Ford Excursion :: 2002 - Battery Light Comes On And Off Randomly
Mar 22, 2016
So my dummy light came on the other day, I went ahead and pulled the alternator and had it tested at advanced. It tested bad so I replaced it not my battery light comes on and off randomly. I have a edge tuner on my truck and my voltage reading on there is different after each start up. Sometimes it runs 12.1-12.2 other times it reads in the 14's I have checked with a multimeter also and got the same readings +-.1 or 2.
My dummy light keeps coming back on randomly, I had to replace the alternator connector because I broke it by accident. I also traced the wires as far as I could to check for brakes in the wire and found none with out proper time to pull all the wire loom off. What is the cause I know I could probably use cables soon as my terminals look a bit rough but are clean. Seems to be some really weak flimsy metal. Which fuse to check as my 2002 ex 7.3 only has the inside fuse block and I can't find much online about it.
View 5 Replies
Advertisement
So I have a 2000 6.8l V10 that I recently swapped the engine on (reman). While I was doing that, I decide to do some LED upgrades. I swapped out the turn signals, side marker lights, and headlights with LEDs. I added some LED fog lights, and I have a Rigid light bar.
I replaced pretty much everything on attached to the engine aside from the alternator (it didn't give me any problems, so I figured it was good).
When the truck is running with the lights off, there are 6 LED strips running as DRLs, when the lights are switched on, the side marker, turn signal and headlights turn on. When I switch to high beams, my fogs turn on. The light bar is on its own switch.
During the day with the headlights off, I dont notice the battery/charging system indicator light turn on at all. At night, when I flip the headlights on, I've noticed that it sporadically and randomly flash. The flashing indicator light does not appear to be associated with bumps or anything.
It does not seem to matter if I have just the DRL/low beams on, DRL/high beams+fogs, or DRL/high beams+fogs + light bar on. The indicator light comes and goes with the same random consistency regardless of how much power I am sucking from the alternator/battery. The RPM's of the engine also appear to have no effect on when/how often the indicator light comes on...
I drove for over an hour last night, and the voltage gauge never changed, so the battery does not *seem* to be draining (~1 year old Optima yellow). I added an extra ground wire going from the battery to the engine about a year ago (long before this LED upgrade) to ensure a good ground, so I dont *think* the wires are the issue. Is my alternator suddenly going bad? Any higher output ones I could replace it with? Is it a simple fix that does not require a new alternator?
Here are some pics of the lights:
(This was before the fog light install)
These lights only come on when the truck is in reverse:
View 6 Replies
I have a 2002 Escape XLT V6 4X4. I searched the issue, but others' symptoms don't seem to be quite the same as what I'm seeing. Over the last few weeks, the battery light has randomly come on and off 3 separate times:
- 1st time, light came on at highway speed for about 30 sec and went out. Didn't come back on. Was during daytime, running DRL's, radio (no amp or subs or anything like that, and heater blower on low speed.
- 2nd time was two weeks later or so. Happened at night with just headlights on at around 55mph (RPMs about 2K or so). Again, stayed on for about 30 sec and went out.
- 3rd time was about a week/week and a half later, yesterday morning. Just running DRL's and radio. Light came on, flickered, came on, and then stayed on for a couple of minutes (all at highway speed). I noticed that if I disengaged the overdrive and got the RPMs up, the light would go out. I ran it out of overdrive for about 2 minutes like that, and the light stayed out. Speed limit dropped to 40mph, and the light came back on (lower RPMs at that speed, didn't run it in low gears). Light stayed on for 30 sec - 1 minute, and then went out on its own and has since stayed off.
I took it to Advance yesterday to have it tested, and the results were that it is charging at 13.9V under no load, and 13.87V under a load. The battery tested good, but the machine said it needed to be charged (it hasn't been acting low...car starts just fine).
I'm driving it to work today to see what it does next, and then getting it tested again on my way home. Has anyone here ever had similar symptoms as above? Does this sound like bad diodes in the alternator?
View 5 Replies
My battery light keeps coming on and off, batteries were replaced by the dealer and checked out good at advanced auto parts.
2002 Limited 7.3L
View 4 Replies
I bought a 02 X back in march this year. I have a family of six and its the only SVU with enough seating and cargo room. About a month or so after I got it the battery would randomly die. I could charge it back up and it would die again a couple of days latter. I figured the battery was no good so I bought a Optima Red Top and threw that in. Truck was doing good so I thought I had it fixed. Then it started back up last week again. I could charge the battery and it would be ok for a few days then be dead the next morning.
I picked up a multi meter from Harbor Freight and checked the battery. Battery was at 10.5 volts. Charged the battery again then checked the alternator with the truck running. 14.2 volts. I've checked the connections one the battery, nice and tight not corroded or anything. My next best guess is something is getting left on and killing the battery. How do I go about testing for that? What might be causing this random battery death?
View 14 Replies
Bought an Ex last year with 200k miles on it. Started having issues this summer. First off, it will shake when pushing on the gas. If I let off the vibrating stops. Secondly, if I tromp on it, the speedometer drops for a second then comes back up and the "ABS" light comes on for that split second too. Thirdly, it will randomly die on me. This morning dropping off the kids at school, it died 3 times while backing up. Starts right up, but will just kill, no sputtering.
The Check engine was on, so I took it into Advance for a reading. Computer said there was an issue at the rear output sensor. So, I replaced the Speed Sensor on the rear differential last night. Take it for a test drive, and the check engine light is still on, but the Overdrive light on the shifter is flashing randomly.
Now, I assume the shaking and dying is Fuel related. I am ruling out the spark plugs as it idles fine (maybe I'm wrong). I purchased a fuel filter to replace that and hopefully it works.
View 14 Replies
I have a a 2005 Focus, 199,000 miles. The battery light has been come on randomly. It doesn't seen to be related to any other event in the car. Things I've done to diagnose it...
I cleaned the battery cable connections before I started any diagnostics.
I have two code reader and no codes are being thrown.
I connected a multimeter to the battery while the car was idling in the driveway.
I got 13.8-14.1 volts as the car sat and ran. When the light came on no change on the meter.
I have a Scan Gauge that allows me to watch the voltage in real time. Four days and no change when the light came on. ~13.8-14.1 at idle and ~14.1-14.4 underway.
I have the Car Chip. I plugged it in drove for about 10 runs and the voltage trace was pretty flat on all runs, battery light on or off.
The only thing that is consistent is if the light is on and I rev the engine it goes out BUT they rpm when the light goes is inconsistent.
View 6 Replies
I randomly started throwing a couple codes that have been causing my "check engine" light to come on ... came on on my way into work this morning) . I know that the P0683 code is the Glow Plug Ctrl Module to PCM Comm Circuit (from my code reader), but I am not sure what to do next ... I have the dealer service DVD from 2002 that I will look at this weekend....
View 7 Replies
2002 Ford Focus SE with 130k miles on it. For the past 4 months the battery light flashes randomly while driving. The flashing and frequency of flashing doesn't seem related to anything I can tell including temperature, length of time the car is running, speed or any variable. Seems like it should be an alternator, but that was replaced less than an year ago and it also has a new battery. The alternator always checks out fine at the mechanic and it will never flash for the mechanic. It went 1 month with no flashing and suddenly it will now flash maybe 20 times in a 5 mile drive. Yesterday it just died at a stoplight with no warning, but then after shutting everything off it started just fine and the battery light didn't turn on for the 2 miles to home.
View 5 Replies
I have a 99 f350 7.3l 4x4 and my battery light flickers randomly. I have checked the alternator and both battery's. All brand new and seems to be ok. They only are getting a charge when the battery light is flickering. I put both new batteries in on Thursday and on Sunday I needed a jump at the store.
View 7 Replies
I recently had my alternator and battery replaced due to my truck dying out randomly on me, tested the alternator and failed, replaced battery, and still got the same results, battery gauge seems to drop quickly, what could be going on, I have been told to replace the fusible link that goes from the battery to the alternator....
View 1 Replies
2002 Exc, 7.3L TD, Some one broke into the truck last week by jaming a screwdriver into the door key lock. Tried to pull the ignition out but failed. Pulled the A/V system out, cutting wires and such. So the dealer (insurance covered it ) installed the new door lock and said nothing is wrong with the ignition. But now the dome lights and running board lights come on at random and kill the batteries.
Could it be the ignition? Or something inside the driver's door? The batteries are brand new.
View 6 Replies
My door ajar light & bell goes on and off at random. It's also setting off the alarm when the doors are locked. What might be causing this.
View 14 Replies
i have a 2000 ex,6.8 4x4.every now and then the dome light stays on.theres also a problem where theres a buzzing sound coming under dash while driving and makes the dome light flicker.these are seprate problems.lol.when the buzzing sound is present ,it stops when i open the door,running or not.but starts up again when i close it,even happens occasionaly when ignition is off and no key in ignition.electrical problems are my worst night mare!!!!!!!! My battery is dead in the morning when this is happening .oh yea,and the o.d.light flashes occasionaly as well.im totally lost.
View 6 Replies
I just noticed this happening the other day. Sometimes the battery light will come on for a second then go off. It seems to happen when I accelerate. I've watched the battery gauge and it never moves when the light comes on. I have a digital voltmeter that plugs into the cigarette lighter and it reads 14.2 volts constantly, even when the light is on. So what could cause the battery light to go on besides a drop in voltage?
View 9 Replies
Came on intermittently other day, got it home then did not start. Charged for a bit, it started on the charger then off the charger a few times I assumed out was the alternator just replaced it. Battery light now on continually, hope I didn't destroy two batteries driving out for 20 mom after light first illuminated, they already to be only one year old. In addition to the ABS light now and the brakes feel unboosted? Hopefully fuses popped?
View 2 Replies
My battery indicator light is doing weird stuff. I have a secondary volt gauge that shows good voltage throughout. Checked posts and connections tight. At idle the warning light is off. Under slow acceleration it starts to flash with the frequency increasing with greater acceleration until it finally goes solid with normal acceleration and highway speeds.
View 3 Replies
I'm going down the highway, put the pedal to the floor to pass and the battery light comes on, no difference in the needle or performance of the X, just the light comes on. 2001 V10 2WD
View 9 Replies
I have a 2004 Chevy Malibu Maxx that randomly dings and shows me the battery light.
It usually happens when going uphill or during really hard accelerations.
It is also showing OBDII code P0621.
The car has no other issues. Always starts, always runs well.
What causes this problem? Where should I start looking? I'm thinking it's probably a bad connection somewhere.
View 10 Replies
I own a 2002 GTI 1.8T, it only has 69000 miles on it, fully loaded, everything but power seats. So far I have had major issues on it. At first the car was randomly turning off and the EPC light came on, engine light is on and airbag light is on.
So far the car has a new speed sensor that fixed the EPC light. Engine light came on I plugged the computer in and code came up to replace the temperature and ignition sensor, took care of that, but light is still on. Airbag light is on for some time and Autobarn wants 150$ to check it but not fix it, and im not going to be doing that.
I also have new front brakes, new CV joints, and new tires on it.
The issues are at hand: If i am at a stop light the car will just turn off randomly, I can turn it back up but I want to stop that part. Sometimes the radio will go off and turn on by itself at random times.
When I am making a hard left, I hear a jolt in the back like something pushed the car and the car will die. Just yesterday I was driving, the ABS and Traction light came on and the back tires screeched and the car just floored by itself.
Yesterday the window did not want to go down and fell out of the socket and currently i have tape on the window to hold it up, i can live with that.
View 2 Replies
As I'm driving along, I get the battery light coming for a few minutes then going out. Is this a sign my alternator is on the fritz?
View 7 Replies
