Ford 6.7L Power Stroke Diesel :: 2013 - Whining Noise Coming From Under The Hood
Jan 10, 2013
Just pu my new 2013 6.7 Diesel with 1300 miles... There is a most annoying whining coming from under the hood and sound like its coming from the secondary filter area or turbo (you can even feel it if you put your hand on the filter lines and housing) and it starts a minute or so after the vehicle has been running and you can her in the cab at 70-mph... At drive through restaurants I have to shut the tk down to place my order and never goes away..
[URL] .....
View 14 Replies
Advertisement
My first opportunity to really use four wheel drive and I am having a whine and a very slight vibration from the drivers side wheel. The noise is only noticeable under throttle/load. When I let off, there is no noise. The truck is also quite in two wheel drive.... No whine.
The truck has been to the dealer for a front end clunk that is coming from the drivers side. The dealer, as usual couldn't replicate it, and didn't do anything. I notice the clunk more on the rebound. I also notice it when using more of the suspension travel i.e. going over a apron into a shopping center, or the crown of a cross street when traveling at a good speed. Short choppy pothole bumps don't replicate the noise as easily.
If I had to guess... The two issues are related. Narrowing it down will be the key. Transfer case? Failing hub? If I don't spoon feed the dealer, I will never get it fixed.
View 10 Replies
So my 2013 is making a strange noise that seems to be coming from the front end when turning and going over a bump. While riding with the Service Writer, we also felt that the noise could be coming from the rear of the truck. I think it's two seperate issues, he mentioned something about the rear end noise being "body shift". So two questions:
1. What a "clunking noise" would be coming from around the steering column.
2. What the heck is "body shift"?
View 14 Replies
Okay so 2007 F350 DWR here, I have a driver who hauls loads using the truck and a 25' gooseneck trailer. She's gone through the bullet proofing process at 80K miles, she now has 128K miles. I have a programmer to monitor temps, and do all required maintenance.
With that said, my driver reported last week that when under load and going up hills he got the white spray coming out from under the hood. See pics below, this is never really good of course but I want to believe its not catastrophic. Two weeks prior I changed out the thermostat and upper radiator hose and of course flushed and filled coolant, all was good - no hoses were loose, etc. Driver reports the truck did not overheat at any time.
Both ECT and EOT are within 10-12 degrees of each other, and did not go over 190 for me while driving around town the other day. There are no codes present, I cleaned the engine bay and drove and re-inspected but can't tell where the coolant is coming from as none appears to be leaking. Last note, I have to admit after driving for a day or two I had to fill the degas bottle up about 3/4 gallon of water. My questions is, what is the next step for me in the diagnostic process?
View 13 Replies
There's a pump or ?? I'm not sure . Our "11 6.7 is making whining vibrating sound coming off passenger side , front of valve cover . Not sure what this is . Nothing I'm searching is telling me n I'm not best with diesels .
View 3 Replies
06 6.0L 205k
EGR, cat, and muffler delete
IPR replaced roughly 10k miles ago
New oil cooler roughly 15k ago
Replaced turbo Y up pipe 15k ago
Replaced radiator, idler pulley, and serp belt roughly 50k ago
I've got a strange squeal sound coming from under the hood only when truck is cold? It sounds like a bearing and after it gets heated up the sound stops. I talked with a guy thats a cummins guy and he said he had a similar issue and he had to replace the bearing in the turbo? Also when truck is warm it will still do it, like for instance, if I run in a store and truck idles for 5-10 mins it will do it only if I romp on it for a short while like 2-3 mins then again goes away. And if I'm idling or in neutral, hot/cold, it does not do it, it seems to be only under a load. Pull a 26 foot boat no problems.
View 7 Replies
What could be making the strange pumping sound coming from under my hood after I shut off the truck?? It sounds like a small compressor or pump running.
View 4 Replies
My 2011 F350 - 6.7 has developed this KRAZY thump, snap noise under the hood, loud enough to be heard inside the cab, and I cannot find out what the heck it is. It is not directly connected to the motor, you can rev it and the noise does not change. the thump is like, every few seconds or so, especially when the motor is cold. I am afraid this is a 2000 dollar noise and the truck is out of warranty.
View 8 Replies
I have a 2011 f250 6.7, I park under my house everyday, so I am used to weird noises coming from my truck when I shut it off, but now that I just did a dpf and egr delete, and tuner, I noticed that my tuner doesn't shut down until the noise under the hood stops, which takes a few minutes to stop, I use to hear the air valve on the egr cooler shut when every got quiet, but I don't remember it lasting this long, any one else have a H&S mini max and it doesn't shut down right away? the place where I bought my mini maxx said it should shut down as soon as your head lights go out, but that's not the case, the headlights go out long before this noise stops and the tuner powers off
View 10 Replies
Had Just replaced glow plugs and batteries along with a new set of tires. Truck had been running fine for the three days that is was. Went out the next morning and went to start and "POP" a large noise came from under the hood. I have yet to discover where this noise particularly came from or what it may have been that caused it. But ever since the POP it will not turnover what so ever. Key on every thing is normal all power just when go to turn key over it makes a faint click. You can feel the click in the relays on your hand when you try to turnover. But nothing. I am absolutely clueless.
View 14 Replies
I've got a stock '15 F250 6.7 w/ the Diesel Site FF67 fuel/water separator and a 50gal Titan Tank. I installed the filter + tank at the same time around 2 months ago; A few weeks ago, I started noticing an odd buzzing/whirring/gurgling noise (both while the truck was running, and while the fuel pump spins up right after turning the key on). I made a quick video of it this morning:
Ford F250 6.7 w/ Diesel site filter DFCM buzzing/whining - YouTube
I thought maybe it was a filter related problem (I got some little black plastic bits in the filter after installing the Titan Tank, despite my best efforts to clean it out thoroughly before installing) - so earlier this week, I replaced both stock fuel filters, and both filters in the DS filter. Didn't seem to affect the noise from the DFCM at all.
I guess my question is - does it sound like this is sucking in air? I've never found any leaking fuel (even after a 3000mi drive from TX to VA and back), and the truck has never complained about low fuel pressure as I've read that some others have run into. But I don't remember the DFCM/low pressure pump being this loud before I installed the new parts.
I spoke to the folks at DieselSite a day or two ago (those guys are great), and they mentioned that sometimes the Ford quick-release fittings work themselves a little loose from the fuel hose during the filter install, and that putting a hose-clamp around the hose+quick release fitting may solve this; I ordered from clamps from McMaster Carr that arrived today, so I may give that a try tomorrow just to see if it changes anything.
View 14 Replies
When I start the cold engine mine makes a loud whining noise. I took it to the Ford dealer and they said that the sound is normal and that it's the turbo's. I think I'll take it to another ford dealership and get a second opinion, The service guy has the same truck as me and his was making the same noise on cold start up and they told him it was the turbo's also. Something's not right about the noise.
View 14 Replies
My truck's been doing this ever since I got it when the engine is cold. Haven't brought it up to a dealer yet because I'm not sure it's a real problem, and since it only does it when it's cold I'd have to leave it overnight.
It seems to happen when the turbo hits a certain RPM. I got it on video but you can't really hear it until the end when I raise the RPMs a bit.
YouTube - VID 20100926 104950
View 14 Replies
So I have a 2008 Chevy Impala LS that hasn't given me any real problems. I had some battery troubles recently that were the result of me leaving the parking/security lights on for 10 consecutive hours, but overnight-charged the battery and was good-to-go after that. But it seems like RIGHT after that was when the whining noise started.
It seems to be related to my power-steering system. I know this since the whining seems to pick up with acceleration and turning. However, I checked my power steering fluid and it did not appear to be depleted at all. I did notice, however, that it seems to be a light greenish color...which from doing a google search, I've gotten the impression that it's probably not supposed to be that color.
What exactly is going on here?
View 4 Replies
A few weeks ago I started noticing what I would best describe as a whining noise when I accelerate. It's not very high-pitched but definitely noticeable. It seems the more I accelerate, the higher pitched the whine becomes, and I can only hear it when I am accelerating. It is not very loud: if I have the radio or stereo on I can't hear it. I have a 2009 Corolla LE with around 122k miles on it (I drive a lot for work.) A few weeks ago I had the car in for an oil change, and was told that my battery was getting low and will need to be replaced soon, so I'm not sure if that would have anything to do with it. As far as describing the specific location of where it is coming from, the best I can say is that it's coming from somewhere under the hood...I know that's a very vague description, but I can't really pinpoint it to anywhere beyond that.
View 3 Replies
I have 2013 f350 crew lariat 4x4 6.7 5000 miles . Cel coming on about 300 miles apart , 4th time now same code p054f ,dealer ship has no answers. Thayer say ford is investigating it ?? I don't about that but it is a real pain bringing it in.
View 1 Replies
I have a 2013 F350. Since it was new in August the turbo has made a chattering sound that sounds to me like the waste gate (if it had one) is opening and closing rapidly. Almost like its building boost and dumping it over and over again. Usually happens when it is in 6th gear around 1700 rpm under light load. It also does it from time to time while plowing snow. You can power through it or let off and it will go away. My local dealer where it was bought new put a new turbo on it and the problem still persists. The truck just turned over 8k miles and has been in several times in attempt to resolve the issue. They say that there are no codes on the truck nor does Ford have anything on their service web. My dealer claims that no one has ever had the issue.
View 14 Replies
I have an intermittent noise that I believe might be transmission. Here are 2 recordings first with nose and second without. I haven't the mic behind the front wheel and I walk around the front to the passenger side.
[URL] ....
View 6 Replies
I've got 2013 es 350 with 10,000 miles on now. I have recently noticed that there was whining/whirring noise coming from the engine(I guess) while accelerating up to 45 mph. It seems that the noise goes along with the RPM since it gets louder when accelerating. It makes same noise when decelerating from 30 mph and it goes away when the car stops. A friend of mine drove the car once before but did not hear anything until I told him about the noise, so I guess it is not very noticeable to some people. At the 10,000 miles check up at the dealer, I mentioned about it and they said they did not hear anything, but I know for sure there is whirring/whining noise.
View 14 Replies
My power steering pump was making a loud whining sound. No problem, changed the pump. Now after the truck is started I will have no power steering or brake assist, give the truck a little gas and you can hear the power steering pump "start". I have tried every way to get the air out, or is that not the problem. I even lifted the front of the truck off the ground with a forklift and with the truck off turned the wheel about six times stop to stop. Fluid level looks good and has since adding after the change.
View 4 Replies
I got a little oily residue on my hood here. It looks like it might be a little wet near the coolant hose & throttle body area. I also have the H&S Intercooler pipe kit installed. Not sure how long this residue has been there, but it is still wet, so its not all hardened. Maybe it's just loose intercooler pipe bolts?
View 7 Replies
