Ford 6.7L Power Stroke Diesel :: 2011 - Typewriter Like Noise At 36k Miles?
Aug 20, 2012
So, I recently had my 4th oil change done at the dealer, just under 36k miles. Same dealer that has done /all/ service on my 2011. They used the same parts and materials as always, but this time there is a very noticeable "typewriter" sort of noise at idle. Much louder than the normal chatter, and not consistent - tick.... tick-tick... tick.... tick... tick tick tick... etc. The diesel tech shrugged it off: "Ford says it's nothing to worry about." As it has never happened before, and it sounded a /lot/ like lifter noise resulting from a low-oil condition, I asked him to put in another quart. He did, and the noise went away. Mostly.
Now I've only driven about 75 miles since the oil change, but the last time I drove it, I had the windows down and noticed what sounded like lifter noise again. Not the same pattern at idle. This time, it was under light acceleration and the frequency increased with engine speed. It's going back to the dealer in the morning. Not only for this, they're also on their third attempt in the past 2 weeks at fixing a squeak in the dash. But while it's in, I want this noise to go away.
In spite of all the posts about how this sort of noise it typical with new oil, and goes away in 10-2000 miles, I'm concerned. Nothing has changed other than the fresh oil and filter. In the last 3 oil changes, this condition never existed. Am I being reasonable?
View 14 Replies
Advertisement
I just got a used F350 with 28k miles I cleaned the battery posts and checked all fluids, changed the fuel filters just in case they were due ( they looked pretty clean), air filter is a WIX had a bunch of bugs in it but still pretty clean... oil monitor says oil OK and filter looks too clean to be that old. It looks like a coolant leak at the turbo was fixed about 1000 miles ago or so and dealer said coolant would have been changed out at that time.
Am I missing anything I should do or check?
View 14 Replies
Driving to work yesterday my engine shuttered and then shut off. The Display said low oil pressure and then powered down, all in about 15 seconds. Dealer called me today told me the engine is blown and is in the hands of Ford now. The only thing he told me was sit back and wait, I can not tell you how long it's going to be. but I am going to be screwed as far as work goes.
View 14 Replies
2011 Super Duty, SB, 6.7, Lariat, SuperCab, FX4 Undercover hard bed cover, Ford bed mat, and mud flaps.Traded a 2003 Expedition with 100k miles on it. It was time for a new tow vehicle, I tow a 30 foot travel trailer.(7000 to 8000lbs) The dealer offered me a deal at invoice plus all of Ford's incentives, so I couldn't refuse.
I have about 1300 miles on it and it runs fine. I have been noticing a wet spot under the right front of the truck, checking today it looks like anti freeze leaking from above the air condition pump. It makes about a 3 inch diameter wet spot, the fluid recovery bottles are still at the correct cold coolant level. I couldn't get my hand in that space to find where it is leaking from.
View 14 Replies
Ive had my 2011 for 20 months. I have 7,300 miles. I know the manual states changing around 22k but do you think time is a factor as well? I wont hit 22k for two years. Truck will be 3.5 yrs old. Should I just change them at 10k and see how they look? Don't want to waste the money either if its unnecessary. I use it 50/50 towing/unloaded.
View 8 Replies
I have a 2011 in the shop for a fuel leak. Truck has 208,000 miles on it. Leaking fuel into the valley. I took the upper and lower intake off and cleaned all the fuel up so I could see and with the key on there is fuel coming out from the bottom of the CP4 area where it mounts to the front cover. Looks like there is an o-ring between the front cover and the CP4 but wouldn't that o-ring be for sealing oil and not fuel? I'm confused as to how this works. Truck runs great with no check engine light. It's not a fast leak but a drip drip drip from the bottom of the engine once it fills up the valley enough to run off the back of the engine.
View 14 Replies
I had an issue with my 2011 6.7 this weekend and I'm clueless after doing the google search for info. My truck started overheating after driving it about 10 miles in tow with a light load (20 foot boat). So my first panic reaction is to stop and check the fluids which all check out as good on the levels if I am checking them correctly.
So it cools off and we go for another spin and now that I am paying more attention I notice abnormally high RPMs before it shifts into all gears and that the heat seems to be a by product of this. there is no abnormal vibrations of any type but it sounds like someone learning to drive a standard for the first time.
I does it almost every time. So I tried the manual shift option and it had no problem and no overheat. If it reaches the 6th gear without the overheat alert posting it runs fine but getting there seems to be an issue.
In the back of my mind I do remember hearing this high RPM before but I have a short drive to work and back so I didn't think much about it as I have definitely keyed in on it now. I have only had the truck a year and I do not know when the service was done last on the Transmission.
View 8 Replies
My 2011 6.7 just started making a hum noise after shutdown. I've read that it might be the wastegate solenoid. Is there a TSB for this. My truck is tuned so hopefully my dealer will be tuner friendly.
View 14 Replies
My 2011 SD started clunking while in 4x4 this weekend. I was on an icy road for about 120 km driving about 60-80 kph and once or twice noticed a random clunk. Didn't think much of it.
Fast forward to following day - get truck on an icy hill where I had to make a sharp turn. Put truck in 4x4, turn off ATC by holding button 8 seconds. Only rear wheels engage. So then try 4 LO. Same thing. Straighten wheels, shift to park, engage 4x4 again and she hooks up and drives out no problem. Further down the road (still in 4x4), it fish tails slightly and then check 4x4 light comes on. In order to get 4x4 re-engaged (was spinning at a stop light on a slight incline) I had to shut truck off and restart it. Then it seemed to work normal and light went off.
Little further down the road I had to go up a steep incline and at a steady 40-50 kph I started hearing (and feeling) a noticeable clunk every few hundred feet. Seems to be coming from rear of truck but honestly cannot say for sure. Goes away when in 2wd.
I have 7000 kms left before warranty expires luckily.
View 14 Replies
2011 F350 diesel with 10,000 miles. I have been experiencing problems with the truck loosing power, making rough running noise (pinging like an older diesel), and vibrating. As though the motor is bogging down. It usually occurs on small inclines or hills with the truck in higher gears and low rpms. It will also occur running on flat ground 65-70 mph. Had it occur once while turning the truck around in 1st gear and low rpms. Depressing the accelerator will bring the truck out of it.
This problem occurs randomly sometimes a couple of times a week to not at all. Took to dealer and they found no codes and of couse it didn't do it on the hour long test drive I took the mechanic on. However they did say they had two other owners come in with the same complaints, but could not get trucks to repeat the issue. Problem usually occurs in the hotter part of the day, maybe just coincidence. I had seen similar posts with this problem but no conclusions.
View 14 Replies
I've got a 2011 F350 Lariat crew cab and when i get up to 75 mph with a cross wind, there is a whistling noise. it sounds like a turbulent whistle as if its blowing across the ribbed portion down by the wipers. I tried to get audio but for some reason my phone wont pick up the noise, but its extremely loud at times. Sometimes it will wake up the kids if they're napping in the back seat.
View 14 Replies
My 2011 F350 - 6.7 has developed this KRAZY thump, snap noise under the hood, loud enough to be heard inside the cab, and I cannot find out what the heck it is. It is not directly connected to the motor, you can rev it and the noise does not change. the thump is like, every few seconds or so, especially when the motor is cold. I am afraid this is a 2000 dollar noise and the truck is out of warranty.
View 8 Replies
I have a 2011 that does not currently have the complete factory exhaust system on it and no muffler. With the nice weather I have been driving around with the windows down and hear a noise out of the exhaust that sounds like tires spinning on wet pavement when I let off the throttle or at some shifts of the transmission. Boost seems normal, and don't hear any noise while under load. I think it is just the VGT closing and making the noise. With deleted sys heard this noise in exhaust?
View 4 Replies
heard a loud squealing noise and now no boost. 2011 with 90k miles
whats my options and what would it cost.
1. replace with factory turbo
2. replace with upgraded turbo and tune?
View 8 Replies
My buddy has a 2011 250 and is having some weird issues with a clicking noise. It started out when you put the truck in gear (D or R) and touch the gas it would click. Seems to be coming from the middle to rear part of the truck. Now it clicks when he's driving. This all started after he got 35's and a leveling kit. It's taller springs in the front and added a block in the rear. It has less than 15k on it.
View 14 Replies
When I start the cold engine mine makes a loud whining noise. I took it to the Ford dealer and they said that the sound is normal and that it's the turbo's. I think I'll take it to another ford dealership and get a second opinion, The service guy has the same truck as me and his was making the same noise on cold start up and they told him it was the turbo's also. Something's not right about the noise.
View 14 Replies
I have a 2011 F250 6.7 Turbo Diesel I recently purchased. I am hearing a noise when accelerating from a stop. The only time I'm hearing it is when the window is down. The noise sounds like someone is tapping an aluminum pop can. It is easily reproducible as well. I decided to get under the truck and have my wife toggle the transmission from park to reverse. They noise does not occur unless one foot is placed on the brake and the accelerator is lightly pressed. (My wife had the opportunity to run me over and claim it as an accident but lucky me she decided not too). Below is a video. I had a hard time locating the noise. It sounds like it may be coming from the exhaust or drive shaft. The drive shaft does not spin when toggling from reverse to drive but the ticking noise can be simulated and heard when lightly pressing the gas while holding the brake. Something need lubed somewhere?
Clicking noise - YouTube ....
View 4 Replies
Got my first CEL at just under 40K miles. P4023, Redundant temp sensor range, so looks like I get a new DEF tank sensor. Of course they are on national back-order still. One would have thought that Ford would finally have these in stock but no.....
View 8 Replies
I have a 2012 F250 6.7L with about 62,000 miles on it. I purchased this truck new in October 2013. I had my first check engine light last Friday. I scanned it and it was a P20BD (Reductant Heater "B" Control Circuit/Open) is what I found when I searched for it. I had the truck in on Tuesday to the dealer. They are telling me it is the Reductant Pressure Line and the repair will be $690. They didn't have the part so I picked up my truck and have an appointment scheduled for Monday.
Since picking the truck the check engine light hasn't returned. I find this odd and it makes me wonder if they are correct or not in their diagnostics.
The other question I have is isn't the DEF system part of the emissions system? If so why isn't it covered under the emissions system warranty until 80,000 miles or 5 years?
View 6 Replies
Well so far I have had this truck for 5 years and I'm going for the third set of tires. So far I have run Nitto terra grapplers, and currently BFG at ko's. Both sets wore out around the 20,000-mile mark, they both wore very evenly, rotated every 6,000 miles, properly inflated, check the lineup at 2 different reputable shops.is it something about the 275-65-20s that make them wear faster? I really don't need an at tire as I don't go off road that much so I'm thinking of a good all season radial.
View 14 Replies
Fan Clutch went out today 47,000 miles.
View 5 Replies
