I'm hoping it's a small simple fix when I climb under the hood. Has happened before, but was an easy fix. The smell is much stronger this time. Any major problems any of you have had if I can't find the culprit?? Learning as I go...always up for checking on every possibility.
2004 F250 SUPER DUTY 6.0 ......
no change, changed stand pipe and dummy plug on driver side, no change and guess what? Now I am stuck on the side of the road waiting to give my last $100 to a tow truck! Engine is hydrolocked, fuel pressure is low, starts off at around 20 and works up to 54 with key on engine off, and that is as much as I know from the side of the road with out my AE. Blew white smoke also. Smelled of unburnt diesel. I think it's linked to my rough running issue. Maybe a bad injector? But every time I did the click test they all passed. Idk, I'm gonna remove the glow plugs and see which hole is loaded and with what. . .
View 14 RepliesOk, finally smelled the smoke and its fuel. Now, it only smokes when idling and in drive! If I put it in park it don't smoke! What in the world is going on?
View 11 Replies2004 6.0. 160K miles.
I'm about to replace an injector and wanted baseline info on fuel pressure before doing the work. Using a gauge tapped into the top of an aluminum alloy fuel filter cap (from bulletproof diesel), I turned the switch key on but did not start the engine.
Static pressure jumped to 60psi, but as soon as the pump cut off the pressure dropped off to zero. Again, engine not started. I cycled the key off and back on and the pressure hit 60psi and held that until the pump cycled off, then dropped back to zero.
I'd like to get a few confirmations that fuel pressure should or should not fall off when the pump kicks off.
Side note, during the crank process the pressure jumps and holds at 60psi and stays at 60psi while idling. I have not conducted a dynamic road test yet. Didn't have the adapter to connect my long hose...
I have been smelling fuel on and off for the last few weeks. I thought it was the fuel bowl drain valve so I ordered the kit for the whole fuel bowl from diesel o-rings. I did the rebuild this morning and I don't see any visual leaks. Still smell a strong odor of diesel though. The lower engine cradle is all wet and the valley is still a little wet too. Could I still have a leak and if so where to look? Could it be just wet still from draining the fuel bowl and needs time to go away?
View 14 Replies2011 F250 6.7 Had the fuel filters changed by the dealer today. No noticeable sounds when I left the dealership, & no fuel stops on the way home (120 miles one way). When I got home, before shutting off the truck, I heard a loud groaning/singing from inside the truck. With the truck still running, I get out, & the groaning/singing is very pronounced....never heard this before & appears to be emanating from the fuel filter underneath the truck.
I turned the truck off, then turned the key back to the position that the fuel pump turns on, and wow, the pump is very loud. Definitely something going on because when I turn the key for the pump to turn on but not start the truck, I can feel the vibrations of the pump working from inside the truck and when listening from underneath the truck, it is very loud. Before today, the truck never made this noise and never heard the pump before.
I've thought I smelt diesel fuel on an off for a while, but never found the source.
Tonight, 17 degrees out I have fuel in the valley and it appears as if the back of the drain valve is wet.
A fuel bowl rebuild is on the short list. Is this typical, the cold weather brings the issue to light?
For the last four months my 04 F350 has been having the same problem every now and then. Cruising down the highway at a decent speed and the fuel pedal/fuel shuts off. Only lasts seconds then re-engages. Two lights come on. Low fuel and water in fuel. I changed the internal fuel pump last week and it did it again tonight. The truck runs great otherwise except for an occasional death shake while stopped at a light. No codes came up and FICM is at 54.
View 14 RepliesMy truck ran great when I got to my house that I turned it off and tried turning it on again it wouldn't turn on I check the fuel pump it works I checked the injector if it was getting fuel it was .I'm a stand still, where else to check? What to do?
View 14 RepliesI have been having trouble w my 04 I checked all fuses all relays all dash lights work, no buzzing on injectors when key turned on. I checked push pull plug for starter it turns over with direct to battery but still does not start. New computer on fender.
View 2 RepliesSo I'm stumped I have an 04 6 liter and I have no power to my fuel pump. My fuse under my Dash is good which is a 20 amp fuse which is number 40. My inertia switch is not tripped and I have power to it however my fuel pump does not have power what else could it be? Is there a relay somewhere else?
View 5 Replies2003 CC 4x4 ... I am pretty sure I know what is going on, but I wanted to start a thread for when I confirm it. I am driving to work this AM and I hear the door ajar chime and I think to myself, uh oh...gauges all look good, there are no lights illuminated on the dash. I get to work and turn the truck off and my fan stays on. I think the ignition module is going bad. Either that, or my remote start is going on the fritz. I will update when I find out more.
View 3 Replies2004 f450 with 6.0. Was driving down the road when it started losing power like it was starving for fuel. It carried on for about a mile then died and will not start. No codes at all and we put a new fuel pump on but still wont start. Put a rag with gas in the air box and will run but rough.
View 6 RepliesHere in the last week or so I have noticed what seems like loss of power in my 04 F250. When I get on the gas it doesn't seems to respond like it used to. When I turn off the truck i can smell diesel a little bit. could it just be a clogged injector, bad plugs or what?
View 2 RepliesI recently was informed by my local mechanic that fuel was leaking into my coolant. He said I had a cracked head based on this and it would give soon. Well, he was right, and now I need to do a head job. I found new heads, but would like to know how many book hours this should take before I proceed. He gives me a wide range of time, and don't want to get taken advantage of.
View 4 Replies2004 6.0 and I put in a new WIF sensor and took off the cover and cleaned the junk out but it still comes on after a minute or 2. What am I missing??
View 3 RepliesI have a 2004 Ford F350 6.0. It is leaking diesel from the front of the engine to the ground. I have a video of this and pictures as well but I'm not sure what I'm looking at. What I can do??Puddle after about 20 min of running.
Dripping from here, left of hose....
I have a'04 f-250 6.0L diesel truck. There are times when i come to a stop that my truck sputters like if it's about to run out of fuel or want to shut off but the tank is full or half. If i am going at a fast pace and then begin to slow down and stop it will sputter.
View 3 Replies2004 F350 4x4 6.0 ... No start... changed fuel pump... lots and lots of bubbles in fuel filter canister.... what to check now... running fuel from external fuel tank not tank on truck... after crank no start fuel disappears from canister.
View 2 RepliesI have a 2004 F-250 changed out both fuel filters and now can't get it to run. It will start up and run for about a minute then stall out. I have cycled the key/pump numerous times with no luck. When I look into the fuel bowl when I engage the pump it looks like it's pushing more air rather than fuel. It seems to be burning the fuel in the bowl and then stalling out. When I take the bowl cap off after it stalls it's empty.
View 14 RepliesFor the second time in 6 weeks My 2004 F250 Powerstroke has run out of fuel with the gauge showing a 1/4 tank. First time it was just under a 1/4 showing I had it towed to dealer and they told me it had sucked in the filters requiring replace and flush of system. The told me that this happening very often and I would be replacing all of the injectors at my cost. I told them that I didn't want this to happen again and to check out the fuel gauge and sending unit and replace if in doubt. Well they checked it out and found nothing wrong, told me it was accurate and should not be an issue again. Now 6 weeks later on the Friday night before a holiday, it did it again, this time with over a 1/4 tank showing. I really don't want to spend 6 grand replacing injectors and would really like to trust my truck again, getting to the point that I'm nervous at 1/2 tank.
View 9 Replies