Ford Aerostar :: Mute Airbag Alarm Without Disconnecting Any Wiring?
Feb 3, 2015
I have this "new" 95 Aero that I really enjoy. It has a few quirks here and there but it had one that was making driving around like sitting in a room with the smoke alarm going off. If you have this shrieking airbag alarm and want to stop it in a simple way and without disconnecting and wires here is how I did that.
pictures below:
Tools needed:
Ratchet
Flat head Screwdriver
Gorilla tape
3M gasket sealer ( or similar )
pic 1 ; The sound comes from the Airbag Diagnostic Module which is a tourqoise colored box just above the fuse box by your right leg.
Remove that by unscrewing 2 bolts that hold the bracket to the module. It is too hard to unclip if you do not bring it down with the bracket. * I disconnected the + terminal of my battery and waited 1 plus minute, but after seeing how to silence the little ***k** you really do not even have to do this.
View 14 Replies
Advertisement
Yesterday, in the middle of replacing the clockspring in my '93 Aerostar, I was asked to move my van. I had just finished removing the airbag and was undoing the steering wheel. Thinking it was no big deal, I reconnected the battery and tried to start the engine. The instruments lit up for a brief moment and then nothing except a relay near the rear hatch buzzing. The buzzing stopped after a second and the interior lights went out too. Now, I have no electrical activity anywhere.
View 3 Replies
Here's the problem with my 1994 Ford Aerostar 3.0 engine. As many have mentioned here, I'm getting the 5 chimes syndrome, indicating an issue with the airbag system. My specifics are:
The Airbag light does NOT light, even when the key is first turned on. You would think the light might be burned out, but I removed the instrument cluster and tested EVERY bulb. After hooking the instrument cluster back up, the light still wouldn't light, but I still get the 5 beeps.
The horn works (haven't tested the cruise control).
I'm not sure where to begin troubleshooting. I have the basic Chilton manual, but it's not troubleshooting the SRS. I understand the cautions when working on the SRS system, but would like to troubleshoot it myself. Unfortunately, I got laid off, and I can't afford to go to the Ford Shop.
1994 Aerostar XL w/3.0 engine, 144K miiles
View 10 Replies
My 82 year old mom had to have a new battery put in her car. Now the airbag alarm is going off. Why is this happening, and is it safe for her to drive somewhere to have it looked at?
View 8 Replies
Got an air bag code 41. Comes on and flashes the code a number of times, then goes off for the rest of the ride. It is a 96 Arerostar, XLT, 4LV6. From what I read it is a short someplace. Where are the crash sensors and how do you check them for "shorts"? I don't understand much about the whole system.
View 12 Replies
My van is spouting SRS fault codes 1-3 and 5-1. I had my shop run a diagnosis and it appears the module has failed. I'm having trouble tracking down a replacement. The Module on my van is Ford# F5AF-14BO56-AA. I see modules with -AD or -BD, but none that match this number perfectly. I also see lots of modules for related Ford vehicles from the same era. Looking for a ford parts number reference sheet that will indicate on what vehicles this module was used or if there is any chance that related modules are compatible?
View 14 Replies
2 or 3 years ago my airbag light started blinking. 120,000 miles, only owner. The code changes daily. Then the car started reviving at highway speeds. Then cruise control wasn't reliable. Sometimes when I hit a bump, the cruise goes off. My mechanic said the reviving felt like it was going in and out of overdrive, so he rebuilt the transmission. No change. This past month, the car started to pull to the right. It felt like I was driving with the brake on, couldn't get up a small hill. Before I could get the car home, the brakes went to the floor and the car stalled. I had it towed to mechanic.
After 10 days, he couldn't duplicate problem, so I took the car back. A few days later, after 4 hours of errands in the hot Texas sun, it did it again for me. Pulled to the right, driving with the brake on feel, brakes to the floor. This time it smelled like something was burning, either brakes, belt or something, and the rear ABS light came on for the first time. Latest mechanic says it is probably a brake booster, but that doesn't explain the reviving does it? I've had it to 2 dealers, 3 mechanics, and no one has a clue what to check apparently. I am a senior, so I can't really start replacing everything. What should I tell them to check, and in what order? I love my Aerostar....
View 14 Replies
I have a 93 Aerostar 4.0 and it is displaying the blinking airbag light (3-2) and the horn doesn't work and the cruise control failed. I believe it is the clockspring ...
QUESTION: Can the clockspring be repaired or must it be replaced. I do not have a schematic of the electrical components of the clockspring ...
View 9 Replies
My 03 expedition has a blinking air bag light. It blinks 4 times and then 2 times and repeats. I have googled this and found 42 = Primary Crash Sensor #2 Feed/Return Circuit - Open
How to fix this? Where to look, what to test, what the service manual says?
View 6 Replies
I pulled my CD player and put it back in and now my air bag light won't go out when it self tests. It blinks for a while then stays on steady. What's up with that -- I thought I was having enough problems with the CD player as it was?
View 14 Replies
I've been trying to trace down a issue with the airbag warning light flashing. The seatbelt light is flashing also. The airbag code is 53. If i search it i get the front crash sensor..I replaced it with a new sensor and pigtail. Other than that the search leads me to believe it could be anything.
I've checked and clean every connection that i could find. I haven't removed the center console yet to check the module. I did buy the truck last fall as a winter/work truck. The issue started a couple of months after i started driving it. Not sure if the module would just go bad.
View 13 Replies
I have a 2004 250 SD. Supercab. Took out the bench and replaced with captains or buckets, whatever you want to call them. Perfect fit. The new seats have their own seat belts built in to them. The old ones, were mounted to the floor and roof. Now the air bag light blinks for a fairly long time, then stays on! What? OK, So, what do I NOT know about this project? I did have to make the wires longer in order to reconnect the plugs. Not a problem, I am an electrician. Trouble shooting is ok, when you know where to start.
View 10 Replies
I am looking for a site that i can download a service manual with good wire diagrams. I want to install an alarm with remote start and need to know what wires go to what.
View 2 Replies
What the code "32" means for the airbag? Lately my airbag light on the dash will blink 3-2 for several cycles then stays on solid til I shut down the truck.
View 12 Replies
Recently I changed a turn signal switch on my VW Jetta 1994, and it turned out the new switch had a faulty horn/airbag connection (just not springin out enough), such that power was not being relayed - I figured this out when the horn would not blow, and on inspection I realized that there was a gap between the connector on the top of the switch and the horn. At the same time I realized that my problem was the signal relay, and not the switch. So I changed back to my old signal switch. The horn is now fine, but I have the airbag alarm light on. I am cannot think of anything I did wrong. So I am wondering whether the light could be coming on because of the initial error when there was no connection where the airbag signal keeps coming on even after the repair error is corrected, or does the alarm indicate a current error rather than a lingering memory of the error I had initially?
View 14 Replies
[URL]......................................................................
After I could not figure why I was having the alarm light I drove the car to a mechanic, explained my sleepless nights and many hours of problem analysis, and then the mechanic took his code reader, connected to the OBD car port, made a few clicks, and charged me $45 and then sent me off. The alarm light has not been back since - it blinks as expected when I start the car.
On my further research I have found that VW airbag light will come on if you check airbag with your ghetto OBD code reader - exactly what I had read! It registers "high resistance", and must be reset by someone with a qualified code reader!
View 3 Replies
My 09 Matrix passenger seatbelt/Airbag Alarm light started to come off intermittently a few months ago. It often came off in a cold morning (when temperature dropps below 40F) after driving for 30+miles. I have taken it to a mechanics and they found an airbag code. They cleared the code but cannot find the root cause. I saw from some online forum that it happened to a lot 05 Matrix and repair involves replacing the clock assembly eventually. It seems to be odd since it only happened to me when it is cold and after some driving. I suspect that it has something to do with the battery since the battery output voltage may be the only thing I can think of that can be temperature dependant.
View 5 Replies
2011 Subaru Outback; in January of 2015 the airbag warning icon shows on the dashboard and a loud alarm sound is played. If I turn the car off and on and I make it go away. Not easy when driving 75 mph on mountain highways. Dealer where I purchased the car has been useless; three visits there and a dozen unreturned phone calls.
View 3 Replies
Brought the Prius v in yesterday for the 3 yr service. Service advisor was very nice, did not try to sell anything more than an oil change basically. I was concerned the voice prompts do not mute the radio, meaning it is very hard to understand the voice guidance unless you turn down the radio volume. Service advisor first calls and says the Bluetooth is working normally. I clarify that the Navigation voice prompts are the issue. He says he'll call back in a little bit. Calls back and says it is normal. Is this normal? The bluetooth functionality mutes the radio. I don't remember it being like that in the past....
View 4 Replies
I can't figure out how to mute the navigation system. I found the volume control, but it doesn't have a silent option. How to do this?
View 4 Replies
My Dad just bought a 2004 v10 and has somehow messed up the mute function on the car. He Now has both the Radio and the Nav muted and cannot figure out how to fix the situation. He doesn't like to use the computer and asked me to figure it out. I'm sure I could stumble into it if I wasn't 800 miles away.
View 3 Replies
