Ford A/C :: 2001 - Coolant Leak At The Top Of Engine In Front On Passenger Side
Nov 11, 2010
I have a 2001 expedition 5.4 ltr that has developed a coolant leak. Leak appears to be on top of the engine, in front on passenger side. The area around the front fuel injector (on passenger side) is wet and water is running down and sitting on top of engine (under intake manifold). My first thought was that the heater hose extending vertically from the block hose fitting. I have found no evidence of a leak in the hose but it appears fitting on block may be the source. It has three bolts holding it onto the block. One from the top and two coming up from the bottom. Two of the three area accessible. How to get to the upside down bolt nestled between hose fitting, block and valve cover. It's been a slow leak so far but I know that's not going to last. Runs fine but steams from water on block at stops and when parked.
View 2 Replies
Advertisement
I have a 96 explorer that has recently developed a coolant leak. i was able to find the location of the leak, but i am puzzled by what is causing it. It is leaking on the back, passenger side of the engine, and while the truck is running it just squirts coolant out on and off...i am guessing it leaks when the thermostat opens. anyways, what is could be? i was thinking lower intake gasket, but i have never seen a lower gasket squirt like that!
View 3 Replies
2003 F250 7.3... I noticed a water leak dripping down onto passenger side front leaf spring. I saw this before but attributed it to the AC (which kicks butt) but haven't used the AC. No scent to the clear fluid, temps all look good. Running fine. Where does the AC discharge go? Could AC be on (not on AC but set in blue zone on dial)? Reservoir looks ok but could e small volume of drips.
View 12 Replies
I have a 1990 F-150 w/351 that I knew had a coolant leak at the back of the engine when I bought. It's a tinker around truck, something for me to play with.
I've traced the leak back to a metal tube/pipe that sticks out of the engine compartment just below the AC housing. I cannot find anything in the Haynes manual or a diagram on the intertron that shows what this is and if it should have a hose on it or...?
View 3 Replies
I have a small coolant leak coming from the passenger side near the back of the engine that forms a spot about the size of a dinner plate if it sits for a few days.
One thing I noticed is if I turn off the AC selector switch when I park I will get the drip but if I leave the switch on MAX AC when I shut the truck off I do not get any leaking.
It is definitely coolant and not just the condensation from use of the AC. If I haven't used the truck for a few days or if I have run it with the AC off I will get the drips.
If I run with the AC on and leave the switch in the on position when I shut the truck off it won't leak. I have tried to locate it from looking above and below but can't determine where it is coming from.
View 4 Replies
I did a search but found nothing on a coolant leak. My 07 (57K) has developed a leak on the passengers side of the engine. Not sure if its the water pump (not making noise) or the themostat housing as a mechanic who took a very quick look at it suggested. How hard it is to get to the thermostat housing? Anything else have to come off? I don't have a FSM.
View 14 Replies
My 2003 GTI 24V VR6 is leaking coolant pretty quickly from the passenger side of the engine compartment. I have a new water pump in hand. If I'm replacing the water pump, would it be smart to go ahead and order a thermostat and metal crack-pipe to replace at the same time that I'm having the water pump installed? I'd hate to get the water pump installed, and find out that the leak is at the crack pipe.
View 3 Replies
I have a 2001 Screw 4x4 that had a bad valve on the passenger side. I got the head rebuilt and put it all back together. Now it has a pretty bad oil leak at the rear of the engine. I thought it was the valve cover gasket but when I took it off the gasket was right where it's supposed to be. I pulled the starter and it seems to be leaking out of the new head gasket. What could I have done wrong? The thing runs perfect now but it's dripping oil like crazy so I had to have done something wrong. I used an OEM head gasket from the dealer and torqued the new head bolts to 30 ft-lbs and then went another 90 turn twice just like the book said.
View 14 Replies
So we have an oil leak in our 2005. It is coming from the front of the engine on the passenger side. The oil was changed on May 15th. And it has only leaked since then. Any thoughts on what it may be? What part of the engine deals with oil in that part of the engine compartment? We will take it back to the place that last changed it and have them check it out as well.
View 2 Replies
So broke down today and have no tools, in a city I don't live in. Huge coolant leak behind the block on the passenger side. Luckily we broke down right at a mechanics shop. They need to take off the manifold to get to the rusted out metal piping in back.
I am new to the V10. Looking for information on what could be leaking back there? I know I could do this myself but I need to know what parts I might be dealing with first. And its tight quarters back there.
View 12 Replies
2003 7.3 175,000 miles...
Saw a stain in my driveway where you normally see AC drip. Opened hood and saw degas empty.
Looking around like crazy and find wet area. Where the coolant line turns down beside the passenger fender.
Looks wet near bend going toward running board. Didn't get to inspect much but I pulled back a bit of loom to inspect shape of lines and they look great.
What could be going on?
View 14 Replies
Alright, after finally fixing my 4X4 issues, now I have a coolant leak. It's on the passenger side, just above the exhaust downpipe. I can't find any leaks in the hoses, and as far as I can see it looks like it's coming out of the back of the head and running down the back of the block. The odd thing is there's no oil in it, and no coolant in my oil (which obviously is a good thing), but I don't want it to get to that point of it is getting worse. Heat works fine, and it isn't overheating, only losing maybe a gallon a month. At some point the ford gold stuff was flushed and it has the compatible green, that is the only thing I can tell is not stock. I don't want to tear it down if I don't absolutely have to.
View 7 Replies
One last issue with my 2000 B3000 3.0L. The leak seems to be on the left (passenger) side of the water pump very near where the bottom radiator hose connects to it. I can't find any loose bolts. It does not leak while driving the truck or soon after. It has to sit for several hours or overnight before it shows up. There are usually 3 or 4 wet spots where it drips from the water pump to the frame to the driveway. It is small enough that I only have to fill up my coolant tank every 1 or 2 months. Could this just be a small gasket leak? It's been happening for about a year or so I think. I replaced the radiator about 2 years ago. I've been expecting it to get worse or bust loose and have been checking it very often. I've never seen one not leak while running like this-has me puzzled.
View 6 Replies
I have a 2003 Expedition with a coolant leak on the front R/H side of the truck. I do not see any coolent lines on that side of the truck and the leak seems to be running off of the A/C compressor. I notice a couple of drops about the size of a dime about once a week in my drive way since x-mass and have NOT had to add any coolant. I was getting ready to do a flush and fill but now have concerns that it may have a bad head or head gasket. The truck has 84000 miles on it and never has been overheated.
View 1 Replies
Coolant leak on the passenger side. Leaking enough to leave a puddle on the floor. This is a 2000.
The water pump is good. Weep hole is dry. All of the radiator hoses look good.
The traditional intake manifold gasket looks fine, even though that isn't really a suspect here.
Looking up from the bottom, coolant is dripping from what appears to be a lower motor mount right next to the oil pan. Also, the area around the crankshaft pulley looks wet.
What should I look for? Could it be a leak from the engine oil cooler? Are there hoses on the back side of the engine? It doesn't look like it's anything simple.
View 6 Replies
Today I noticed a small coolant leak under passenger side bumper. What it could be leaking from?
View 1 Replies
I've got an '04 1.8t jetta with 158k on the clock. Recently noticed I have a coolant leak on the passenger side of the car. Started the car in my driveway and looked for drips and found coolant collecting in the front valence right underneath the intercooler. Took a look from the top and noticed the hose going into the bottom of the part shown in the picture is leaking like a sieve. It's the metal canister-type thing on the passenger side right next to the radiator. What part this is? And where I can get a new hose that connects to the bottom of it?
View 11 Replies
So my coolant system woes have continued! I recently replaced my thermostat ,thermostat housing, thermostat cover and all of the rings and gaskets. I finally stopped the leak on the driver side which seem to be the thermostat now about seven days later I am experiencing leaking on the passenger side. I walked out from work today and noticed I pool of coolant under the car. I can't tell exactly where it's coming from but it's coming from one of the components that runs off of the large belt. I snapped a few pics from the bottom of the car I don't think this is the actual component that's leaking. I think the leak is just falling off of it . I was wondering where the water pump is located.
View 5 Replies
Two weeks ago I was driving home from work and my heat stopped working. I pulled over and saw coolant dripping badly out of the bottom of my truck. I popped the hood and sure enough, coolant was bubbling out of the front passenger side of the intake. I took it to a shop to do the work (quoted at 500-550 out the door with a dorman intake). A week goes by and I get a call from the shop, "After two Dorman Intakes, the truck is not running right", what it could be.
The truck has 367k on it (not sure if original motor). Yesterday I get a call from the owner, " we put the original intake back on and fixed the leak with jb weld. The truck still runs bad. They claim they didnt do anything wrong and will not take any blame for ruining my engine. (Keep in mind the truck ran PERFECT when I took it in there). The truck doesnt throw any codes and they are at a loss of what could have happened. They put in 8 new plugs and 2 coils that they broke while in the process of removing the intake. F150 5.4 ...
View 3 Replies
My truck just passed the 3 year/36k by 2 days! I got it on 8/4/10 but it only has 27,000 miles of course I just found a puddle of coolant under the right front drivers side. After a little reading, I guess this is common. Should I push for Ford to fix it or get an extended warranty and turn it in on that or... Aftermarket yet that isn't half plastic like this stock POS?
View 12 Replies
I'm trying to figure where the coolant leak is. Appears to originate on the driver's side front, right near the thermostat housing. Since the engine tilts back the entire drivers side is wet. The thermostat gasket appears to be OK, but it does have a lot of miles on it.
If it's not the thermostat then can coolant leak from the cross over tube. And is the cross over removable without taking off the intake. There appears to be a bolt coming up from underneath on the passenger side.
Also, does coolant flow through this plastic intake. If it does, then the leak could be some where else, if not, then it's probably the thermostat.
View 9 Replies
