Ford Excursion :: 2000 - Transmission Fluid Leaking?
Jul 16, 2013
2000 EXCURSION 7.3 Powerstroke
Automatic Transmission My son was trying to back up my empty 12' flat bed trailer up a hill (approximately a 25 degree hill). Why'll I was at work, my wife said he was having alot of trouble, and it was taking him awhile. She said she saw transmission fluid on the ground and stopped him immediately,and he turned off the engine. There is a trail of fluid on the driveway about 100' long and a 1/2" wide. This transmission has allways been solid, and only leaked a few drops on the driveway in almost 300,000 miles. what probably happened, and what I will need to do to fix it. I have allways worked on all my vehicles. But I know better than to get very deep into a transmission.
View 5 Replies
Advertisement
2000 Excursion 7.3 unk transmission
Quick run down on the situation. It has been terribly hot here bumping 105 degrees. I was told by a man he could see fluid leaking and it was trans fluid. I checked it and filled it up and got it to the shop.
Next day they said it was not leaking and that it probably overheated. They recommended an after market trans cooler. They put it in and off I went. 60 miles later I got fluid all over the rear of the truck. I filled it up again and got it home. Shop says I need a new trans.
View 9 Replies
My new/used 2000 4x4 excursion with 214000 miles on it has a transmission fluid leak.
It could be a rear portion of pan gasket but it seems to be coming out of the area where the transmission bolts to the extension housing.
I just put a transfer case in it. Thought all the fluid all over was due to exploded T case.
It seems the output shaft seal may be bad. I cannot seem to find an OEM part number for this seal.
What is part number for this seal, if one exists? Maybe the seal is in the extension housing and it's just the gasket between Trans and housing.
View 8 Replies
So my 2000 f350 is leaking transmission fluid from the cooler line. It goes to the rear of the transmission, but where does it go to from there?
View 5 Replies
Just changed transmission fluid and filter at 175,000 on my 2000 V-10 and now I have a whinnying sound and shifting that does not feel sure footed. It worked fine before the change. Fluid is synthetic and filter is Ford Motorcraft. Did it just go?
View 14 Replies
I have a windshield washer fluid leak. It's leaking onto the passenger side floor under the dash. Any have a good place to start looking or how to access the area it might be leaking at?
View 6 Replies
This line is rusted out on my V10 and leaking fluid.
How hard/expensive is this to fix?
I'm in the middle of doing my exhaust manifolds right now, so I'm hoping it's a simple bolt-on fix.
View 8 Replies
Did ball joints this weekend and now have little axle fluid leaking out passenger side. was going to change axle fluid when i saw this so continued and when pulled the fill plug i would say 8oz or more came draining out. Did I mess up the seal inside the tube?
View 5 Replies
Its been awhile since I have been on. Everything has been running great for me until I found my passenger side front axle leaking fluid. I'm sure something has been posted on here but I have limited access to internet right now and need to know what I am getting into to change the seals. From what I have found there is an inner seal in the pumpkin and then an outer seal and dust cover. Are both of these easy to change? Are there any special tools needed? Do I need to remove the gears in the pumpkin? If so, is this difficult and any special tools required for this?
Mine is a 2001 V10-6.8, 4x4 no mods at this point.
View 14 Replies
I took my 1993 Ford Explorer for an oil change they told me I also needed a rear differential service and a transmission service, so I told them to go ahead (this was on a wednesday). On friday the car broke down leaking transmission fluid (reddish oil). The clutch was making a sound when pushed in and we were not able to shift. I towed it back to the place where the oil was changed the gentelman open something under the car and he said that it had transmission fluid. He got on the car turned on and push the clutch when he did that a lot of fluid began coming out (reddish oil). He said it was the clutch that went out. We think they messed up the transmission. I towed the truck to a garage and the guy mentioned something about a plug related to the transmission. Could the oil people have done something wrong to the transmission that made the car break down???
View 4 Replies
I have a 2000 2wd with the 5.4 in it. I tow a travel trailer and loaded is 6500lbs. Today leaving the campground I had to climb an extremely steep hill as soon as you left the campground. No time to build speed. The old Ex made it, but I was definitely worried. The truck ran fine the rest of the 2 hours home. I went to back my camper into its spot to store, and smoke started coming out from under the hood. When I crawled under it, tranny fluid was leaking on the ground. A pretty steady drip. I let it cool down, added fluid and drove around. Didn't leak anymore. Did the tranny just get hot and had to burp? The drip was coming from where the tranny connects to the motor.
View 8 Replies
Found a puddle under the X last weekend. I thought it was the pan gasket when I got under her but much to my dismay, it was not. Fluid was actually seeping from between the extension unit and the tranny. Would this just be the gasket between the two?
View 5 Replies
So, had a transmission fluid leak. Couldn't find the leak so I went to a transmission shop. The diagnosis is that a snap ring broke and resulted in a hole in my tranny, something about reverse gear pressures weakly designed snap ring.
Not too happy about this, being that I had thought that the transmission was the strong point of my truck... Is this common?
View 10 Replies
My dad's truck recently started leaking transmission fluid and we're having trouble identifying what needs to be replaced, here is a picture of where it's leaking from.
2005 Ford F-150, 5.4L Engine...
Fluid is leaking from the rear end of the transmission. The black stuff is some instant weld fluid...
View 2 Replies
Daughters 94 f150 4.9L 204K miles e40d started leaking transmission fluid from the bell housing, so she parked it for 2 years...Now I have been nominated to fix it... Truck was running good when parked. Got it started (Just charged battery and started it up), and backed it up. Reverse is good and solid. When I tried to move it, it wouldn't move in drive. Starts to engage, then drops out. Pulled into first, and the truck moves, but have to have high rpm.
Replaced tc seal, filter and fluid, (12 quarts). No change... Ran it down the road, had to start off in first, good power up to about 35, shifted to second, it shifted...ran up to 45, then shifted into drive, it shifted, and maintained power. Had to slow so stopped and turned around, tried moving out in drive, and it just kept dropping out. Returned home as I left...read a lot of this forum, and learned some but not enough..
Pulled codes 327,116,536,538. No transmission codes.
View 10 Replies
A little background info...up until about 6 months ago my 01 Ex V10 was a grocery getter for the wife; only got a few thousand miles a year for the most part. Since we moved from Washington state to Texas it has turned into my daily driver (after a 2500 mile drive towing 8k trailer).
A couple of weeks ago we were running errands and after we got home there was smoke coming from under the hood, but I couldn't pin point it. I let it be because I figure it would let me know when something was really wrong. A few days later it did it again but this time I found the problem; transmission fluid was leaking out of the bell housing onto the y-pipe. I did my research and come to find out it is most likely the front pump seal that got soft from overheating. So my buddy and I drop the transmission and replace the seal. Put it all back together and everything seems great.
Another week goes by and we have driven the Ex fairly extensively around town and even took a couple short day trips and everything is great. Then as we are turning onto an on ramp to get on the highway I give it gas to speed up and all of a sudden the RPMs climb like it dropped into neutral. I had enough momentum that I got over onto the shoulder and started to check thing under the hood. Looked like I was low on trans fluid; ok so I added a quart. Put it in "D" and still nothing. Then I try "1", "2", "R" and they all work fine.
View 4 Replies
So I had a stuck caliper on the driver rear side. I pushed the piston back and checked everything to make sure all was in working order. After some though and reading about the calipers getting stuck which old brake lines, I decided to upgrade the line with the Russell stainless steal lines.
I got all the lines put in but I seem to have fluid leaking on the passenger side fitting which I can't seem to get to stop. I put the old line back in but it is still leaking. I am not sure what I need to do or check to get it to stop. It seems to be leaking from the thread area. I checked the fittings and they don't look cross threaded so I don't understand why it may be happening.
View 3 Replies
1996 Ford F450 1 ton diesel engine truck with approximately 100,000 miles has been leaking transmission fluid. Took it to mechanic who replaced the seal and converter. When idling, you can see it drip, drip, drip, etc. Now it is leaking more than before I had it worked on.
View 2 Replies
I have 2007 sport trac 4.0 liter V6. I have noticed for the past week or so that I have antifreeze leaking from the bottom of the radiator and I had to add some coolant to it the other day(1/2 gallon). I know it is the radiator leaking and not the overflow so I am going to go head and order me a radiator and change it. I have read that some of the replacement radiators was not lasting but about a year before they leaked.From what I have read on the internet a lot of ford owners is having this same problem with the radiator leaking at around 60,000 miles. Also there is no transmission dip stick to check the fluid, will I lose enough fluid that it hurt the transmission. I have just had the 60,000 mile transmission service done.
View 9 Replies
My transmission on my 2002 7.3 4x4 is pouring fluid from somewhere above the rear of the pan. I thought it was the pan at first. I pulled it off and replaced the filter. After adding fluid while it was running for 4 or 5 minutes it started pouring again. It's not the pan. It's coming from above the pan somewhere. It won't leak unless it's running. Is there a place it can leak on top??
View 7 Replies
I had an 02 Explorer for years now and absolutely love it. It has almost 170,000 miles on it and is definitely showing its age. There's alot of rust underneath and ive been replacing things as they break. For about a year now I've been dealing with the transmission leaking fluid. This vehicle doesn't have a transmission dipstick and has to be filled from underneath. When I have the transmission full of fluid it works perfectly until recently. Now, when I go up a hill the transmission goes into an almost neutral state.
The R.P.M's will go up past 4000 and I'll have to stop. It doesn't misfire or bog down, just acts as if the tranny is in neutral. Sometimes I just sit there for a minute and its fine, other times I haven't been as lucky. In one instance I had to sit there for about 20 minutes, in another I disconnected the battery to reset everything, and on another instance it would stall out the moment I put it in gear. I know it's a little low on fluid and will be getting it filled again soon. I plan on possibly getting a new transmission this winter, but gotta keep it going till then.
View 3 Replies
