Started smelling exhaust in the cab while idling, and at startup. After further investigating found out the EGR inlet tube is leaking at the flex joint. So my question is , is there anything that will jump at me while I'm doing this tube replacement.
View 3 RepliesI have an exhaust smell in the cab of the truck. It is pretty strong. Seems worse when it is really cold outside and goes away when outside temps warm up. I checked the tube (passenger side behind engine) and did not see any soot.
View 12 RepliesWas cold this morning, -15c, and I remote started the truck and then left home about 5min later. I could smell exhaust in the cab. I read some of the other threads about this. How can I tell if it was doing a regen? I have an Edge Insight. Is the a parameter I can display to know the regen was active?
View 14 RepliesI just looked back and it has been since July 7th that my girl has been sitting in my shop. Well this past weekend I finally got her back together and started. It took a while to build pressure but she finally came to life..
While I am thrilled that she is running again i have low power before the boost kicks in and is idling rough with a blueish- white smoke coming out of the exhaust. Once i kick her a little she will get up and go but I've never had the smoke before.
I'm thinking maybe a bad injector???
Got to thinking today while my truck was warming up, why does the exhaust smell so bad. I think it is kinda interesting that the exhaust pipe is so clean also, like new matter of fact.
So what make the exhaust smell? The exhaust filter traps the partials right but where did the diesel smell go? I can understand it when in regen but in normal operation I don't get it. I guess I just don't the mechanics behind it. All I do know is that, what is left just stinks especially when warming up.
We've had a run of -20 to -40 weather here for the past few weeks.
A few weeks back I noticed that when I climbed into my truck after command-start warm up for 10 minutes, and I could smell strong exhaust.
I figured it was hopefully the wind, or an isolated event.
Over the past few weeks I've used my truck for 3-4 more around town runs and every time I warm it up I get the strong exhaust smell. It's that rich, eye watering, sickening exhaust smell. I also notice a small yellow frozen puddle under the exhaust tips that wasn't there before.
It's bad in the cab, but even walking around outside the truck and the smell is sickening. I actually just started the truck and I could actually smell the exhaust smell faintly, from inside my house! This has never before occurred. Prior to this, a person could hardly tell it was a diesel by the smell of the exhaust.
Once the truck is up to temperature the smell seems to disappear, or at least lessen.
2015 6.7 KR... when idling for long periods of time the cab starts to smell like exhaust. I've also noticed when standing outside the truck with it idling (not in regen), it freaking stinks, bad! My 2003 never had this problem and idled for days (literally). Possibly leaky gasket here or just the nature of the 6.7?
View 14 RepliesI just took my new (to me) 2012 F350 out for it's first real tow job; pulled our 9,500lb travel trailer up and over the Sierra Nevada Mountains for a week long camping trip.
Under load, I started to smell a burning metal/paint smell in the cab, to the extent that I was wondering if something was wrong. All of the gauges were fine, and there was no unusual smell under the hood.
My wife discovered the floor on the passenger side was hot to touch (directly above the exhaust), and it actually started to melt a few plastic items in her purse.
I did just have the EGR valve replaced after it threw a code; not sure if there's some coating on the new one that could be burning off.
Isit normal for the floorboard to be that hot when working thes trucks?
I have been smelling a slight exhaust smell in the cab of the EX. I slide under the truck and looked at the up pipes and bellows. I saw a slight amount of soot on the outside of both bellows. So does that mean I have a leak? What is the most economical fix? Does the turbo need to be removed?
View 4 Repliesso i cant quite tell where its coming from, but here is a picture. it seems to be coming from just even with the drivers side exhaust manifold towards the back. from what i can see the top valley looks clean. it seems to only leak while its running. and it leaks quite a lot. its close to the bell housing so im guessing a rear main but i don't know. i hope its not!
View 14 RepliesOver the weekend I replaced the passenger side up pipe with one that doesn't have a spot for the EGR cooler. After putting the turbo back in it has a pretty bad exhaust leak. Sounds like it is on the drivers side somewhere near the Y pipe. When replacing the passenger up pipe I didn't loosen any manifold bolts or anything and I am thinking that the Y pipe is out of alignment with the turbo. What is the proper procedure to loosen everything up and get it aligned on the turbo? My guess is remove turbo, loosen drivers side manifold, loosen passenger side manifold, loosen passenger up pipe and tighten it again now that everything isn't under tension, install turbo and clamp to Y pipe, tighten manifolds. Is that the right idea?
View 8 RepliesUsually in the OBS 7.3 but a buddy of mine with a 2003 6.0 is having some issues. When he romps on the pedal but when he does so he claims he can smell exhaust in the ventilation system. I rode with him and smelt it as well. So I inspected all exhaust clamps and piping as best I could and did not notice any soot or leaks while running. I don't know if it pertains to it or not but his heater only works on defrost.
View 4 RepliesToday I drove to dinner in my 2012 6.7 with no problems then on the way home my brother said he noticed my truck was white smoking quite a bit and he said there was a very strong exhaust smell coming from my truck ( he was in his car behind me) I ran a diagnostic test and what came up was code P0401 (I believe that's right). Need to figure out what is going on with my truck before I take it to the mechanics and get charged up. The truck still has DPFs in it just has a DPF back exhaust and has a AFE cold air intake running on a stock tune. However I do have the DPF deletes and EGR delete sitting in my garage just haven't gotten them on the truck yet.
View 2 RepliesI've been smelling coolant for a few weeks with no apparent leak. Walk out today, small puddle under truck. Coolant running/drip along seam of engine and trans right in front of downpipe on passenger side. Even with a mirror I can't see up far enough. Looking from top is impossible. What could be leaking up there? Turbo?
View 4 RepliesI suspect I have a turbo seal leak. My 2004 E350 6.0 smokes like crazy. The smoke is white and smells like you poured raw oil on a hot manifold. Definitely not diesel smoke. How can I tell if it's my turbo without tearing it out?
View 14 RepliesI've thought I smelt diesel fuel on an off for a while, but never found the source.
Tonight, 17 degrees out I have fuel in the valley and it appears as if the back of the drain valve is wet.
A fuel bowl rebuild is on the short list. Is this typical, the cold weather brings the issue to light?
I have noticed a refrigerant oil smell coming out of the A/C vents when I first start my truck with the a/c on.. smells like the PAG oil in the A/C system.. I got under the truck and stuck my finger in the condensate drain and it's oily, and has the same smell.. the A/C is still blowing cold, but the smell is getting worse..
View 10 RepliesSo I started my truck this morning and it sounds like air rushing out from the driver side of the engine. I currently have my ICP unplugged due to a bad sensor, will be replacing it on Sat. Also I have been having an issue with my turbo but I don't think that it's related as I here the air rushing sound when at idle as well at when driving. It seems to be a bit louder when the engine is cold but I could also be crazy about that.
View 3 RepliesWtf is going on, Temps are all good, no check engine codes...bad diesel fuel? I had 1/4 tank of diesel fuel when I filled it up...
View 14 RepliesI'm having an issue with massive oil consumption and no oil leaks on the ground! No clue where the oils going but I burned more than 2 gallons today in a few hours of driving exhaust smells awful but the truck is running fine.
View 14 Replies2007 Escape XLT 3.0 AWD. During the winter there can be quite the exhaust smell in the interior upon startup and especially if using the remote start. During driving the smells will clear out and appear again with an extended stop but not as bad as initial cold startups. I realize the hotter the engine and exhaust components the smaller the leaks become. Hopefully not an exhaust manifold leak.
Looking for a way to find where a leak may happen. I saw a video of a garage using "smoke" pushed up the tailpipe to find leaks. Or any other techniques or similar situations.