Looks like now the radiator in starting to seep a little between the core and the plastic sides. Couple questions. Whats the best replacement that wont cost a ton. Would this have anything to do with the intermittent not starting when warm.
View 6 RepliesPlastic coupling between core and hose, is there a specialty to needed to remove from heater core?
View 1 RepliesOn our '04 Ex with 195 on the clock I've discovered a pretty good leak dripping. I crawled under it an coolant appears to be dripping off the back of both exhaust manifolds.
Less than 1000 miles ago we had an oil cooler and egr was pulled and freeze plugs installed by an excellent well respected 6.0 diesel shop. I don't think both gaskets could have blown at the same time creating two leaks. It runs fine, degas bottle still has coolant in it.
I've seen other threads that point to the heater core hose and more commonly the "orange" egr hose. It appears that an egr delete removes the hose - I think... but would that Blue / orange hose be there if the cooler was just capped and electrical unplugged?
The shop is going to look at it Monday but I'm trying to understand it better ahead of time.
I've been having transmission fluid leak from my truck for a while now. Very slow leak. At first I thought it was a hard line and replaced it but it was still leaking. Then I think I found where it was coming from. It looks to be fluid dripping on the bottom of both sides of my intercooler? On both identical spots. I am guessing perhaps I had a crack on my transmission oil cooler and driving blew it into the fins of my intercooler. I took my old one off and couldn't visibly see one. I have a brand new trans cooler installed now. Haven't drove yet as I am waiting on brake parts? I couldn't think of anything else on why it would leak off the intercooler?
View 6 RepliesWhat it is or why there is a three inch pull handle hanging down on the bottom of the Diesel Tank on my niece new 2012 F350??? It is sitting hanging there begging to be snagged and ripped off the bottom of the tank!!!!! I'm at least going to Gorilla Tape it up to the bottom of the Tank.
View 10 RepliesA couple of weeks ago I got a service engine soon light and it turns out that the egr cooler core was bad. I had it replaced this week under warranty but now this has me thinking that maybe in the long run I would be better off to tune the truck. I had not even considered it until now, but this is a truck that I plan on keeping and I think that all of this emissions crap is shortening the life expectancy of the truck, at least without dumping money into it on a regular basis. Would this have been caused by anything that I have done? Am I not driving the truck hard enough maybe?
View 2 RepliesI had my truck at the dealer a while back while it was still under warranty and I told them that it was leaking around the oil pan. It was bad enough to coat the pan in oil, but no drips on the floor. They claimed no issue and sent me home. Well now my warranty is up and it's dripping on my shop floor. It is weeping out around the bolt heads.
I'm going to call the dealer in the morning and see if they will work with me since I did have it in under warranty for this same issue.
I have a 2011 f450 that I just bought and it has the plastic oil pan. I see that the newer 6.7 have the metal lower oil pan. Is there a good reason to change over to the metal pan? Is the 1/4 turn drain plug the problem?
View 13 Replies, 211,000 miles and the third radiator that was put in this truck is leaking!! Has there been a recall This is not right. I haven't even had the truck five years and this will be over 5 grand in radiators. Is a person suppose to budget an extra grand a year if they want to own a ford diesel?
View 14 RepliesI thought I remember a posting about removing the radiator to do the cooler because it made it easier to work standing in the engine bay with the engine in front of you instead of leaning over and removing everything from outside ? I'm getting ready to do my 4th external oil cooler? And is it difficult to remove radiator, and/or worth removing it ?
View 14 RepliesI was just outside and noticed a little puddle under the front of the truck. I crowled under her to find orange coolant on the seam of the radiater right above the drain. I thought maybe the drain was open a little but no, it was tight. I have 40000 miles on the truck.
View 14 RepliesHow many of you put a screen in front of all your radiators to keep bugs and stuff from clogging them up? Is there much of an air flow restriction (from the screen)? It is about the first thing I always do when I get a new vehicle.
View 5 RepliesRead that this is a common issue, leaking out crimped seam on lower LH (2012 F250 King Ranch). I have called Ford customer service twice, they said "we do not have any recall or programs to cover the out of warranty repair". I keep adding coolant and thinking eventually Ford will address this problem. They did cover my bad EGT sensor....
View 9 RepliesI am in the middle of a several thousand mile road trip, and I am with family in Utah when this evening I noticed a puddle under my 6.0 Excursion.
Coolant leak? - YouTube
The fluid does not smell like typical coolant, but from the location of the drip, I cant think of it being anything else.
Recently turned 100k and since have had my exhaust RTD's go out. While fixing that they found the back radiator leaking. Since then both batteries died which didn't surprise me at 40 months. Then my windshield washer started leaking, then my DEF heater went out and two days ago my AC quit. I was ready to buy a new 2015 but now not sure. I've contacted Ford customer service and they are getting with the dealer to see what they may cover but haven't heard anything back yet.
Mine is a 2011 with 105,000 on it. This is pretty frustrating. I have been very pleased with this truck up until now it has been very dependable. However when that dependability begins to go south at only 100k it brings to question what exactly are we paying for here? A heavy duty truck that costs upward of 60k should be one you can count on for a lot longer than that. How Ford approaches this with me is definitely going to have a direct bearing on which 2015 diesel truck is in my driveway in the next few months. Again let me say that i have been very pleased with this truck and FOMOCO in general.
Ok I now have the dreaded leaking radiator on my 2011. I am wondering how the aftermarket radiators are holding up? I was talking with my local radiator repair shop and they have been repairing the oe radiator with good results. They also claim that they have repaired some aftermarket radiators. He did not mention any brand names so I can not make any claims against them. I am considering a mishimoto replacement.
View 14 RepliesRemoving the radiator on these trucks to repair the leak? It looks pretty straight forward. Remove the fluid, grill, hoses, and the few screws on each side that connect the other cooling coils to the main radiator. then hopefully it should slide straight up and out. A radiator shop said they would replace the gasket between the plastic end caps and the radiator if I take it to them. Which brings me to my next question. Is it the gasket that is causing this notorious leak or is it a crack somewhere or a loose crimp? Mine is leaking from the usual spot. Driver side on the bottom at the seam. Then runs down the frame to the ground.
View 6 RepliesIn April I replaced the radiator, hoses, water pump and Tstat. I used Mishimoto for the radiator and hoses (silicon). I am having trouble with the hoses leaking where they clamp to the radiator. I put 2 on the lower hose and that seemed to work. No other signs of leak on than drip from the top hose - factory clamp is on and tight as I can turn it - still lost a gallon in 2-3mo. Should I just get a new clamp? OEM stuff was not this prone to leaking ....
View 14 RepliesAfter chasing the smell of coolant for a couple weeks, discovered that the upper radiator hose was leaking at the engine. Based on my schedule and drive schedule, and unfamiliar location this last week, I took my truck to the last people I wanted to - the Ford dealer, where they attempted to charge for the hose replacement. During this time I discovered the nature of how these hoses work and asked the tech why they don't just replace the O-rings ... "Ford Motor Company wants to sell you a new hose with labor" - a direct quote from the Ford tech. And that is why Ford is the LAST place I want to go for repairs I cannot perform. I kept the old hose - any spot where you can get the O-rings alone?
View 5 RepliesNoticed this past month on colder days my upper hose is collapsed, typically a symptom of a bad radiator pressure cap.
This hose is connected from the water pump to the radiator. The radiator is connected to the Degas bottle which has a nonstandard radiator cap.
Do these plastic caps vent the same way a typical cap does?
Cap for 2011 Ford F-350 Super Duty|9C3Z-8101-B
This weekend while towing a light load I noticed my FWT and EOT starting to climb rapidly, EOT reached 260 FWT I think about 240. I exited the interstate to find I had a busted radiator hose. I replaced the hose and filled the system with distilled water, but didn't add antifreeze at this time. The system wasn't completely empty.
I noticed once back on the road my EOT seemed to be higher than normal but FWT seemed to be normal. Could the lack of antifreeze cause a greater delta between FWT and EOT? I have seen articles which state do not use Ford Premium Gold Coolant, but to use CAT EL-1 coolant instead. Which should I use?