Ford Excursion :: 2002 - Overdrive Stops Working When Hot?
Jun 10, 2017
I have a 2002 7.3 ltd X with the 4r100 transmission. The trans shifts fine until it get over 160 deg (glow shift gauge in test port) Then the OD stops working and get no engine braking until I turn off the OD. when od is turned off, appears to shift OK. When the trans temp gets below 150, I get the OD back. The OD light did flash on 2 occasions but no code while engine on and light flashing but OD was working at the time. after shutting off engine and restarting light stopped. New fluid and filter, torque convert was flushed also and X has larger 6.0 trans cooler. Tran did get hot once while towing 4 ton trailer 240 f, thus bigger cooler. what would cause the OD to go out when above 160 f but come back when cool?
View 7 Replies
Advertisement
I have 2005 ford excursion with 24300 miles. My speedometer is not working, engine light on , abs light one, overdrive flashing. I just changed speed sensor on rearend, but my speedometer still not working.
View 4 Replies
I have a 02 ford explorer sport trac the overdrive is not working and I have fixed the wire in the steering column and the neutral safety switch and it still does not work. What it could be???
View 3 Replies
2002 Escape. The over drive deselect button stopped working on my wife's escape. Is their a fuse other than the box under the hood? Transmission was rebuilt not too long aga and has been running fine till the other day.
View 2 Replies
Fuse 29 was blown when I got my truck, automatic headlights and overdrive lock didn't work. I replaced the fuse, the lights came on and overdrive locked out but when I shifted into park the doors locked and the fuse blew. How the door locks are related and why they would lock when shifting to park?
View 2 Replies
I recently bought an 02 Excursion. The front seats have been swapped to Lariat seats. (I'm assuming to get the 40/20/40 seats which I love considering I have 7 kids and need to haul 9 people.) When I bought it I noticed right away that the power mirrors don't work. Noticed a few days later that the rear speakers weren't working either. Under the driver seat (its power and heated seat) I found the connector that went to the rear audio controls on the previous console.
I spliced the wires for the rear speakers and they are working now I tried replacing the switch for the power mirrors and still nothing. Could this problem be related to the seat swap or is this a total separate issue? I've got to get a new test light to check for power to the switch...the bulb is blown in mine. Assuming that I check the power wire (orange w/ light green, right?) and it is fine, what's next?
View 3 Replies
I have a 2002 excursion xlt 4x4 v10
The door locks quit working. The previous owner did the tin foil repair... I replaced the four door actuators today. Now all of the doors lock and unlock on the manual buttons. The fob doesn't work on any door.. when i try and use the door code pad, the locks go into a cycle.. the keep trying to operate by themselves. I had to disconnect the battery to get it to stop. I can't find the door lock relays. I have most of the dash out. Where these are?
View 12 Replies
The ruck is a 2002 Ex limited v10 4x4. The cruise worked fine till my wife drove the truck! the green cruise light blinked a few times, now, there is nothing.I'm no good at electrical issues.
View 3 Replies
Wife just told me tonight that the overhead console and rear heater are not working in the excursion. Of course, we have a 3 hour drive tomorrow and it is cold outside.. The posts seem to center on either the readout not working or the heater not working, but not both. Trying to minimize time troubleshooting outside in the cold.
View 4 Replies
My 2002 Excursion was rear ended. Body shop replaced the bumper. I noticed that the reverse aid was no longer working. I checked and noticed that non of the sensors were working. It was working before they replaced the bumper. If the speaker is out, would the four rear sensor still tick? I find it mighty strange, that it worked before and after the accident. Now that they've replaced the bumber, Every time it's placed in reverse, the light comes on.
View 4 Replies
I just bought an 04 excursion with the 6.0 diesel. I took a trip to vegas and noticed a humming/ vibration about 55-65mph only in overdrive. i have checked u joints and they look good. The x does have a small lift its the bracket kit with stock springs. What gets me is, I don't notice it driving in town only in overdrive at highway speed.
View 8 Replies
I have an unmodified 2000 Excursion 7.3. with 239000 miles on it. My transmission started to slip in overdrive. I could turn off the OD and it would run fine. I was in upper Wisconsin headed home to Georgia and figured the cold had something to do with it. Drove sixty mile with OD off turned it back on shifted fine and drove 750 mile to Paducah, KY stopped to eat and it started down the road and it slipped again.
Drove 45 miles stopped added 8 oz of tranny fluid and it drove fine back to a friends house and after I dropped him off and headed home it started again. The tranny is serviced every year, new filter, drained torque converter. I use Amsoil Synthetic ATF. I have used the truck to tow a 10000lbs trailer over 65000 miles. I was not towing when this occurred. What is going on? I guess what I am asking is my tranny about to become toast or am I looking at something that can be fixed easily.
View 14 Replies
This might be a dumb question but the light for my overdrive is blinking and it won't stop. I tried pushing the button on the end of the shifter but it still blinks. No codes are triggered. This is on my 2000 7.3l 4x4 limited. I haven't check the fluid level yet. Just got home from an exhausting trip. Here is a picture.
With it on ....
With it off ....
View 14 Replies
My X has started shuttering in overdrive this morning. I have taking it out of overdrive and seems to go away , maybe a slight notice.....
It did shutter one time at about 2000 rpm while power braking.... but cant get it to do that every time.... possible coil...???
View 14 Replies
I have an '05 V10 with 74,000 miles. The overdrive button on the gear shift does not work and it keeps me in trailering mode. If I put it in park and jostle the shifter and steering wheel, sometimes it works. Also, the back-up sensors no longer work.
View 5 Replies
Today i go out and crank my truck and it fires right up. I notice the overdrive light on the shifter is flashing. It did that a few days ago but stopped within a minute or so. This time i noticed the check engine soon light was lit as well. I checked my scan gauge and it said three codes stored. The first one i looked at was P0705. The truck was running fine the whole time. I turned it off and tried to crank it again.
This time it just turned over and over but would not crank. I cleared the codes before checking the other two codes. I wish i would not have done that but I wasn't thinking straight. I tried several more times to crank but it never fired. One time it tried to but never fully did. I gave up and switched cars. I am going to try again when i get back home. What causing this?
View 14 Replies
So while driving to work I start experiencing some weird behavior with the transmission. It would shift hard and seem like it wasn't pulling hard at all. I looked down and saw the overdrive off light flashing. Got to work, turned the car off then started back up and the light was off. Any thoughts?
View 14 Replies
My 1991 Explorer 4.0 4x4 overdrive not working, so far have checked ohms on sensor at trans and it appears to be ok. Also looking for the pinout of PCM under passenger kick panel to see if voltage is being output to the sensor at trans.
View 1 Replies
My 2002 Ford Explorer has a 4.0 liter engine. The overdrive light on the dash is blinking.......what repair and how much would it cost to expedite that repair? Also the ABS light is on....
View 19 Replies
My son has a 02 - 2 wheel driver xls. His over driver light is blinking on and off. what the problem might be? He has about an 80 mile round trip drive today before he can get it to the dealer. Would he be damaging the vehicle if he drives it that far?
View 1 Replies
My overdrive light is blinking off and on. When I accelerate normally, the truck starts stumbling? (don't know a better word) some, sort of like a clogged air filter or fuel filter. I am going to take it to a transmission shop because its a little beyond me, but don't want to get ripped off.
View 10 Replies
