 20, 2016
2003 Limited 6.0 130K. Just took a 1000 mile trip for spring break. While away, I noticed a small leak near the front passenger side of the truck. It is red so I assumed it was transmission fluid. It is leaking from, the best I can describe, a small housing that looks like it might be a filter near the tire (it looks like the old style canister oil filter housings). All the hoses are clean and where the hoses go into the radiator are clean. Is this an easy fix? I am a bit worried about trying to get the thing off without damaging the hoses.
View 3 Replies
Advertisement
Its been awhile since I have been on. Everything has been running great for me until I found my passenger side front axle leaking fluid. I'm sure something has been posted on here but I have limited access to internet right now and need to know what I am getting into to change the seals. From what I have found there is an inner seal in the pumpkin and then an outer seal and dust cover. Are both of these easy to change? Are there any special tools needed? Do I need to remove the gears in the pumpkin? If so, is this difficult and any special tools required for this?
Mine is a 2001 V10-6.8, 4x4 no mods at this point.
View 14 Replies
So I went outside yesterday, an hour after getting home from an hour drive. I find a PUDDLE of transmission fluid under my car. The only place WET under the car, however, is under the passenger side (where the antifreeze is). When the flat bed tow truck arrived and lifted the car onto the truck, there was a line of fluid that leaked out where the car was pulled onto the bed at an angle. When I spoke to the mechanic this morning he said he can't find a leak anywhere. My transmission fluid is full as is my antifreeze. So where did the leak come from and why isn't it happening now?
View 2 Replies
I have a 2006 sonata 3.3 with auto trans I'm having trouble with fluid leaking from the passenger side axle seal. I have already replaced the seal with a Hyundai seal and it is still leaking. Not as bad as before but it leaks onto the exhaust and smells really bad. The transmission is not overfull...
View 2 Replies
I have recently replaced the clutch, clutch master cylinder, clutch slave cylinder, Strut tower mounts and brakes on my 2002 Hyundai Elantra 5 speed. Everything is working properly but now I have a transmission fluid leak. I can not locate the exact location. It appears that it is dripping down onto the passenger side half axle where it connects at the transmission.
View 2 Replies
My 2005 Prius has a slow fluid leak from the driver’s side front transmission cover. My dealer says their books do not provide a repair for this and recommend replacement of the hybrid transmission (~$2800).
View 9 Replies
I have a 2003 Expedition with a coolant leak on the front R/H side of the truck. I do not see any coolent lines on that side of the truck and the leak seems to be running off of the A/C compressor. I notice a couple of drops about the size of a dime about once a week in my drive way since x-mass and have NOT had to add any coolant. I was getting ready to do a flush and fill but now have concerns that it may have a bad head or head gasket. The truck has 84000 miles on it and never has been overheated.
View 1 Replies
My '02 F150 just developed an oil leak. It appears to be coming from the passenger side front. I'm just assuming here, but could it more than likely be the timing cover? I'm 150 miles from home and I'm debating on getting the timing cover gasket on my way home tomorrow. Also, if it is the timing cover, what other gaskets should I replace? Pretty sure the water pump oring.
View 1 Replies
I have a f150 with a 5.4L with 354,000 miles on it. It started leaking water somewhere on the front of the motor on the passenger side. it looks like it is under where the heater hose connects to the intake. I guess my question is can the water eat a hole in the intake?
View 1 Replies
My new/used 2000 4x4 excursion with 214000 miles on it has a transmission fluid leak.
It could be a rear portion of pan gasket but it seems to be coming out of the area where the transmission bolts to the extension housing.
I just put a transfer case in it. Thought all the fluid all over was due to exploded T case.
It seems the output shaft seal may be bad. I cannot seem to find an OEM part number for this seal.
What is part number for this seal, if one exists? Maybe the seal is in the extension housing and it's just the gasket between Trans and housing.
View 8 Replies
Have a 1998 F-150....heard a strange noise coming from the front passenger side of the truck. Parked and turned the wheel and heard something fall off. It appears to be a shield of some sort.
View 2 Replies
My 7.3 has a leak on the front diff passenger side. It went into a shop for repair and they did both seal but the passenger side came out with a worse leak than it went in with. So just looked this morning and small pool of oil under the ujoint area on the concrete. Its booked in again to be fixed under warranty repair (place that fixed it, repair came with 2yr warranty) on Wednesday next week - was the earliest I could get.
Question - can i keep driving the truck? I'm making a wild assumption that I can unless I use 4 wheel drive. My intention was to just keep topping up the diff to ensure there is fluid in it. It's the work truck so wouldn't be good to be without....
View 10 Replies
2003 F250 7.3... I noticed a water leak dripping down onto passenger side front leaf spring. I saw this before but attributed it to the AC (which kicks butt) but haven't used the AC. No scent to the clear fluid, temps all look good. Running fine. Where does the AC discharge go? Could AC be on (not on AC but set in blue zone on dial)? Reservoir looks ok but could e small volume of drips.
View 12 Replies
On my 2003 Excursion 7.3L, I notticed I'm leaking what I think is coolant from the passenger side rear hard line by the front spring hanger. I haven't pealed the plastic loom away yet, but I did see the loom is chaffed near the spring hanger. What lines are the ones that carry coolant, and can I just cut the hard lines and replace with a section of rubber hose?
View 3 Replies
I bought a 1990 ranger with only 38000 miles on it from a online auction from boing aircraft. it never left the flight line and never even had a title. I picked it up from the airport and found out that it didn't have AC like they said, I was a little ticked but that isn't the main problem. When I drive it and it gets warmed up it leaks Tranny fluid from the front of the transmission. The engine does not overheat. It is a 4 cyl AOD automatic with a real thin radiator and a transmission cooler. Without AC the truck isn't the good deal I thought I was getting, and with a bad tranny this is becoming a big OOPS. Why this is happening?
View 3 Replies
We bought the X like almost year an a half or two years ago. Since the day we bought her shes had an exhaust leak on the pass side. Ive been a mechanic forever and it didn't bother me at purchase. Well I finally get around to it this last weekend. My son and I get to repairing her on saturday. Well we got manifold off with the intention of ordering a new set of headers. Well Luke talks me into just replacing the broken stud (got lucky only had 1 on the pass side). And replacing the gasket. So I took the manifold to get resurfaced,got the new studs and gaskets.
We reassy everything. It went well, start her up and wow shes finally quiet. I love it. So were sitting there admiring our work (took most the day as we had to drive 40 minutes away 1 way to get parts and angle drill alone). As were sitting there chattin for 5 minutes im like do you hear that.....Its getting louder luke WTF.....WELL IN 5 MINUTES THE DAMN LEAK IS BACK... It sounds like its back at the original place but while listing with a hose it sounds like its also at the y pipe. But the sound can be traveling......
I def am not a fan of Autozones felpro gaskets but they have worked in the past. But they look NOTHING like the factory units but still should work. Well I searched all weekend and read tons of posts on what to get. As I def want to replace the y pipe also. In the end said ok,what the hell. I just got off the phone with BANKS. I ordered headers,y pipe,gaskets,etc. I didnt want to spend that much but after pricing headers (from all manuf's and a new y pipe) the BANKS complete system wasn't much more...
Kit should be here tomorrow or wed at the latest. And I just want my X to be exhaust leak free. Im not big on taken pics during install of stuff but ill try and ill post up after it done.
View 14 Replies
So I had a stuck caliper on the driver rear side. I pushed the piston back and checked everything to make sure all was in working order. After some though and reading about the calipers getting stuck which old brake lines, I decided to upgrade the line with the Russell stainless steal lines.
I got all the lines put in but I seem to have fluid leaking on the passenger side fitting which I can't seem to get to stop. I put the old line back in but it is still leaking. I am not sure what I need to do or check to get it to stop. It seems to be leaking from the thread area. I checked the fittings and they don't look cross threaded so I don't understand why it may be happening.
View 3 Replies
So broke down today and have no tools, in a city I don't live in. Huge coolant leak behind the block on the passenger side. Luckily we broke down right at a mechanics shop. They need to take off the manifold to get to the rusted out metal piping in back.
I am new to the V10. Looking for information on what could be leaking back there? I know I could do this myself but I need to know what parts I might be dealing with first. And its tight quarters back there.
View 12 Replies
My power steering seems to have sprung a leak. There is quite a bit of fluid below the passenger side of the steering rack. The leak seems to be right below where the power steering hose comes down off the pump, gets secured to the chassis and changes to metal line from rubber. The metal line then goes into an L bend and is routed towards the driver side right where the leak apparently is.
I haven't had a chance to have a good look, as it was 10:30 at night when I parked it and looked (12km of careful city driving since it started to act up)
Is this a high pressure or return line?
The leak seems to be forward of the steering rack, so hopefully I wont have to replace it.
View 8 Replies
I have a 97 ford f150 v6 2wheel drive. I was driving to work when l heard rattling in the engine like something came loose when I stopped to check my transmission fluid was pouring out drained out in 2mins tops. What do you think it could be?
View 6 Replies
I just recently had to replace the extension housing on my truck. Well after doing so I went to start it up and top off the tranny fluid and it started to leak out on the left rear side of the transmission near the extension housing. Ive looked and looked and found that the fluid is coming from the top right in front of the extension housing but when i clean it off there seams to be no holes or cracks. It isn't the housing seal, cause it pools in front of that. What could be the issue? My truck is a 01 F250 4X4 5.4L.
View 4 Replies
