Ford 6.7L Power Stroke Diesel :: Intermittent Engine Knock And Burning Smell
Nov 9, 2014
Today I noticed this burning smell under my hood and a bit of a engine knock on idle... It doesn't knock all the time tho ??
View 7 Replies
Nov 9, 2014
Advertisement
Ford 6.7L Power Stroke Diesel :: Burning Smell In Rear Of Truck
What is that Burning Smell?
View 14 RepliesFord 6.0L Power Stroke Diesel :: Hole In Transmission Case / Burning Smell?
After driving, i smelled something horrible burning. When I get home, I get on my creeper and roll under to look for anything suspicious, and I find this. It is not where the drain plug in the pan is, it's in front of that. I checked the temp when I was driving but it never got high. I really need my transmission to not explode on me right now, I have a lot of driving to do.
Here's a gallery where there are some pictures....
Photo Album - Imgur....
Ford 6.0L Power Stroke Diesel :: Oil Burning Smell - Smoking Rear Drum / Hub
Got home today and smelled the "oil burning" smell. Blue smoke, didn't smell like brake pads. The smoke was evident from the right rear wheel. Put her in the garage and pulled the wheel. By the time this was done there was no smoke and no fluid anywhere, but there may not have been when it was smoking either. The drum was hot, the axle housing was not hot until closer to the drum/disc/wheel. The differential was slightly warm. Vent was not plugged. No obvious accumulation of lube or fluid on the inside of the wheel. Plenty of disc pad left. The actuator for the emergency brake that sticks out the back of the brake/plate assembly was super hot.
If I decide to pull the hub/rotor to inspect the brake shoes am I getting in far enough to commit to doing a full hub/bearing/seal inspect replacement? I'm getting old enough to pay a shop for this stuff and save my back, but if it's a no-brainer repair to get new seals I'd like to do it and save some bucks. Might as well do both sides right?
I'll be driving cross-country in June with a slide-in camper and want it done rather than a band aid job. It's never been checked before. 2006 F350 -- 150k miles. I'll keep searching the forum for answers but would like some opinions...
Ford 6.0L Power Stroke Diesel :: Sting Skunk Or Rubber Burning Smell In Cab
Left work tonight in heavy snow fall. Was in four wheel drive and following some slow pokes, till I could finally pass. I thought the smell was the cars ahead of me. Got to my crash pad, (5th wheel home away from home) and noticed the smell seemed stronger in the cab. Checked under hood and is not from the engine. Cab stinks bad.
View 3 RepliesFord 6.7L Power Stroke Diesel :: Engine Knock But No Engine Light?
I have a knock ! (hoping its just an injector) No engine light, No drivability issues 190k Not there at start up, not there right after a drive. any thoughts?
[URL]
Ford 6.7L Power Stroke Diesel :: At Random Times Engine Sounds Like It Has A Rod Knock
I have a 2016 f350 super duty with 6.7L engine, at random times engine sounds like it has a rod knock, give more fuel, it goes away, driving at 40 to 55 mph the whole vehicle shakes all at different times and different days vehicle has under 6500 miles want to now anything before going back to dealer..
View 6 RepliesFord 6.0L Power Stroke Diesel :: Engine Smell In Cab
For the last couple weeks, I've had the ac on and windows down basically the whole time and ive notice some oil spots on the driveway... i got under the truck and was feeling around where i saw the suspected oil, and well it seem as though its water mixed with a little oil and i have a small amount of oil leak from my intercooler pipes and elbow... Why I have the oil spots that looks like its mixed with water and why my in cab air vents seem to put out an engine/emissions smell?
View 7 RepliesFord 6.0L Power Stroke Diesel :: 2004 F350 - Intermittent Loss Of Power / Stall Or Stumble When Engine Is Cold
I just bought a 2004 F350 6.0 cclb 6 speed with 260k on it. The previous owner seemed to have taken good care of the truck. It is basically stock with the exception of the blue spring mod, and a sinister diesel coolant filter. Anyways, I brought the truck home and it ran great. Now I have an issue that needs to be addressed.
The issue: I am experiencing a intermittent loss of power, stall, or stumble when engine is cold. After sitting all night the truck will start fine and idle fine. But when I try to accelerate and bring engine RPM up the engine will stumble and lose all throttle response, when this happens the WTS and WIF light flash. Sometimes it just stumbles, sometimes the truck will actually die and then restart. The issue seems to go away after the engine has reached operating temp.
I did some research on the issue and it seems there is actually a TSB out from ford for this issue. It explains that some 2003-2004 6.0's might have wiring harness chaffing issues. This is what the issue I am having seems like to me (shorting harness). I looked up codes on the truck and there is an active code (#8 glow plug circuit fault). I did a short visual inspection of harness and didn't see anything out of the ordinary. But i wonder if it would be worth changing both sides of the glow plug harness?
Ford 7.3L Power Stroke (1999-2003) :: Burning Smell In Cab All Day?
I smelled it this morning and when driving home and it almost smells like wires burning and its pretty strong. I looked all around the dash and can even smell it under the hood. And by the way the cruise control recal was done on it so it shouldn't be that. Hopefully my truck doesn't catch on fire over night.
View 9 RepliesFord 7.3L Power Stroke (1999-2003) :: Intermittent Idle Knock Heavy Use Dependent
My late 99 has 161K, I am the 2nd owner and bought from the Original owner. It is stock with no tunes. Auto/4wd.
It has had an intermittent idle knock and recently has gotten much louder recently when used heavily with towing for summer camping in the 7K range up steep hills. The knocking goes away above 12-1500 rpm. There is no noise when the engine is cold. It seems heavily temp/load/heavy use dependent. If driven lightly, the knock is quieter but still present. The trans was recently rebuilt and new billet converter installed, made no difference so it's not that it would appear.
I rec'd blackstone last week and the results are excellent. Running the cyl contribution test while hot in drive at idle reveals cyl 8 is running 4.9 to 5.4 Perdels. #3 is 2.2 to 2.8. 1,6,7 are 0. 2 is .6 and 5 is .4.... I haven't checked bolt torque yet. My question: Is #8 "fixable" potentially with bolt torque? Is it considered too far gone and should just be replaced?
Ford 6.0L Power Stroke Diesel :: 2007 F250 - Check Engine Code - ICP Circuit Intermittent
I have a 2007 f250 and got a check engine code icp circuit intermittent and to what I know icp sensor should be on the valve cover on the passenger side but it's not I bought the truck few months ago could it be that they swapped the engine for an early 6.0 or is there any other place for the icp sensor???
View 7 RepliesFord 7.3L Power Stroke (1999-2003) :: 2001 - Burning Oil Smell Inside Cabin
We have a 2003 Explorer Sportrac and the fuel cap light came on. Then ck engine light came on. took it to a dealer to check it out. Said it has a fuel pressur issue. could be the cap or something in the fuel tank. it needs a pressure check they said. cleared codes and put new factory fuel cap on. 2 weeks later it happened again.
XLT model 108,000 miles on it and we are the original owners...
Ford 6.0L Power Stroke Diesel :: 2004 - Knock During Start Up
My 2004 powerstroke recently started making a loud knock during the process of starting. Will make the sound warm or cold, however I mostly hear it when the truck is warm as it cranks a little longer and about two seconds into the crank something starts knocking. After the truck starts it runs perfectly fine.
View 6 RepliesFord 6.7L Power Stroke Diesel :: 2013 F350 Just Developed A Knock
My new to me (2K miles now) 2013 F350 with 52k miles just developed a knock. Oil changed 600 miles ago, Oil level good. No codes or CELs ...
YouTube...
Ford 6.0L Power Stroke Diesel :: Burning Oil After Turbo Replacement
On Friday my turn shaft broke, 70 mph on the highway. As soon as it broke burned oil like a freight train, I know seal in the turbo. Bought brand new Garrett turbo installed last night. Let idle for 5 minuets and went and drove it and it burns oil once I get on it. Drove it for about 3 miles comes and goes? I did break a piece of the turbo vane off 1/4 inch by 1/4. The truck runs fine no knocks or misses. Could this just be oil left over or is there something else I should be looking for?
View 2 RepliesFord 6.7L Power Stroke Diesel :: Right Fog Light Bulb Is Burning Out
Lately my right fog light bulb is burning out, and I notice water on bulb and lens fogged. Dealer is telling me they have to take picture, send to ford for approval to replace under warranty. Really?
View 3 RepliesJeep - Grandcherokee :: Chemical Leaks - Intermittent Burning Match Smell
I get more or less constant wine-like odor in the salon, as well as intermittent burning match (sulphur?) one. These seem to be seeping from the outside, through the ventilation system. The car has a new radiator, and the heater core, there are no apparent coolant leaks.
View 3 RepliesFord 6.0L Power Stroke Diesel :: Burning Oil - Blue Smoke Under Any Load
2005 F250, 6.0, 60K miles, recently (within last 1K miles) had ARP studs, EGR delete and new oil cooler installed. Shortly after (5-6 weeks later) I noticed blue smoke under any load (taking off from red light, backing up) but not at idle or startup. Was using the "Performance" SCT canned tune after the stud install, but had the "65HP Tow" canned tune installed when I first noticed the smoke and now back to stock after noticed the smoke as a precaution. Everything else original except FICM, filters and batteries and use 5w40 Mobil 1 since new.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Very Strong Diesel Smell?
One of the great things I liked about the new 6.7L engine was the lack of any diesel smell. While the tips of the exhaust pipes remain clean at 64,000+ miles, no soot, my truck now has a strong smell of diesel after each use. The truck is running strong but I can't figure out why this is happening.
View 4 RepliesGolf IV R32 :: Burning Smell / Lose Any Power And No Check Engine Light Came On
Ok my R is all stock 59k miles. This morning I was getting on the freeway and some AMG hold was on my ass so I floored it and accidentally hit the rev limiter. After that It smelt almost like burnt rubber in the car. I rolled the windows down and the smell went away in about ten min. I didn't lose any power and no check engine light came on. When I got to work I got out and looked under, no fluids leaking. But the smell was still there. I'm gonna look at it more after I get home from work.
View 10 Replies