Ford Excursion :: 2002 XLT Turning Over Slowly When Starting
Oct 14, 2012
We have a 2002 Excursion XLT. 7.3 liter diesel. Edge chip.
It started turning over slowly when starting, and before I could take it in, it stopped starting completely. We tried jump starting it, nothing. the batteries seemed okay, so we took the starter down to the auto parts store and had it bench tested. It tested fine. We didn't think it would be the starter, since it is just under two years old. Didn't think the alternator was at fault, since it is a year old.
Purchased a new relay and installed it in the inside fuse box, nothing. We purchased two new batteries. After we dealt with rapidly flashing 'theft' light on the dash, it started up. Thought we had solved the problem. A couple of days later, slow to turn over when starting again. The next morning it wouldn't turn over at all. Tried to bypass all the sensors and relays between the ignition switch and the starter by connecting a wire between battery and starter. Nothing.
Had starter bench tested at a different store. It worked intermittently. Replaced the starter. Nothing. But when we hook up the battery directly to starter with key turned it turns over AND starts. Assume it something in ignition switch or a relay between ignition and starter. Bought a manual, but it doesn't show where to find relays. When I check trouble codes, I have a p1000, a p1260, a p0603, and a p0674.
View 8 Replies
Advertisement
I have 2002 2.0 Jetta that I totaled. I found a 2000 2.0 Jetta that had no engine or tran. I swapped the entire wiring harness with the engine and trans from 2002 into 2000. I even swapped the doors. The cluster, steering column and all. I am still in the process of getting a few parts to finish it up. At this point, the only thing not hooked up is the headlights and the radiator. I hooked up a battery and tried to get it to turn over today. I turned the key to the on position and the cluster did not do anything. The engine turned over very slowly in the start position.
View 21 Replies
Grinding feeling, and noise from rear of 02 explorer xlt. only noticed when starting out from a full stop and turning. It feels like something is grabbing like the rear brakes. I purchased this suv of a local dealer lot, because it was so clean and on a short test run seamed fine.
The day after I picked it up I took it for a shakedown cruise to see if I noticed any problems. After going up a few forward grades I noticed a disturbing rattling noise coming from mid under carriage, and got very worried. I immediately took it to a local well revered mechanic. They eventually had it for 4 days in order to diagnose it. After the dealer had done the inspection on the car and passed it, that all rotors and pads needed to be replaced, left front wheel was locked up, inspection sticker month was never punched, both front tires were bad and either the flex plate or tork converter or both needed to be replaced. I took it back to the dealer with the report and he agreed to fix it with me paying for parts. He did and the rattle was gone !
Yet now I have noticed the problem mentioned at the beginning of this piece, plus the rear wiper does not work. I think I got taken for a ride, which may become a longer ride than I thought. All I want is a reliable car. what could that rear noise be ???
View 5 Replies
Having some problems with my truck.... First off I bought a 2002 excursion and drove it for one day. Then I was at the car wash cleaning up the truck. Then I saw the window fogging up so I turned the car off. Now it won't start.
I had previously installed a new stereo, but had some problems, so I ran the remote wire to the fuse box, because the wire in the harness wasn't getting power.. So after a little trouble shooting we found out that the fuel pump wasn't working or was bad.
We replaced it, now it has pressure but will not start, will start with starting fluid but will not crank on its own. someone told me it may be a bad PCM? and a dealer can only replace it... I don't have tons of cash, as i bought this truck on 8/30/12 and this happened the day after i bought it.
The previous owner has paid or the fuel pump replacing but I don't think its right on my part to have him pay more money as this may be a mess up on my part with hooking the radio up to the fuse box... we have tried the fuses,realys, crank sensors...
View 6 Replies
My 2002 4.8L Silverado recently started having this intermittent starting problem.
A few days ago I got in to start it, turned the key and nothing happened. Lights, radio and power locks all were working fine but engine would not crank or turn over. Turned the key off and on a few times and then the truck started fine.
It started fine for about 3 days. Then got in to start it the next day and this happened again. Turn the key and nothing. Lights, power locks, radio all working ok. Turned the key off and on multiple times but still nothing. So I cleaned the battery cable connections and fully charged the battery, even though it checked out ok. Tried it again and same thing was happening.
This time I looked at the ignition and starting relays under the hood in the electrical box. I swapped a few of them around, tried to start it each time and still nothing.
So I had the vehicle towed to the dealership to be checked. The next day the service man calls me to tell me when they went to check it, the truck is starting fine.
I am not sure if this is a starter problem, ignition switch problem or maybe the computer. The thing is, I can't drive it like this because it is no longer reliable.
View 7 Replies
2002 Excursion 4x4 7.3. I've read about this on here before but I've forgotten what the problem is. When the wheels are turned and the vehicle is going forward at some speed, there is a knocking sound, like a ba-doomp ba-doomp ba-doomp. Does it in both directions, sounds like its in the front hub area. I don't have the time to fix it myself, how much should I expect to pay a dealer and/or independent shop to do it?
View 2 Replies
Got an '02 here. This noise started to appear recently. When I turn the key to put electricity on (without starting the car), I hear this electric motor-like sound, similar to power window sound, coming thru the dash area, and it can also be heard outside the car coming from somewhere in or near the engine compartment or in front of the dash/windshield area. Could this be one of the servo that operates the AC vents? or its something else?
View 1 Replies
My driver window is VERY slow up and down, sometimes the window stops midway thinking it is hitting something because it is straining do hard, is this the motor dying, or does the window need to be greased?
View 14 Replies
Today I was driving my 2005 Honda CRV when suddenly the car starting revving up while slowly stopping. It would not move after that. Car still reved up while stepping on the gas. Had to be towed to a mechanic. They could not look at it today.
View 12 Replies
So I went to Target with my wife yesterday and after about 30 mins of shopping, left the store and tried to start the Ex and will not start. The engine tuned over slowly like the battery did not have enough juice to start the truck. So I had it jumped and it started right up. So I went to autozone and the battery and alternator tested and both and in good working order.
Today it happened again. After stopping at a fast food joint to grab a quick bite, same thing it did not start. But before I started the truck the voltmeter showed about 12.6 volts. When I tried to start it, the engine turned really slow and did not start. By that time the volt meter showed about only 6.5 volts. So trying to start it just drained the battery. I had it jumped and it started right up. Went back to Autozone and had the battery and alternator tested and both are fine.
Once the truck is running, the volt meter shows ~13.5 - 14 v volts. No other electrical issues while driving. What's happening? What should I check for? The battery is about 3 years old. I will charge the battery over night and see what happens tomorrow.
View 11 Replies
Is it normal for the engine to start at 2000rpm and slowly drop?
View 10 Replies
I have a 2011 sonata with the 2.4 liter 4 CYL motor and auto transmission. It has 61,600 miles on it. Just out of warranty...awesome.
In the last few days I've noticed it has had issues starting. For instance, when I got into the car and started it for the first time in the day, it starts up fine. Then a few hours later, I start it again but the engine will just spin slowly...I then turn the key back to off and then turn it again to start. It then will start up fine on the next try.
No check engine light or any sounds I can feel (I am Deaf so I cannot hear any sounds when it doesn't start) new battery in August of 2015. When it doesn't start, all of the dash lights come on.
View 8 Replies
So just last night I began having a small issue with my R32. While idling, the RPM's slowly starting getting lower to the point where the car almost stalled, probably in the neighborhood of around 300rpms, then it would slowly increase back to normal idle. It did this a few times then while driving and a steady cruise of 35mph I felt a large power loss for a second or two. This repeated a few times until I got home and parked it. I also noticed that the RPM's would fall much, much faster between shifts than normal during this episode. I drove it a short distance today. It it showed no signs of the same problem. Any possible causes?
View 4 Replies
1994 Caprice Classic (350 cid LT1)... Engine cranks very slowly, almost doesn't start, sometimes starter disengages/re-engages. 1year ago mechanic checked batty, alternator and starter, all ok. I had starter replaced as it seemed the most likely cause. Eventually got better but now is worse again. Also notice a lot of movement on the dash voltmeter needle, sometimes high, sometimes low, turn signal moves the needle. Ive spent hundreds of dollars on troubleshooting and the new starter. What could be causing this?
View 4 Replies
As the topic says, I get a slight stutter in the car when I'm say parking into a parking spot. As I get closer to 0 mph i feel the car kinda jerk a little bit.
It's done this since we bought it off a used car lot, and I figured it was the tranny fluid being burned or low. I did a drain/fill twice over the last weekend, and noticed while it has worked forthe issue, it's not fully rectified.
I also notice that 60-80% of the time when LIGHTLY accelerating, going from 1st to 2nd is kinda rough. If i floor it, it's actually pretty smooth.
It doesn't feel like anything "BAD" is happening - no grinding, doesn't feel like slippage...
View 5 Replies
I recently acquired a 2000 Golf GTI 1.8 20v that came with a few preexisting issues, one of which being that the alternator will not charge the battery. I've checked my voltage while running "starting with a full charge" and it slowly but steadily declines from 12.09 to 11.0 over a 2-3 minute time span. On the dash the battery light is on and never turns off and my radio does not work at all "even with a full charge". I have already replaced my alternator, battery, battery cable, and the two relays in the engine compartment. The relays in the engine compartment were causing a "ghost" amp draw but that has been resolved. I do not have a 109 relay as I have read that this could be the culprit, when I examined the "under-dash" panel I found that my panel does not have one. I have also replaced the 30amp fuses in the engine compartment fuse box and cleaned the grounds.
View 11 Replies
Whenever I turn the wheel there is a ticking that seems to be coming from the front wheels. You can only hear it with the windows down and going slower than 10 mph. The rate of ticks seem to speed up or slow down depending on how fast I am going around a corner. I don't have a lift at my disposal and don't particularly love going to the dealership.
View 14 Replies
My mom wants to sell her 2002 Ford Explorer w/ 4.0 as enough kids have moved out that the vehicle is no longer needed. It has 162 000 mostly trouble free miles on it. However, for me to sell it for her, I need to get it running well first. The background:
Just recently it fried the alternator. No big deal, got a reman for my dad and he put it in. But now it has this sort of "shudder" at idle and low rpm, and also when accelerating slowly low in the revs. I don't know if it was there before or not because only my siblings drove it, and their not exactly observant. I am positive it is a misfire.
So far I have done the obvious. I have pulled all the plugs, they are nice and tan, re-gapped them (although they were only .002 out of spec at the most). I noticed that one plug wire was broken on the inside, where it connects to the plug. Thinking I solved the problem, I bought a new set of wires and put them on. No such luck however, as the problem continues unchanged. On the new wires, I have verified tons of spark making it through. In an effort to isolate the bad cylinder, thinking maybe it was actually a plug, I started pulling wires off the coil with it running. I could barely notice a change in the engine with any of them, and a couple seemed to have no change at all (again, I may just not have been able to detect it because I could barely make out the other changes).
Next, thinking maybe it was fuel related, I put a stethoscope on some of the injectors and they sounded the same, but I can not get at the back passenger and 2 back driver ones. How else can I test these?
I even went so far as to unplug IAC, engine died immediately so its not that. I also took off the EGR valve and cleaned it, and pushed the plunger up and down lots and it moves freely. I tried pulling off the vaccuum line from the EGR with the engine running and there was no change, but that doesn't really mean anything does it?
So I put it all back together and thats how it sits for the night. On a related note, the CEL is on, but it is on more often than not on that thing, and my dad has taken it to a dealer three times to have codes read and nothing ever shows up. The mechanics keep saying that it has something to do with the fuel cap and pressure or something.
View 9 Replies
Have a '02 f150 and thinking the heater core slowly dieing. Have noticed for several weeks a nice line of water leaking onto the passenger side floor. Do you have to take off the entire dash to get to it? Will be doing replacement myself as the dealer or shop would probably kill me on labor.
View 12 Replies
Just recently bought a 07 Nissan Maxima SE. Has a few issues.
The car sun roof does not work at all. It worked the day I bought it though.
Has issues turning on. Cranks slowly then after a few seconds of struggle it turns. Didn't have this issue when I bought it.
Goes idle when first starting to drive. From park, I put the car in drive, or reverse, and let go of the brake, it basically does nothing. Engine is on as if it were in park or neutral, but the car doesnt move. When I press the gas it takes a few seconds before it decides to actually move.
View 2 Replies
When I'm driving slowly and turning over a dip or bump, like driving out of a driveway while turning, I always hear something in my steering assembly clunking. Is it something I can tighten up, like a bushing? I know it's not the usual the abs system clunk, and it's a different sound from the echo inside the tires one may hear at low speeds.
View 1 Replies
